Lennox Hearth CI2500DVF Bedienungsanleitung

INST ALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference. INST ALLA TEUR: Laissez cette notice avec l'appareil. CONSOMMA TEUR : Conservez cette notice pour consul- tation ultérieure. - Do no t st or e o r us e g as ol in e or ot he r fla mm ab le va po rs an d liquids in the vicinity of this or any [...]

2 The assembled vented gas stove heater is packaged with: one - log set located in firebox one - ember strip located beneath stove body (on pallet) one - bag of glowing embers located in the firebox one - envelope containing the literature package which consists of the homeowner's manual, installation instructions and warranty; located on th[...]

3 IM POR T AN T SA FET Y AN D W A RN IN G IN FOR MA TI ON W ARNING Y oung chil dren shou ld be carefull y supervised when they are in the same room as the appliance. T od- dlers, young childr en and others may be susce ptibl e to accidental contact burns. A physical barrier is recommended if there are at risk individuals in the house. T o restrict [...]

 FOR YOUR SAFETY do not insta ll or opera te this applia nce without first reading and understanding this manual. Any installation or operation of the appliance deviating from that which is stated in this manual WILL void the warranty and may be hazardous.  INST ALLA TION AND REP AIR SHOULD ONL Y BE DONE BY A QUALIFIED SERVICE TECHNICIAN.[...]

GENERAL INFORMA TION 5 I npu t (B TU/ HR) M an ual ly -M odu lat ed G as Va lve s ( mil liv ol t mod el s) Mo del s Na tur al G as Pr opa ne CI 150 0D VF 17 ,50 0 to 28 ,00 0 20 ,50 0 to 27 ,00 0 CI 250 0D VF 25 ,50 0 to 8, 500 26 ,50 0 to 34 ,50 0 T able 1 Note: Installation and repair should be per formed by a qualified service person. The appli[...]

6 Installation of these appliances are approved for installation in New Y ork City in the US state of New Y ork. (Massachusetts Approval #G1-1105-11) These appliances are approved for installation in the US state of Mas- sachusetts if the following additional requirements are met: • Install this appliance in accordance with Massachusetts Rules an[...]

7 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 1 H (with optional warming shelves) F E (with ashlip) A B D L E N N O X G C Dimensions CI1500DVF CI2500DVF A 24-1/2” (622 mm) 30-1/2” (775 mm) B 27-1/2” (699 mm) 28-1/2” (724 mm) C 19” (483 mm) 22” (559 mm) D 7” (178 mm) 7” (178 mm) E 20-1/2” (521 mm) 23-1/2” (597 mm[...]

8 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. T op Vi ew / Cor ne r Cle ara nc es T op Vi ew / Rea r W a l l o r A lc ov e C lea ra nc es Si de Vi ew / Rea r W a l l o r A lc ov e C lea ra nc es Clearance T o Combustibles and Alcove Dimensions Figure 2C Clearances T o Combustible Materials / Floor Protection • The location should also b[...]

9 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 12 X Roof Pitch is X/12 2 FT MIN. 2 FT MIN. Lowest Discharge Opening H* *H = MINIMUM HEIGHT FROM ROOF TO LOWEST DISCHARGE OPENING OF VENT TERMINA TION HEIGHTS FOR VENTS ABOVE FLA T OR SLOPED ROOFS Horizontal Overhang Vertical Wall Vent T ermination Storm Collar Concentric Vent Pipe Flashing 1 [...]

10 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Mi ni m um C l ea ra n ce s Ca na d ia n I ns ta l la ti o n * US I n st al l at io n * * A = Cl ea r a nc e ab o ve gr a d e, ve r a nd a , po r c h, de ck or b al c o ny . 12 i nc h e s (30 cm ) * 12 i nc h e s (30 cm ) * * B = Cl e ar a nc e t o wi n do w o r d oo r t ha t m ay b e op e n [...]

11 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Remove the screws and support plate which secure the stove legs to the pallet. Lift stove off of the pallet and place it into position (where unit is to be installed). IM POR T A NT N O TE : I f p r op ane i s u s e d, b e a w ar e t h at i f t h e t an k s i ze i s t o o sm all ( i . e. u n [...]

12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Note: Install Leg Leveling Bolts if Necessary: The four leg leveling bolts (included in literature package), are provided for leveling the stove if necessary . T o install, thread the bolts into the existing holes in the bottom of each leg. T urn the leveling bolts to adjust for correct heigh[...]

