Monessen Hearth B-Vent Specialty Gas Fireplace System DESIGNER SERIES инструкция обслуживания

DESIGNER SERIES 624BVSTNV/624BVSTNE, 624BVPFNV/624BVPFNE 624BVCLNV/624BVCLNE, 624BVCRNV/624BVCRNE, 624BVBYNV/624BVBYNE B-V ENT S PECIAL TY G AS F IREPLACE S YSTEM I NST ALLA TION , O PERA TION AND M AINTENANCE M ANUAL D O NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE V APORS AND LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE . WHA T TO DO IF[...]

"W ARNING : I F NOT INST ALLED , OPERA TED AND MAINT AINED IN ACCORDANCE WITH THE MANUF A TURER ’ S INSTRUCTIONS , THIS PRODUCT COULD EXPOSE YOU TO SUBST ANCES IN FUEL OR FROM FUEL COMBUSTION WHICH CAN CAUSE DEA TH OR SERIOUS ILLNESS AND WHICH ARE KNOWN TO THE ST A TE OF C ALIFORNIA TO CAUSE CANCER , BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM [...]

T ABLE OF C ONTENTS 2 C22 C ONGRA TULA TIONS ! Y ou have chosen the finest decorative gas appliance available. Y our 6- IN -1 ™ Specialty Gas Fireplace has been designed for years of heating and viewing enjoyment. Please take time to read this entire manual before installing or operating your system. Model Dealer Serial No. Dealer Phone No. Gas T[...]

P ARTS D IAGRAM 3 MV MV PV PV N O C F F O 16 16 15 15 7 17 17 19 19 18 18 9 6 5 8 4 3 11 11 13 13 12 12 14 14 10 10 2 14 14 1 13 13 ON OFF PILOT TH TPTH TP 53D9019. Rev 3 11/07[...]

P ARTS L IST 4 All repair part orders should be placed through your local dealer . T o ensure prompt and accurate service, please provide the following information when placing a repair part order: Model num- ber of your Fireplace, Part Name, Part Number , and Quantity of parts needed. 6-IN-1 PART LIST 071589 071589 076673 076673 077620 077620 0709[...]

The table below is a list of components which may be safely used with this product. Configuration Kits 6BK Bay Kit 6CK Corner Kit (works for left or right side) 6IK Island Kit 6PNK Peninsula Kit 6SK See-Thru Kit Control Kits 6CN Control Kit Natural Gas Standing Pilot 6CLP Control Kit Propane/LP Gas Standing Pilot 6CEN Control Kit Natural Gas Electr[...]

F IREPLACE C ONFIGERA TION I NST ALLA TION 6 P ART 1 Remove front glass door by removing the cardboard fillers at the top and lifting up and away from the appliance. Install the handles onto the door using screws from the handle package. Keep front glass door of f of the appliance until installation of Configuration Kit (Part 2) and Control Kit (Pa[...]

23 1/8 FRAMING  FRAMING  DIM. FOR DIM. FOR SEE THRU SEE THRU 42 3/8 42 3/8 42 1/2 42 1/2 (FRAMING MIN.) (FRAMING MIN.) (ALL UNITS) (ALL UNITS) 1 1/2 MIN.  1/2 MIN.  CLEARANCE CLEARANCE 24 5/8 24 5/8 24 1/8 24 1/8 22 1/8 22 1/8 1 4 1/2 4 1/2 12 1/16 12 1/16 19 19 9 3/4 9 3/4 7 1/2 7 1/2 22 1/4 22 1/4 TOP VIEW TOP VIEW 37 1/4 37 [...]

To accommodate the various configurations, we have provided access openings in the bottom of the unit for gas line and wall switch wires. This may not be convenient for some installations, if so you may drill an access opening into the lower face of the unit (1" for gas line, 1/2" for the grommet). 1. Route the 3/8 inch N.P .T . black iro[...]

F IREPLACE I NST ALLA TION AND V ENTING 9 F IGURE 5F IGURE 6 APPROVED APPROVED COWL COWL MIN. MIN. 6 FT. 6 FT. SUPPORT SUPPORT 4 FT. 4 FT. MAX. MAX. APPROVED THIMBLE FOR APPROVED THIMBLE FOR 6" TYPE "B" GAS VENT 6" TYPE "B" GAS VENT CHIMNEY CHIMNEY GAS APPLIANCE GAS APPLIANCE WALL WALL FLOOR FLOOR THROUGH WALL THROUGH [...]

V ENTING R EQUIREMENTS 10 W ARNING : D O NOT CONNECT THIS APPLIANCE TO A CHIMNEY FLUE SERVING A SEP ARA TE SOLID FUEL BURNING APPLIANCE . C ARBON DEPOSITS (S OOT ) AND CREOSOTE FROM SOLID FUELS CAN CLOG THE VENT FROM THE APPLIANCE CAUSING POISONOUS CARBON MONOXIDE TO BE RELEASED INT O THE ROOM IN WHICH THE APPLIANCE IS INST ALLED . All vented gas-f[...]

