Stoelting SO328 manual

Optima SO328 Floor Model OWNER'S MANUAL Manual No. 513591 Apr . 2003 Rev .2[...]

[...]

Need Part s or Service? We stock the parts you need.  Our Technicians are factory trained and are certified in the Stoelting Technicare program. Model No.: _______________________ Serial No.: _______________________ Purchase Date: ____________________ Start-Up Date:____________________ CALL Distributor: _________________________ Phone No.: _____[...]

[...]

OWNER'S MANUAL FOR MODEL SO328 STOELTING FLOOR MODEL FREEZER This manual provides basic information about the freezer. Instructions and suggestions are given covering its operation and care. The illustrations and specifications are not binding in detail. We reserve the right to make changes to the freezer without notice, and without incurring [...]

[...]

SECTION DESCRIPTION PAGE 1. INTRODUCTION 1.1 Remote Possibilities .......................................................................................... 1 1.2 Features ............................................................................................................ 1 1.3 Freezer Specifications ........................................[...]

FIGURE TITLE PAGE 1 Model SO328 ................................................................................... 1 2 Freezer Specifications ...................................................................... 2 3 Leveling Unit ..................................................................................... 3 4 Electrical Box .............[...]

1 1.1 REMOTE POSSIBILITIES The S toelting Optima delivers frozen drink profits by the pitcher . The Model SO328 is a high-volume producer of ready-to-serve frozen cocktails or frozen neutral base for those special drink recipes. From an extra-small space, the Optima’s compact design and high capacity output will give you extra-large profits. SECT[...]

2 Electrical Refrigeration Crated Dimensions Dimensions  208/230/60/1  HFC-404A environmentally-  Width: 22" (55.9cm)  Width: 17.6"(44.7cm)  20 amp circuit & plug friendly refrigerant  Depth: 30" (76.2cm)  Depth: 26.1"(66cm) per side  2 HP (14,800 BTUH) high-  Height: 66" (167.7cm)  Height:[...]

3 SECTION 2 INST ALLA TION INSTRUCTIONS 2.1 SAFETY PRECAUTIONS Do not attempt to operate the freezer until the safety precautions and operating instructions in this manual are read completely and are thoroughly understood. Take notice of all warning labels on the freezer. The labels have been put there to help maintain a safe working environment. T[...]

4 2.4 INSTALLING PERMANENT WIRING If permanent wiring is required by local codes, the following procedure must be performed. W ARNING DISCONNECT FREEZER FROM THE SOURCE OF ELECTRICAL SUPPL Y BEFORE SER VICING . A . Remove the right side and left panels and electrical box covers to gain access to the power cord. B . Remove the strain relief connecto[...]

5 SECTION 3 INITIAL SETUP AND OPERATION 3.1 OPERATOR'S SAFETY PRECAUTIONS SAFE OPERA TION IS NO ACCIDENT ; Observe these rules: A. Know the freezer . Read and understand the Operating Instructions. B. Notice all warning labels on the freezer . C. Wear proper clothing. Avoid loose fitting garments, and remove watches, rings or jewelry which cou[...]

6 Figure 6. Disassembling Freezer C. Remove the spigot body from the front door by pul ling the retaining pin out of the spigot handle. Push the spigot body thru the bottom of the front door . D. Remove the agitator assembly from the freezer . Pull the agitator assembly out of the freezer barrel. E . Keep the rear of the agitator assembly tipped up[...]

7 W ARNING THE UNITED ST A TES DEP ARTMENT OF AGRI- CUL TURE AND FOOD AND DRUG ADMINISTRA- TION REQUIRE THA T ALL CLEANING AND SANI- TIZING SOLUTIONS USED WITH FOOD PRO- CESSING EQUIPMENT BE CERTIFIED FOR THIS USE. USE “STERA-SHEEN” OR EQUIV ALENT . When sanitizing the freezer , refer to local sanitary regulations for applicable codes and recom[...]

8 Ê Ê Ê Ê Ê 3.8 CLEANING & SANITIZING OF S0328 WITH FILL-O-MA TIC II AND FILL-O-MA TIC III A . Empty freezer & mix container of product. B . Mix 4 gallons of warm (120°F) detergent (Joy or equivalent) water and pour into mix container , brush mix container , pick up hose and draw tube. Pump detergent water into freezer hopper . C. Mix[...]

9 4. Fill Timer Operation The timer has ten dip switches, all switches placed in the “on” position are added together to make up the tot al time delay . This freezer leaves the factory with 64, 128 and 256 in the “on” position, this is a total of 448 seconds. The preset time should be enough to fill the hopper up to the top level probe. Fil[...]

10[...]

11 4.1 ROUTINE CLEANING T o remove spilled or dried mix from the freezer exterior , simply wash in the direction of the finish with warm soapy water and wipe dry . Do not use highly abrasive materials as they will mar the finish. 4.2PREVENT A TIVE MAINTENANCE It is recommended that a maintenance schedule be followed to keep the freezer clean and op[...]

12[...]

13 SECTION 5 REPLACEMENT PARTS INFORMATION 5.1 ORDERING P ARTS T o assure receipt of the proper replacement part s, supply your dealer or distributor with the following information: A. MODEL NUMBER of equipment. B. SERIAL NUMBER of model (stamped on nameplate). C. P ART NUMBER, P ART NAME, AND QUANTITY NEEDED. Many part names and numbers are listed[...]

14 Item Stoelting P/N Qty . Description 1 1 170882 1 Auger Bushing 2 4177009 1 Auger Weldment 3 667892 1 Seal, Shaft 4 3172965 1 Rear Seal Adapter 5 624857 1 Ring, O, 2-1/4 ID x 2-5/8 OD x 3/16 CS 6 162157 2 Blade, Scraper 7 508048 As Reqd Lubricant 8 21771 18 1 W asher , Acetron 1.25 OD x .94 ID x .060" 9 336525-SV 1 Door , Front 10 625310 1 [...]

15 6.1 Fill-O-Matic II The Fill-O-Matic II is a self contained auto-fill system designed to be used with the Model SO328 Freezer. The pump is built onto the cover of a 10 gallon mix vat. A draw tube extends to the bottom of the container to supply the pump with mix, the mix then passes thru a screen, thru the pump and discharges thru a hose to the [...]

16 Strainer On/Off Switch 1 15 V olt 15 Amp Plug Ç Å È Figure 10. Fill-o-matic II[...]

17 6.2 Fill-O-Matic II The Fill-O-Matic III is a gas powered auto-fill system designed to be used with Slush and Cocktail Freezers. The pump is built to hang on the side of a 10 gallon mix vat. The pump can be driven by either regulated CO 2 , nitrogen or filtered compressed air. A draw tube extends to the bottom of the container to supply the pump[...]

18 Mix Outlet Gas Outlet Gas Inlet Mix Inlet É Ë Ë Ë Figure 11. Fill-o-matic III[...]

19 Gas Powered T o Freezer Electric From Auto Fill Note: T ubing Sold Separately 7 = 6 6.3 Fill-O-Matic Connections[...]

[...]

W ARRANTY MIX TRANSFER PUMPS / COCKT AIL / SLUSH 1. Scope: Stoelting LLC warrants to the first user (the “Buyer”) that the evaporator assembly and compressor (if applicable) of Stoelting mix transfer pump, cocktail and slush equipment will be free from defects in materials and workman- ship under normal use and proper maintenance appearing with[...]