Weber 2200 NG инструкция обслуживания

PLA TINUM ™ SERIES II Natural Gas Barbecues Operating Guide NO TICE T O INST ALLER: These instructions must be left with the o wner and the owner should keep them for future use. W ARNING: Follow all leak c heck procedures carefull y in this manual prior to barbecue operation. Do this even if barbecue was dealer assembled. W ARNING: Do not operat[...]

2 T ABLE OF CONTENTS W arnings 3 W arranty 4 A Word of Thanks 4 Standards and Codes Information 5 Storage 5 Operating Area 5 Natural Gas Supply T esting 5 *REFER TO YOUR STEP-BY -STEP SECTION A T THIS TIME Lighting 6 Crossover Ignition System 6 T o Extinguish 6 Manual Lighting 7 T o Extinguish 7 Lighting the Side Burner 8 Cooking 9 Cleaning 9 Using[...]

3 W ARNINGS  D ANGER Failure to f ollo w the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodily injury or death, or a fire or an e xplosion causing damage to property . ■ Do not store a spare or disconnected LP tank under or near this barbecue. ■ Improper assembly may be dangerous. Please careful[...]

4 ST ANDARDS AND CODES INFORMA TION Y our W eber Gas Barbecue is a portable outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in the food. The Weber Gas [...]

5 Thank you for choosing a W eber Barbecue. Our family here at W eber has worked har d to produce the highest quality pr oducts for your satisfaction. While we give much attention to our products, an occasional err or may occur . Our knowledgeable Customer Service staff is pr epar ed to help you with any pr oblems with parts or assembly . Call our [...]

6 LIGHTING THE MAIN BURNERS  W ARNING: Check hose before eac h use of barbecue for nic ks, cracking, abrasions or cuts. If the hose is found to be dama g ed in any wa y , do not use the barbecue. Replace using only W eber authoriz ed replacement hose. Order from Weber -Stephen Products Co., Customer Service or authorized dealer . 1) Open the lid[...]

7 MANUAL LIGHTING 1) Open the lid. Figure 2. 2) Make sure all burner control knobs are turned OFF . (Push each burner control knob down and turn clockwise.) For barbecues equipped with a side burner , push the burner control knob in and turn clockwise to OFF . 3) T urn gas supply valve on. 4) Strike a match and put the flame into the matchlight hol[...]

8 The side burner has a separate ignition system from the main cooking box. Lighting only the side burner . Figure 3. 1) Open the side burner lid. 2) Check that the side burner valve is OFF (push in and turn clockwise), and all main burner control knobs are OFF (push down and turn clockwise). 3) T urn the gas supply on. 4) Push in and turn the side[...]

9 COOKING The W eber Gas Barbecue should not be moved when operating or hot. If burner s go out during cooking, open lid, turn off all burner s and wait 5 minutes before relighting. Note: The temperatures inside y our cooking box, f or the first f ew uses, while surf aces are still v er y reflective, ma y be hotter than those shown in y our cookboo[...]

10 The Steam-N-Chips Smoker cooks with both Weber FireSpice Wood Chips and Chunks. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using the FireSpice Chips because they ignite and create smoke faster . For longer cooking foods such as roasts, chicken and turkeys, etc., we recommend using FireSpice Chun[...]

11 MAINTENANCE Spider Stopper Guards Y our Gas Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section of the burner tubes. This blocks the normal gas flow , and can cause the gas to flow back out of the air shutter . Figure 5. This could result in a fire in and around the air [...]

12 MAINTENANCE View from behind cooking box Wing nuts Figure 11 Guide screw Figure 12 Figure 10 Replacing Main Burners a) Y our W eber Gas Barbecue must be OFF and cool. b) T urn gas OFF at source. c) T o remove the control panel, see the Step-By-Step Guide. d) Unlatch the Spider Stopper Guards and remove. Figure 10. e) If your barbecue has a side [...]

13 Figure 16 White wire Black wire Crosso ver Ignition System Operations If the Crossover Ignition System fails to ignite the Front burner , light the Front burner with a match. If the Front burner lights with a match, then check the Crossover Ignition System. ■ Check that both the white and black ignition wires are attached properly . Figure 16.[...]

