Superior SDV35 инструкция обслуживания

SDV35 Direct - V ent Gas Fireplaces SDV35-N INST ALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference. INST ALLA TEUR : Laissez cette notice avec l'appareil. CONSOMMA TEUR : Conservez cette notice pour consultation ultérieure. MODELS DON’T THROW IT AW AY ! This manual contains important operating an[...]

2 S a f e ty an d Y our Fireplace  T o prevent severe burns and injuries, install a screen or physical barrier to prevent direct contact with the glass. T o order a FREE Lennox ® SAFETY GUARD for your fireplace, see details at left.  Follow the safety instructions below and be sure everyone in your household understands this burn hazard: Th[...]

3  Afin d'éviter de vous brûler gravement ou de vous blesser , installez une grille ou une barrière physique pour empêcher tout contact direct avec la vitre. Pour commander un P ANNEAU DE PROTECTION Lennox ® GRA TUIT pour votre foyer , consultez les détails dans la partie gauche.  Suivez les instructions de sécurité ci-dessous e[...]

4 Important Safety Information WARNING: Do not operate appliance with the glass front 1. removed, cracked or broken. Replacement of the glass should be done by a licensed or qualified service person . Do not use this appliance if any part has been under water . 2. Immediately call a qualified service technician to inspect the appliance and to rep[...]

5 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A P P O S I T I O N D E S M I S E S E N G A R D E R E L A TI VE S À LA SÉCURITÉ D’UTILISA TION V ot r e f o y e r a é t é li v ré av ec de s é t i q u e tt es de sé c u r i té qu i doivent être collées à côté des dispositifs de contrôle du foyer . Une étiquette de sécurité [...]

6 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. General Information These fireplace models covered in this manual are direct-vent sealed combustion gas fireplace heaters designed for installation into manufac- tured homes and site built residential homes. These direct-vent appliances operate with the combustion chamber completely isolated[...]

7 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Burn-in Period During the first few fires of this appliance there will be some odor due to the curing of the paint and burning off of lubricants used in the manufacturing process. Depending on your use, the burn-in period may take a few hours or a few days. K E E P Y O U R H O U S E W E L L [...]

8 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. OPERA TION AND CARE OF YOUR APPLIANCE W ARNING Y oung children should be carefully supervised when they are in the same room as the appliance. T oddlers, young children and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at risk individuals[...]

9 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Honeywell Millivolt Gas Valve Figure 4 O N O F F P I L O T L O H I OFF ON OFF ON Blower ON/OFF Rocker Switch SIT Millivolt Gas Valve Gas Outlet Gas Inlet Pilot Adjustment Screw T erminals TPTH,TP & TH Figure 3 H I L O W H T P T H T P T P I L O T P I L O T O N t i O F F IN OUT OFF ON OFF ON[...]

10 Replacing Logs If the logs become damaged by accident or im- prope r handl ing and need replac ement , use only the proper repla cement logs from manufactur er (see Page 24 for ordering information). Re-Install Embers and Logs Carefully follow placement instructions on Pages 12 and 13 ) . All logs should fit onto cor- responding pins and/or log[...]

11 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. T op Flange on Glass Door Bottom Vee-flange Glass Door Glass Door Latch Glass Door Firebox Floor Installing Glass Enclosure Panels (see Figure 5) 1. Visually inspect the gasket on the backside of the glass panel. The gasket sur face must be clean, free of irregularities and seated firmly . [...]

12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. REFERENCE Firebox Accessories / Parts Cat. No. Model No. Description 88L53 FGE Bag of Glowing Embers 80L42 FDVS Bag of Decorative Volcanic Stone Glowing Embers Bag of Glowing Embers (rockwool) Separate into Quarter Size (separate) Pieces INST ALL VOLCANIC STONE, GLOWING EMBERS AND LOGS 1. Rem[...]

13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 7 MODEL SDV35 Log Placement Instructions I ns t al l t h e E mb e r s , V ol c an i c S to n e a nd Lo g s i n t h e or d er shown here (1 through 5) and per the instructions on Page 12 . LOG SET Catalog Number H3367 * Item Description A Log, Rear B Log, T op Left C Log, Center D Log, [...]

