United States Stove 3000 (L) инструкция обслуживания

Owner’s Operation and Instruction Manual C S S U C O M P A N Y U N I T E D S T A T E S S T O V E SAFETY NOTICE: If this heater is not properly install ed, a house re may result. For your safety, follow the in- stallation instructions. Never use make-shift compromises during the installation of this heater. Contact local building or re of[...]

2 Ussc CONGRATULATIONS! You’ve purchased a heater from North America’s oldest manufacturer of wood burning products. By heating with wood you’re helping to CONSERVE ENERGY! Wood is our only Renewable Energy Resource. Please do your part to preserve our wood supply. Plant at least one tree each year. Future generations will thank you. The inst[...]

Ussc 3 " CUT HERE " CUT HERE WARRANT Y INFORMA TION CARD     [...]

4 Ussc " CUT HERE " CUT HERE Ê É        ?[...]

Ussc 5 Tools and Materials Needed For Installation You will need a drill with a 1/8” bit to install sheet metal screws into connector pipe. A 5/16” socket/wrench or screw driver to install pedestal trim, room air deector, and blower assembly described below. A 1/2” socket/wrench to install ue collar. A non-combustible oor protector a[...]

6 Ussc ASSEMBLY INSTRUCTIONS Blower Assembly THE BLOWER ASSEMBL Y MUST BE DISCONNECTED FROM THE SOURCE OF ELECTRICAL SUPPL Y BE- FORE A TTEMPTING THE INST ALLA TION. THE BLOWER ASSEMBL Y IS INTENDED FOR USE ONL Y WITH A STOVE THA T IS MARKED TO INDICA TE SUCH USE. DO NOT ROUTE THE SUPPL Y CORD NEAR OR ACROSS HOT SURF ACES! Fix the assembly to the b[...]

Ussc 7 INSTALLATION SAFETY NOTICE • IF THIS STOVE IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. TO REDUCE THE RISK OF FIRE, FOLLOW THE INSTALLATION INSTRUCTIONS. • THI S ST OVE IS NOT APP ROVED FO R INSTAL LATI ON IN A MA NUFACTURE D OR MO BILE HOME. • CONSULT YOUR MUNICIPAL BUILDING DEPARTMENT OR FIRE OFFICIALS ABOUT PERMITS, RESTRICTI[...]

8 Ussc FLOOR PROTECTOR Your wood stove should be placed on a 1 inch, non-combustible surface with a k factor of 0.84. For multiple layers, add R-values of each layer to determine the overall R-value. The R value for the required board is 1.2. If there is a horizontal section of chimney connector, the oor protector should go under it and 2 inches[...]

Ussc 9 CLEARANCES TO COMBUSTIBLES It is of utmost importance that the clearances to combustible materials be strictly adhered to during installation of the stove. Refer to the tables below : • Floor to ceiling height must be at least 7’ (2.13m) in all cases. • Do not place any combustible material within 4’ (1.2m) of the front of the unit. [...]

10 Ussc CHIMNEY CONNECTOR (STOVE PIPE) Your chimney connector and chimney must have the same diameter as the stove outlet (6”). If this is not the case, we recommend you contact your dealer in order to insure there will be no problem with the draft. The stove pipe must be made of aluminized or cold roll steel with a minimum thickness of 0.021” [...]

Ussc 11 CHIMNEY Your wood stove may be hooked up with a 6” factory built or masonry chimney. If you are using a fac- tory built chimney, it must comply with UL 103 or CSA-B365 standard; therefore it must be a Type HT (2100°F). It is extremely important that it be installed according to the manufacturer’s specications. If you are using a mas[...]

12 Ussc FACTORY BUILT CHIMNEY : When a metal prefabricated chimney is used, the manufacturer’s installation instructions must be followed. You must also purchase (from the same manufacturer) and install the ceiling support package or wall pass-through and “T” section package, restops (where needed), insulation shield, roof ashing, chimn[...]

Ussc 13 MASONRY CHIMNEY : Ensure that a masonry chimney meets the minimum standards of the National Fire Protection As- sociation (NFPA) by having it inspected by a professional. Make sure there are no cracks, loose mortar or other signs of deterioration and blockage. Have the chimney cleaned before the stove is installed and operated. When connect[...]

14 Ussc Combustible Wall Chimney Connector Pass-Throughs Method A. 12” (304.8 mm) Clearance to Combustible Wall Mem- ber: Using a minimum thickness 3.5” (89 mm) brick and a 5/8” (15.9 mm) minimum wall thickness clay liner, construct a wall pass- through. The clay liner must conform to ASTM C315 (Standard Specication for Clay Fire Linings) [...]

