Invacare 3750 manual

Owner’s Operation and Maintenance Manual DEALER: This manual MUST be given to the user of the tub. USER: BEFORE using this tub, read this manual and save for future reference. For more information regarding Invacare products, parts, and services, please visit www.invacare-ccg.com Recessed Side Entry Bath Tubs Model 3750 Model 3800 AFTER INSTALLAT[...]

Recessed Side Entry Bath Tubs 2 Part No 1150695  WARNING DO NOT USE THIS PRODUCT OR AN Y AVAILABLE OPTIONAL EQUIPMENT WITHOUT FIRST COMPLETELY READ ING AND UNDERSTANDING THESE INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTION AL MATERIAL SUCH AS OWNER’S MANUALS, SERVICE MA NUALS OR INSTRUCTION SHEETS SUPPLIED WITH THIS PRODUCT OR OP TIONAL EQUIPMENT[...]

TABLE OF CONTENTS Part No 1150695 3 Recessed Side Entry Bath Tubs TABLE OF CONTENTS SPECIAL NOTES ................................................................................ 5 LABEL LOCATION ............................................................................ 6 TYPICAL PRODUCT PARAMETERS ................................................[...]

TABLE OF CONTENTS Recessed Side Entry Bath Tubs 4 Part No 1150695 TABLE OF CONTENTS Safety Inspection Checklis ts ................... ............................................. .................. .................................29 Initially ..................................................................................... .................. [...]

SPECIAL NOTES Part No 1150695 5 Recessed Side Entry Bath Tubs SPECIAL NOTES Signal  words  are  use d  in  this  manual  and  apply  to  hazards  or  unsafe  practices  which  could  result  in  personal  injury  or  property  damage.  Refer  to  the  following  table [...]

LABEL LOCATION Recessed Side Entry Bath Tubs 6 Part No 1150695 LABEL LOCATION    ?[...]

TYPICAL PRODUCT PARAMETERS Part No 1150695 7 Recessed Side Entry Bath Tubs TYPICAL PRODUCT PARAMETERS 3750 3800 MINIMUM SPACE REQUIREMENTS: 7 feet x 6 feet LENGTH EXTERIOR: INTERIOR: 59½ inches 49 inches 59½ inches 49 inches WIDTH EXTERIOR: INTERIOR (SEAT): 31.5 inches 21 inches 31.5 inches 21 inches DECK HEIGHT: 41.5 inches SIDE ACCESS DOOR: 40-[...]

FEATURES Recessed Side Entry Bath Tubs 8 Part No 1150695 FEATURES 3750 Control Panel Tub Interior Flow Water Therm ometer Tub Exterior Service Access Door Door Door Handle Drain Drain Plug Burp Fitting Whirlpool Jets Control Panel (See Above) Shower ON/ OFF Valve Whirlpool Aerator Valve Water Temperature Control Valve Tub Fill Valve Whirlpool ON/OF[...]

FEATURES Part No 1150695 9 Recessed Side Entry Bath Tubs 3800 Control Panel Tub Interior Flow Water Therm ometer Tub Exterior Service Access Door Door Door Handle Drain Drain Plug Burp Fitting Whirlpool Jets Control Panel (See Above) Shower ON/ OFF Valve Whirlpool Aerator Valve Water Temperature Control Valve Tub Fill Valve Whirlpool ON/OFF Button [...]

SECTION 1—GENERAL GUIDELINES Recessed Side Entry Bath Tubs 10 Part No 1150695 SECTION 1—GENERAL GUIDELINES  WARNING SECTION 1 - GENERAL GUIDELIN ES contains important information for the safe operation and use of this product. Check  all  parts  for  shipping  damage  before  using.  In  case  of  damage, [...]

SECTION 1—GENERAL GUIDELINES Part No 1150695 11 Recessed Side Entry Bath Tubs Electrical Be  certain  ALL  electrical  wor k  is  performed  by  a  qualified  electrician  and  is  in  compliance  with  local  electrical  codes. ALL  electrical  connections  are  to  be  wa t[...]

SECTION 1—GENERAL GUIDELINES Recessed Side Entry Bath Tubs 12 Part No 1150695 Maintenance and Inspection  DANGER ELECTRICAL SHOCK HAZARD. All disasse mbly and maintenance of the tub MUST be done by a qualif ied technician, certified electrician or plumber. Disconnect electrical supply or turn o ff circuit breaker befo re performing any mainten[...]

