True Manufacturing Company TCGDZ-50 инструкция обслуживания

............ www .truemfg.com ............ INST ALLA TION MANUAL FOR TCGDZ DISPLA Y CASES (DUAL ZONE) MODELS CUR VED GLASS DISPLA Y CASES - DUAL ZONE MODELS - CONGRA TULA TIONS! Y ou have just purchased the finest commercial refrigeration available. Y ou can expect many years of trouble-free operation. TRUE FOOD SERVICE EQUIPMENT , INC. 2001 East T[...]

NOTICE TO CUSTOMER: Loss Or Spoilage Of Products In Your Refrigerator/Freezer Is NOT Covered By Warranty. In Addition To Following Recommended Installation Procedures You Must Run The Refrigerator/Freezer 24 Hours Prior To Usage. True Manufacturing Company, Inc.[...]

............ www .truemfg.com ............ SAFETY INFORMA TION • This display case must be pr operly installed and located in accordance with the Installation Instructions before it is used. • Do not allow childr en to climb, stand or hang on the shelves in the displa y case. They could damage the r efrigerator and seriously injur e themselves.[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 2 2 SAFETY INFORMA TION PROPER DISPOSAL OF THE DISPLA Y CASE DANGER! RISK OF CHILD ENTRAPMENT USE OF EXTENSION CORDS NEVER USE AN EXTENSION CORD! TRUE will not warranty any display case that has been connected to an extension cord. Child entrapment and suffocation ar e no[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 3 3 Bef ore your ne w display case is connected to a power suppl y , chec k the incoming voltag e with a voltmeter . If anything less than 100% of the rated voltag e f or operation is noted, correct immediately . Have the cir cuit chec ked by a qualified electr ician to m[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 4 4 INST ALLA TION / OPERA TION INSTRUCTIONS T o insure that your unit wor ks properl y from the first day , it must be installed properly . W e highly recommend a trained mec hanic and electrician install your T r ue equipment. The cost of a profes- sional installation i[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 5 5 INST ALLA TION / OPERA TION INSTRUCTIONS Warning For proper performance of refrigerated cabinet an ambient temperature no greater than 75°F (24°C) with a relative humidity of 55% is required. TOOLS REQUIRED: • Phillips screw driver • 3 / 8 ” (9.5 mm) socket or[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 6 6 INST ALLA TION / OPERA TION INSTRUCTIONS Step 4 A. Bef ore your ne w unit is connected to a pow er supply , check the incoming v oltage with a v olt- meter . If anything less than 100% of the r ated voltag e f or operation is noted, correct immedi- ately . B. Models e[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 7 7 INST ALLA TION / OPERA TION INSTRUCTIONS CONDUCTORS AND CIRCUITS Wire Gauge for 2% Voltage Drop in Supply Circuits. 115 Volt Distance In Feet T o Center of Load Amps 20 30 40 50 60 70 80 90 100 120 140 160 2 14 14 14 14 14 14 14 14 14 14 14 14 3 14 14 14 14 14 14 14 1[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 8 8 Step 5 A. The compressor is r eady to oper ate. Plug in the display case. B. Check the temperature control setting in the lower right of the cabinet backside. The set- ting should be at No. 3 position to maintain an approximate temperature of 38°F (3.3°C). Set defro[...]

INST ALLA TION / OPERA TION INSTRUCTIONS SHEL VING INST ALLA TION (REFRIGERA TED BAKERY) SHELF INST ALLA TION: A. Lift each door up and out of track (do not dis- connect elastic tubing). Stretch elastic surgical tubing and set doors on each side of unit. B. Locate brackets, lights, shelves, etc. from cabinet interior . C. Locate shelf suppor ts wra[...]

INST ALLA TION / OPERA TION INSTRUCTIONS OPTIONAL (INST ALLING OPTIONAL CASTORS) CASTOR INST ALLA TION: TOOLS REQUIRED: • Castor wrenc h (if not included contact T r ue) • Adjustable wrenc h NOTE Castors not available for hard wired or remote models. WARNING Make sure unit is empty of all its contents (shelv- ing, shelving lighting). Make sure [...]

INST ALLA TION / OPERA TION INSTRUCTIONS FORMICA KIT INST ALLA TION: FORMICA KIT COMPONENTS: (2) F or mica T op End P anels 10 3 / 4 "w x 33"h (27.3 cm x 83.8 cm). (2) Bottom End P anels (1) left side, (1) right side (For mica glued to black plastic panel with 4 key hole slots). (1) F or mica Front P anel width will var y x 7 5 / 8 "[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 12 12 MAINTENANCE, CARE & CLEANING • The e xterior may be wiped clean with mild soap and water . Use a good stainless cleaner on coun- tertop. CAUTION: Do not use any steel wool, abrasive or chlorine based products to clean stainless steel sur - faces. • The inter[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 13 13 MAINTENANCE, CARE & CLEANING LIGHT BULB REPLACEMENT SHELF MOUNTED BULB REPLACEMENT : WARNING When replacing a light bulb make sure power to the unit is either turned off or unplugged. A. Unplug the light assembly from the receptac le on the interior side wall. R[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 14 14 MAINTENANCE, CARE & CLEANING TEMPERA TURE CONTROL ADJUSTMENT FOR HIGH AL TITUDE ONL Y! TERMS: • Cut-out - T emperature sensed by the controller that shuts the compressor off. • Cut-in - T emperature sensed by the controller that turns the compressor on. TOOL[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 15 15 CLEANING THE CONDENSER COIL When using electrical appliances, basic safety precautions should be followed, including the following CONDENSER CLEANING: TOOLS REQUIRED: • Phillips screwdriver • Stiff br istle brush • Adjustable wrench • V acuum A. Disconnect p[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 16 16 Condensers accumulate dirt and require cleaning every 30 days. Dirty condensers result in compressor failure, product loss, and lost sales... which are not covered by warranty . If you keep the Condenser clean you will minimize your service expense and lower your el[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 17 17 CAUTION: Do not use any steel wool, abrasive or chlorine based products to clean stainless steel surfaces. • Stainless Steel Opponents There are thr ee basic things which can break do wn your stainless steel’ s passivity lay er and allow corrosion to rear its ug[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 18 18 Recommended cleaners f or cer tain situations / environments of stainless steel A) Soap, ammonia and detergent medallion applied with a cloth or spong e can be used for routine cleaning. B) Arcal 20, Lac-O-Nu Ecoshine applied provides barr ier film for fing erpr int[...]

............ www .truemfg.com ............ T rue Food Service Equipment, Inc. 19 19 W ARRANTY INFORMA TION (U.S.A. and Canada ONL Y!) ONE YEAR P ARTS & LABOR W ARRANTY TRUE warrants to the original purchaser of every new TRUE refrigerated unit, the cabinet and all parts thereof, to be free fro m defects in material or workmanship, under normal [...]