14 TROUBLESHOOTING Prob lem Burners b urn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups:  CA UTION: Do not line the bottom tra y with aluminum f oil. Burner flame pattern is erratic. Flame is low when burner is on HIGH. Flames do not run the wh[...]

15 Problem Side burner does not light. Flame is low in HIGH position. Flame is very yellow in conjunction with the smell of gas, OR Burner makes popping noise in conjunction with the smell of gas. Push button ignition does not work. Flame is large or erratic. Check Is gas supply off? Is fuel hose bent or kinked? Inspect burner ring slots for obstru[...]

16  W ARNING: All gas controls and supply valves should be in the OFF position. Figure 17 (a). Make sure black wire is connected between igniter and electrode. Make sure white wire is connected between igniter and ground. Check that igniter lock nut is tight. Figure 17 (b) and figure 17 (c). Note - If the igniter works loose, carefully tighten t[...]

17 Figure 19 T o Clean the Burner Head Remove the windshield and grate. Remove the burner cap. Figure 19 (a). Clean with soap and water . Soak if necessary . Remove the burner ring. Figure 19 (b). Clean with soap and water . Soak if necessary .  CAUTION: Do not enlarge the slots in the burner ring. Only clean with a cloth and soap and water . Re[...]

18 PLA TINUM SERIES II 2200 NA TURAL GAS EXPLODED VIEW ® ® ® ® ® ® ® ® W E B E R W E B E R 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41-44 46 45 47 48 49 50 51[...]

19 PLA TINUM SERIES II 2200 NA TURAL GAS REPLACEMENT P ARTS LIST 1 Hinge pin cotter (2) 2 Hinge pin (2) 3 Lid (assembly) 4 Thermometer 5 Weber warm-up basket 6 W arming rack 7 Steam-N-Chips Smoker 8 Steam-N-Chips Smoker flue 9 Cooking grate (2) 10 Cooking box 1 1 Keps nut 12 1/4-20 x 1/2 inch bolt (12) 13 Nylon washer (16) 14 Left work surface 15 P[...]

20 PLA TINUM SERIES II 3200 NA TURAL GAS EXPLODED VIEW ® ® ® ® ® ® ® ® W E B E R W E B E R 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41-44 45 46 47 48 49 50 51[...]

21 PLA TINUM SERIES II 3200 NA TURAL GAS REPLACEMENT P ARTS LIST 1 Hinge pin cotter (2) 2 Hinge pin (2) 3 Lid (assembly) 4 Thermometer 5 Weber warm-up basket 6 W arming rack 7 Steam-N-Chips Smoker 8 Steam-N-Chips Smoker flue 9 Cooking grate (2) 10 Cooking box 1 1 Keps nut 12 1/4-20 x 1/2 inch bolt (12) 13 Nylon washer (16) 14 Left work surface 15 P[...]

22 PLA TINUM SERIES II 3400 NA TURAL GAS EXPLODED VIEW ® ® ® ® ® ® ® ® W E B E R W E B E R 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 41-44 45 46 47 48 49 50 51 52 53 54 60 55 59 56 58 40 57[...]

23 PLA TINUM SERIES II 3400 NA TURAL GAS REPLACEMENT P ARTS LIST 1 Hinge pin cotter (2) 2 Hinge pin (2) 3 Lid (assembly) 4 Thermometer 5 Weber warm-up basket 6 W arming rack 7 Steam-N-Chips Smoker 8 Steam-N-Chips Smoker flue 9 Cooking grate (2) 10 Cooking box 1 1 Keps nut 12 1/4-20 x 1/2 inch bolt (14) 13 Nylon washer (19) 14 Left work surface 15 P[...]

P A TENTS AND TRADEMARKS © 1998 Weber . Weber , , Genesis, Flavorizer and Crossover are registered U.S. trademarks; Perma- Mount, Gas Catcher , FlameCheck, Steam-N-Chips, Spider Stopper , and W arm-Up are U.S. trademarks of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Genesis Gas Barbecues are covered under th[...]