SECTION 1—GENERAL GUIDELINES Part No 1150695 13 Recessed Side Entry Bath Tubs Operation  DANGER Keep hair and body away from su ction guard when pump is running. The causes, symptoms, and effects of hyperthermia may be described as follows: Hyperthermia occurs when the internal temperature of the bo dy reaches a level several degrees above the[...]

SECTION 2—PARTS AND INSTALLATION Recessed Side Entry Bath Tubs 14 Part No 1150695 SECTION 2—PARTS AND INSTALLATION Parts Information For  parts  information,  please  contact  ICCG  Te c h n i c a l  Service  at  (800)  668 ‐ 2337. About Installation  WARNING Access for servicing the tub MUST be provid ed. If [...]

SECTION 2—PARTS AND INSTALLATION Part No 1150695 15 Recessed Side Entry Bath Tubs Installing the Tub  WARNING Protective eye wear MUST be worn when dri lling to avoid possible eye injury. The tub MUST be supported by the floor and not the deck. NOTE:  For  this  proced ure,  ref er  to  FIGURE 2.2,  FIGURE 2.3  on  p[...]

SECTION 2—PARTS AND INSTALLATION Recessed Side Entry Bath Tubs 16 Part No 1150695 13. Model  3750  Only ‐ P erform  the  following  steps  to  install  the  shower  wan d: A. Determine  the  mounting  location  for  the  shower  wa n d  and  mark  this  on  the  w all. ?[...]

SECTION 2—PARTS AND INSTALLATION Part No 1150695 17 Recessed Side Entry Bath Tubs Electrical and Plumbing Hook-up Locations on the Tub NOTE:  For  this  proced ure,  ref er  to  FIGURE 2.5  on  page  17. NOTE:  For  installation  deta ils  ref e r  to  Electrical  Installation  on  page 18 [...]

SECTION 2—PARTS AND INSTALLATION Recessed Side Entry Bath Tubs 18 Part No 1150695 Electrical Installation  DANGER When using electrical prod ucts, basic precautions shou ld alw ays be followed, including the following: RISK OF ELECTRIC SHOCK. Connect the b athtub only to a circ uit protected by a ground-fault circuit-interrupter (GFC I). Use a[...]

SECTION 2—PARTS AND INSTALLATION Part No 1150695 19 Recessed Side Entry Bath Tubs 6. Open  the  service  access  panel  to  access  pu mp  electric  connections  (Detail  “ A”). 7. Route  electrical  line  through  electrical  line  routing  hole.  Refer  to  Electrical  and ?[...]

SECTION 2—PARTS AND INSTALLATION Recessed Side Entry Bath Tubs 20 Part No 1150695 Plumbing Installation  DANGER Be certain all plumbing work is perfor med by a qualified plumber and is in compliance with local codes.  WARNING Some state and local pl umbing codes require the install ation of a “reduced pressure zone” (RPZ) assembly on bo[...]

SECTION 2—PARTS AND INSTALLATION Part No 1150695 21 Recessed Side Entry Bath Tubs 10. Check  for  leaks  in  supply  or  drain  lines  and  check  operation  of  tub.  Refer  to  Operation  on  page 22. NOTE:  Check  local  codes  re g ar d i n g  maximum  water  temperature [...]

SECTION 3—OPERATION Recessed Side Entry Bath Tubs 22 Part No 1150695 SECTION 3—OPERATION Overview The  tub  is  designed  to  improve  the  efficiency  and  environmental  safety  of  you r  facility ʹ s  operation.  Howev er ,  if  the  tub  is  not  operated  or  maintained[...]

SECTION 3—OPERATION Part No 1150695 23 Recessed Side Entry Bath Tubs Disinfecting the Tub Using the Closed Loop System  WARNING Disinfect the tub after EACH us e to avoid resident infection and contamination of the tub. DO NOT disinfect the tub when it is occupied otherwise injury may occur. Read and understand all information on Invacare bran[...]

SECTION 3—OPERATION Recessed Side Entry Bath Tubs 24 Part No 1150695 Opening/Closing the Tub Door  WARNING DO NOT open door when water is in th e tub, serious injury could result. NOTE:  For  this  proced ure,  ref er  to  FIGURE 3.1  on  page  24. Opening the Tub Door 1. Place  one  hand  on  top  of [...]