13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. CAUTION: Label all wires prior to disconnection when servic- ing controls. Wiring errors can cause improper and dangerous operation. A TTENTION: Au moment de l'entretien des commandes, étiquetez tous les fils avant de les débrancher . Des erreurs de cáblage peuvent entraîner un fonct[...]

14 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Blower Mounting Bracket Black Black White White Fan Disc Rheostat Blower Assembly (Shown Rotated 90 Degrees CCW) Black Power Cord Blower Wiring Diagram W ARNING The power cord must be plugged directly into a properly groun ded three-p rong 120 volt, 60 hz wall recepta cle. Do not cut or remov[...]

15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 13 Figure 14 Horizontal Run (in feet) Vertical Run (in feet) Measure from the appliance flue collar to the top of the vent pipe Unacceptable Venting Configuration Ve rti cal T ermi nat ion s Must be in this area Vertical Run (in feet) Measure from the appliance flue collar to the to[...]

16 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Direct-Vent Retrofit Of Existing Chimney System An existing Class-A (wood-burning) Metal Chimney or Masonry Chim- ney can be converted to a direct-vent system. Use one of the following chimney conversion kits listed below. Have the existing chimney system inspected by a professional prior to[...]

17 DIRECT -VENT SYSTEM COMPONENTS The following "Security Secure Vent TM " or "Simpson Dura-V ent" brand Direct-Vent components may be safely used with these appliances. IMPORT ANT NOTE: S ea l t he fi r st s e ct io n o f p ip e t o th e s to v e co l la r u si ng mi ll - pa c b la ck , h ig h t em p er at u re s e al an t . N[...]

18 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Gas Valve 3/ 8 " NPT x Fl a re Fi t ti ng 3/8" Flex T ubing 3/8" Nipple 3/8" Union 3/8" Close Nipple 3/8" Shut-off Valve 1/2" x 3/8" Reducer G a s S t u b 1/2" x 3/8" Flare Shut-off Valve Gas Solid Line Connector Gas Flex Line Connector * S e [...]

19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 4 . Place the center log piece over the corresponding pins next to the front left log as shown in Figure 23 . Center Log Piece Figure 23 Center T op T wig 7. Install the center top twig onto the corresponding pin on the rear log and align it with the indentation on front left log as shown in [...]

20 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. T u r n on gas s u pp l y an d tes t for ga s le ak s u si n g a ga s lea k tes t so l ut ion (al s o re f er r ed to as bub b le le ak sol u ti o n) . Not e : Us in g a so a py wat er sol u ti on (5 0 % dis h soa p , 50% w at e r) i s an e ff ect iv e l ea k te s t sol u ti o n but i t is n [...]

21 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. IMPORT ANT Ensure that the front glass panel is in place and sealed during adjustment. WARNING Air shutter adjustment should only be performed by a qualified professional service technician. CAUTION The adjustment rod and nearby appliance surfaces are hot. Exercise caution to avoid injur y w[...]

22 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Re f . A ir sh u tt er Pa te n t: U. S . P at . 5 , 55 3, 603 Figure 34 Adjustment Rod Up (1/8" Open Position) Air Shutter Burner T ube Adjusting Set Screw Adjustment Rod Down (full open position) Burner Air Shutter Adjustment CAUTION The cast iron stove top is ver y heavy and may requir[...]

23 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. La chimenea caliente cau- sará quemaduras graves Nunca permita que los niños toquen el vidrio ni otras partes de la chimenea ADVERTENCIA Un foyer chaud peut causer de graves brûlures Ne laissez jamais un enfant toucher à la vitre ou à toutes autres parties du foyer A VE R TISSEMENT A TT [...]

24 RA TING LABELS MANUFACTURED AT : AUBURN, WASHINGTON FOR USE WITH NATURAL GAS. EQUIPE POUR GAZ NATUREL ALTITUDE MIN. GAS SUPPLY PRESS (“WC) PRESS MIN. D’ALIMENTATION (“CE) MANIFOLD PRESSURE (“WC) PRESSION CE TUBULURE (“CE) MANUFACTURER’S RECOMMENDED ORIFICE SIZE DIMENSION DE L’INJECTEUR RECOMMANDE PAR MANUFACTURIER (DMS) MAX INPUT ([...]

25 NOTES[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Printed in U.S.A. © 2003 Lennox Hearth Products P/N 775,147M REV . E 03/2010 1508 Elm Hill Pike, Suite 108 • Nashville, TN 37210 Lennox reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and prod[...]