Ussc 15 OUTSIDE COMBUSTION AIR Your wood stove is approved to be installed with an outside air intake which is necessary for a tightly constructed home and houses with a negative pressure problem. You can purchase this option through your heater dealer. Make sure to specify the part number mentioned in this booklet. Instal- lation instructions are [...]

16 Ussc TYPE WEIGHT (LBS. CU. FT., DRY) PER CORD EFFICIENCY RANKING SPLITS MILLIONS BTU’s/CORD Hickory 63 4500 1.0 Well 31.5 White Oak 48 4100 .9 Fair 28.6 Red Oak 46 3900 .8 Fair 27.4 Beech 45 3800 .7 Hard 26.8 Sugar Maple 44 3700 .6 Fair 26.2 Black Oak 43 3700 .6 Fair 25.6 Ash 42 3600 .5 Well 25.0 Yellow Birch 40 3400 .4 Hard 23.8 Red Maple 38 [...]

Ussc 17 THE FIRST FIRES The fresh paint on your stove needs to be cured to preserve its quality. Once the fuel charge is properly ignited, only burn small res in your stove for the rst four hours of operation. Never open the air control more than necessary to achieve a medium burn rate. Make sure that there’s enoug h air circulation while c[...]

18 Ussc WARNINGS • NEVER O VERF IRE YOUR ST OVE. IF ANY PA RT OF THE STOVE STARTS TO GLOW RED, OVER FIRING IS HAPPENING. READJUST THE AIR INTAKE CONTROL AT A LOWER SETTING. • THE INSTALLATION OF A LOG CRADLE or GRATES IS NOT RECOMMENDED IN YOUR WOOD STOVE. BUILD FIRE DIRECTLY ON FIREBRICK. • NEVER PUT WOOD ABOVE THE FIREBRICK LINING OF THE FI[...]

Ussc 19 ASH DISPOSAL Ashes should be removed from the stove every few days or when ashes get to 2 to 3 inches deep. Always empty the stove when it is cold, such as in the morning. Ashes should be placed in a metal container with a tight tting lid. The closed container of ashes should be placed on a non combustible oor or on the ground, well a[...]

20 Ussc REPAIR PARTS 1 8 9 11 40 17 18 20 19 16 15 23 25 26 24 39 35 36 37 38 27 29 30 28 33 34 31 12 13 14 32 5 6 7 2 3 4 22 21 10 4 3 1 5 6 7 2 9 8 10 11 Feed Door Assembly[...]

Ussc 21 REPAIR PARTS Key Part No. Description Qty . 1 25491 Feed Door, Painted (40484) 1 2 25692 Handle, Painted (40515) 1 3 83506 3/8 x 1-1/4 Roll Pin 1 4 891 135 Spring Handle - LG 1 5 88066 Rope Gasket - 5/8” 4.6 Ft 6 88087 Glass Gasket - 1/8 thk x 1” wide 3.7 Ft 7 891 131 Ceramic Glass 1 8 25464 T op Glass Retainer 1 9 25465 Bottom Glass Re[...]

24 Ussc THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPENDABLE SERVICE FROM YOUR HEATER, AND ENABLE YOU TO ORDER REPAIR PARTS COR- RECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFERENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING INFO[...]

2 3 Ussc NOTES[...]

Ussc 2 4 NOTES[...]

20 Ussc C E M AN UE L VO US A ID ER A À O BT EN IR U N FO NC TI ON NE M E NT E FF IC AC E E T F IA BL E DE V OT RE P OÊ L E ET V OU S PE RM ET TR A DE C OM MA ND ER C O RR EC TE ME NT T OU TE P IÈ C E DÉ TA CH ÉE . G A RD EZ C E MA NU EL D AN S U N LI EU S ÛR P OU R TO UT E C O NS UL TA TI ON U L TÉ RI EU RE . L O RS QU E VO US N OU S ÉC RI[...]

Ussc 19 ÉL IM INAT ION DES CEN DR ES Les cendr es dev ront être é limin ées du poêle plusi eurs f ois pa r sema ine ou quand la cou che de cen dres a ttein t 2 ou 3 pouc es. Vi dez touj ou rs le poê le qua nd il est fr oid, en mati née par exe mple. Élimi nez touj ours les ce ndr es dan s un c onten eur m étall ique aya nt un couv erc le d[...]

18 Ussc A V ER TI SS EM EN TS • NE S UR CHA UF FE Z PA S VO TRE P OÊ LE. S I UN E PAR TI E DU PO ÊL E COM ME NC E À RO UG IR, U NE SU RC HAU FF E SE PR OD UI T. RÉ AJU ST EZ LA COM MA NDE D' ADM IS SI ON D'A IR AU NI VEA U DE RÉ GL AGE L E PL US B AS . • L' IN STA LL AT IO N D' UN PO RT E-B ÛC HE ou DE GR IL LES DAN S [...]