SECTION 3—OPERATION Part No 1150695 25 Recessed Side Entry Bath Tubs Water Temperature Setting NOTE:  For  this  proced ure,  ref er  to  FIGURE 3.2.  DANGER ALWAYS hand test the inco ming water temper ature and the wate r temperature in the tub before immersing the re sident. Failure to do so may result in a scalding injury.[...]

SECTION 3—OPERATION Recessed Side Entry Bath Tubs 26 Part No 1150695 Operating Shower/Massage Wand NOTE:  For  this  proced ure,  ref er  to  FIGURE 3.3. NOTE:  STEPS  1 ‐ 3  are  to  be  performed  while  holding  the  shower/massage  wand  over  the  tub. 1. T urn  shower/ma[...]

SECTION 3—OPERATION Part No 1150695 27 Recessed Side Entry Bath Tubs FIGURE 3.4 Filling Tub Hydromassage CAUTION Before starting hy dromassage, water level MUST be completely above whirlpool jets otherwise damage to the motor/pump will result. NOTE:  For  this  proced ure,  ref er  to  FIGURE 3.5. 1. Close  the  aerator ?[...]

SECTION 3—OPERATION Recessed Side Entry Bath Tubs 28 Part No 1150695 FIGURE 3.5 Hydromassage Whirlpool Aerator Whirlpool On/Off Button Drain Drain Plug DETAIL “A” DETAIL “C” DETAIL “B” Turn Counterclockwise to Open Whirlpool Jet Pull Out to Open Inlet Plug Whirlpool Inlet[...]

SECTION 4—MAINTENANCE Part No 1150695 29 Recessed Side Entry Bath Tubs SECTION 4—MAINTENANCE NOTE:  Every  six  months  or  as  necessary  have  a  qualified  technician  perform  a  thorough  inspection  and  servicing.  Routine  maintenance  will  extend  the  life  and  [...]

SECTION 4—MAINTENANCE Recessed Side Entry Bath Tubs 30 Part No 1150695 Maintenance Overview Cleaning the Door Seal Gasket The  rubber  door  seal  gasket  should  remain  clean  and  free  of  debri s.  Use  a  wor ki n g  solution  of  a  commercially  av ailable  heavy  duty  cle[...]

SECTION 4—MAINTENANCE Part No 1150695 31 Recessed Side Entry Bath Tubs Heavy Duty Cleaning Procedure  WARNING The disinfectant dispensing system has been fact ory tested and calibrated for use with I nvacare disinfectant. The use of any disinfectant with a dilution ratio (½ oz. per gallon) or visco sity level different than that of Invacare d[...]

SECTION 4—MAINTENANCE Recessed Side Entry Bath Tubs 32 Part No 1150695 Calibrating the Disinfectant Flow Meter  WARNING The disinfectant dispensing system has been factory te sted and calibrated for use with Invacare disinfectant. The use of any disinfectant wi th a dilution ratio (½ oz. per gallon) or viscosit y level different than that of [...]

SECTION 4—MAINTENANCE Part No 1150695 33 Recessed Side Entry Bath Tubs 13. T urn  the  disinfectant  va l ve  to  the  on  position. NOTE:  Liquid  will  be  heard  filling  the  interior  plumbing  of  the  tub. 14. Note  the  position  of  the  floating  ball  in  the[...]

SECTION 4—MAINTENANCE Recessed Side Entry Bath Tubs 34 Part No 1150695 Maintenance Record DATE MAINTENANCE PERSON TYPE OF MAINTENANCE PERFORMED NOTES[...]

SECTION 5—TROUBLESHOOTING Part No 1150695 35 Recessed Side Entry Bath Tubs SECTION 5—TROUBLESHOOTING NOTE:  If  pr oblems  are  not  rem ed i e d  by  the  suggested  means  above,  contact  an  ICCG  deal er  or  technical  support. SYSTEM/OPERATION SYMPTOMS FAULTS SOLUTION Hydromassage System[...]

LIMITED WARRANTY PLEASE NOTE: THE WA RRANTY BELOW HAS BE EN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MA N UFACTURED AFTER JULY 4, 1975. This warranty is extended only to the o riginal purchaser/user of our pro ducts. This warranty gives you speci fic legal rights and you may also have other legal ri ghts which vary from state to st[...]