LOGS AND TWIGS. LOGS AND TWIGS. TOP VIEW OF TOP VIEW OF Curing Instructions Note: When lit for the first time the fireplace may emit a slight odor for several hours. This is due to the curing and "burn in" of external parts and lubricants used in the manufacturing process. This condition is temporary . Open doors and window to ventilate t[...]

Units with 6CEN Controls 1. Determine a convenient location within twenty (20) feet and cut a hole large enough to accommodate the wall switch yet be covered with a wall plate. It is not necessary to use a wall box, but one may be used. 2. Route the wire provided through the 1/2 inch black plastic grommet in the unit. 3. Route the wire into the wal[...]

Pilot Burner Adjustment 1. Adjust the pilot screw to provide a properly sized flame. 2. Do not adjust the pilot screw all the way out counterclockwise because it will leak gas. Flame Switch (For Units with 6CN and 6CLP Controls) Y our fireplace has been equipped with a thermocouple which senses the flame and shuts of the gas flow to the pilot and m[...]

Maintenance of the Appliance Air flowing through the appliance will cause dust and lint to collect on the grate, burner and logs. Exessive buildup of dust and lint can cause the pilot and burner to operate improperly and produce hazardous levels of carbon monoxide, a poisonous gas. The appliance may produce carbon (soot) during operation. This carb[...]

15 C OMBUSTION A IR P RECAUTIONS N OTE : The use of outside air for combustion is optional unless required by building codes. It is only necessary to supply outside combustion air to one side of the fireplace. Use the model OAC4 combustion air kit. 1. Extremely long runs and numerous turns in the duct leading from the fireplace to the combustion ai[...]

C OMBUSTION A IR A SSEMBL Y 16 M ODEL AK4 C OMBUSTION A IR A SSEMBL Y 1. Remove the cover plate from the 4-inch outlet opening location on the left outside of the fireplace. DO NOT remove the cover if the outside air will not be connected. 2. Place the starting collar (4 inch) into the hole on the left side of the fireplace. Fasten it in place with[...]

OPERATING INSTRUCTIONS OPERATING INSTRUCTIONS WARNING: FOR YOUR SAFETY READ BEFORE LIGHTING FOR YOUR SAFETY READ BEFORE LIGHTING ON OFF TO TURN OFF GAS TO APPLIANCE TO TURN OFF GAS TO APPLIANCE KNOB KNOB INDICATOR INDICATOR POSITION POSITION GAS CONTROL GAS CONTROL THE FIRE DEPARTMENT. HAS BEEN UNDER WATER. OR EXPLOSION. CONTROL SYSTEM AND ANY GAS [...]

O PERA TING I NSTRUCTIONS 18 C. C. D. D. LIGHTING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE LIGHTING IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL IF YOU CANNOT REACH YOUR GAS SUPPLIER, CALL THE FIRE DEPARTMENT. USE ONLY YOUR HAND TO PUSH IN OR TURN THE GAS USE ONLY YOUR HAND TO PUSH IN OR TURN THE GAS CONTROL KNOB. NEVER USE TOOLS. IF THE KNOB WILL C[...]

Correct installation and safe operation of this appliance require, but are not limited to the following: Do's: 1. Do use this appliance only on type of gas it is designed, certified and equipped. 2. Do install this appliance and all gas piping according to local codes, or in the absence of local codes, according to the current National Fuel Ga[...]

T ROUBLESHOOTING 20 While the manufacturer has made every reasonable effort to ensure that this appliance operates properly and satisfactorily , sometimes problems do arise. The following troubleshooting chart lists several problems with their probable cause and remedy . Any adjustments and/or replacements must be by a qualified person. Do not repl[...]

NOTE REGARDING VENTED PRODUCTS This product must be installed by a licensed plumber or gas fi tter when installed within the Commonwealth of Massachusetts. Any residence with a direct vent product must have a CO detector installed in the residence. Installation of the fi replace or vented gas log in the State of Massachusetts requires the damper [...]

SPECIAL REQUIREMENTS CONTINUED 2. APPROVED CARBON MONOXIDE DETECTORS. Each carbon monoxide detector as required in accor- dance with the above provisions shall comply with NFP A 720 and be ANSI/UL 2034 listed and IAS certi- fi ed. 3. SIGNAGE. A metal or plastic identi fi cation plate shall be permanently mounted to the exterior of the build- ing [...]

N OTES 21 53D9019. Rev 3 11/07[...]

N OTES 22 53D9019. Rev 3 11/07[...]

A TTENTION A PPLIANCE I NST ALLER P LEASE RETURN THESE O PERA TING AND I NST ALLA TION I NSTRUCTIONS TO THE A PPLIANCE FOR C ONSUMER U SE . 53D9019. Rev 3 11/07[...]