14 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 8 Burner Flame Appearance Model SDV35 BURNER ADJUSTMENTS (QUALIFIED TECHNICIANS ONL Y) Flame Appearance and Sooting Proper flame appearance is a flame which is blue at the base and becomes yellowish-orange in the body of the flame. When the appliance is first lit, the entire flame[...]

15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Main Burner Factory Air Shutter Opening Setting - Inches (millimeter) Model Natural Gas Propane Gas SDV35 1/4 (6.35 mm) 1/2 (12.7 mm) Figure 9 1 . Locate adjustment rod and adjust air shutter to the standard setting as shown in Figure 9 (adjustment rod is located in the lower control compartm[...]

16 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. WIRING DIAGRAMS Wiring diag rams are provi ded here for refe rence purp oses only . This inf ormat ion is also prov ided on schematics attac hed directly to the applian ce on a pullout panel located within the control compartment. CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING[...]

17 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS Product Reference Information Cat. No. Model Ship Wt Ship Volume H4632 SDV35-N 115 lb. 16.17 cu. ft. Remote Control Kit, Standard Cat. No. Model No. Description H0249 RCL Remote Control System (Standard) Remote Control Kit, Deluxe Cat. No. Model No. Description H025 1 R C[...]

18 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Polished Brass & Brushed Stainless Hood Kits Attractive hoods are available in two styles. These hoods are designed to be fitted to the glass viewing sides of the appliance. In addition to providing an aesthetically pleasing appearance to your appliance installation, the hood reduces hea[...]

19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 4-Piece Door Frame Kits A decorative door frame kit is avail - able for use with these appliances. It is des ig ne d to at ta ch dire ctl y to th e f ron t f ace of t he ap pli an ce at t he four edges of the glass enclosure pa ne l res ul ti ng in the ap pe aran ce of a pi ctur e f ra me . ([...]

20 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. LIGHTING INSTRUCTIONS – MILLIVOL T GAS V AL VE FOR YOUR SAFETY READ BEFORE LIGHTING A. This appliance has a pilot which must be lighted with a piezo igniter . When lighting the pilot, follow these instructions exactly . B. BEFORE LIGHTING smell all around the appliance area for gas. Be sure[...]

21 INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT HONEYWELL ET SIT INSTRUCTIONS D'ALLUMAG E 8. Enfoncez le bouton de réglage jusqu’au fond et gardez-le enfoncé. Allumez immédiatement la veilleuse en déclenchant l’allume-gaz à étincelle (en poussant le bouton) jusqu’à ce que la veilleuse s’enflamme. Continuez de tenir le bouto[...]

22 Annually (Before the onset of the Burning Season) MAINTENANCE T ASK ACCOMPLISHING PERSON PROCEDURE Inspect/Clean Burner , Logs and Controls Qualified Service T echnician Inspect valve and ensure it is properly operating. Check piping for leaks. V acuum the control compartment, fireplace logs and burner area. Check Flame Patterns and Flame Heig[...]

23 SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION 1. Spark igniter will not light pilot after repeated triggering of igniter button. WARNING: if the pilot will not light after 1 minute of attempting, wait for at least 5 minutes for gas to clear before attempting again. A. Defective igniter (no spark at electrode). Check for spark at electrode and pilot;[...]

24 Item Description Cat. No. Qty. 1 Hood H4574 1 2 Louver Assembly , T op H6294 1 3 *Louver Assembly , Bottom H6296 1 4 Enclosure, Glass Front (Complete) H6554 1 5 Nameplate, Superior 56L93 1 6 Latch 69L21 2 7 Log Set (Complete) H3367 1 8 Burner Assembly 69L09 1 9 Burner Bracket H4890 1 10 Ember Screen H6714 1 11 Orifice, Main Burner - Natural Gas[...]

25 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. REPLACEMENT P ARTS DIAGRAMS - MODEL SDV35 7 1 2 11 12 16 15 6 22 13 3 18 21 19 17 20 5 8 4 9 10 24 25 26 27 28 29 30 31 14 GAS CONVERSION KIT 23[...]

26 Notes[...]

27 Notes[...]

Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. 1508ElmHillPike,Suite108•Nashville,TN37210 Printed in U.S.A. © 2006[...]