Ussc 17 LES PRE MIERS FEU X La pe int ure fr aîc he de vo tr e p oêl e a bes oi n d'ê tr e cui te p our pr és erv er s a qu al it é. U ne foi s q ue le com bus tib le e st cor rec tem en t all umé, fa ites un iquem ent brû ler de pet its feu x dans votre poê le lors des qua tre pre mière s heure s de fon ction nem ent. N'o uvrez [...]

16 Ussc T Y P E P O I D S ( L B S . C U . F T . , À V I D E ) P A R C O R D O N C L A S S E M E N T D ' E F F I C A C I T É S E F E N D M I L L I O N S B T U / C O R D O N Hickory 63 4500 1,0 Bien 31,5 Chêne blanc 48 4100 0,9 Correct 28,6 Chêne rouge 46 3900 0,8 Correct 27,4 Hêtre 45 3800 0,7 Dur 26,8 Érable à sucre 44 3700 0,6 Correct [...]

Ussc 15 AIR DE COMBUSTION EXTÉRIEUR Vot re poê le en bois est cer tié pour une insta llat ion compr enan t une arri vée d’a ir ext érieu r, ce qui est néc essa ire pou r le s ma iso ns b ien iso lées o u aya nt u n pr ob lèm e de pre ssi on n égati ve. Vous pouv ez v ou s pr ocur er cet te opt ion che z v ot re vend eur de cha uff ag [...]

14 Ussc P a s s a g es de ra c c o r d e m e nt de ch e m i n é e à t r av e r s u n e pa r oi co m b u s t i b l e Mé th od e A. Dé ga g e me nt de 12 ” ( 30 4 ,8 mm ) av ec un me mb re d e pa r oi co mb us ti b l e : En ut i li sa nt de s br iq ue s d' un e ép ai s se ur m in im al e de 3, 5” (8 9 mm ) et un r e vê te me nt en ar g[...]

Ussc 13 CHEMINÉE EN MAÇONNERIE : Ass urez -vo us qu'un e ch eminé e en maç onner ie r épond e au x st andar ds minim um d e l' As soc iati on n ation ale de prot ect ion con tre les ince ndie s (NF PA) en la fais ant insp ecte r par un pro fessi onne l. Assu rez- vou s qu' il n'y ait pas de ss ures, de mor tier s perd us[...]

12 Ussc CHEMINÉE FABRIQUÉE EN USINE : Lor squ' une ch em iné e m éta lliq ue préfa briq ué e est uti lisé e, les ins tru ctio ns d'ins tall at ion du fabri quan t doi ve nt êtr e re spect ées. Vous dev ez ég alem en t ache ter (aup rès du même fab ri qua nt) et inst alle r l'en semb le de sup port du toit ou le pass age d[...]

Ussc 11 C H EM IN ÉE Vot re poêl e à bois doit être racco rdé ave c un e che min ée fabr iquée en usi ne ou en maço nn eri e de 6”. Si vou s util ise z une ch eminé e fabr iqu ée en us in e, el le doi t ré pon dre à la no rme UL 10 3 et CAN/C SA-B3 65 ; pa r co nsé quen t el le doit êt re de ty pe HT (2 10 0 °F ). I l es t ex trê [...]

10 Ussc R A CC OR D DE C HE MI NÉ E (T U Y A U PL IS SÉ ) V ot r e ra c co r d de c h e mi n ée e t v ot r e c h em i né e do iv e n t a v oi r le m ê me d i a mè t re q ue la s o rt i e du po êl e (6 ” ) . Si c e n 'e s t p as le ca s, no u s v o u s r ec o mm a n do n s d e c on t ac t er vo t r e v en de u r a n d e v ou s a ss [...]

Ussc 9 DÉGAGEMENTS AVEC LES MATIÈRES COMBUSTIBLES Il e st extrêmem ent importan t q ue l es dégageme nts avec le s ma tières c ombu stib les soient strictem ent respectés lors de l'installation du poêle. Consultez les tableaux ci-dessous : • La haute ur en tre le sol e t le plaf ond doit être d'a u m oins 7’ (2 ,13 m) dans tou[...]

8 Ussc ARRIÈRE A V ANT CÔTÉ CÔTÉ P R OT EC TE UR D E SO L Vo tr e poê le à bo is de vr a ê tr e p la cé su r u ne su rf ac e n on co mb ust ib le d' 1 p ou ce av ec un fa ct eu r k de 0, 84 . Po ur l es pr o te ct eu rs à c ou ch es m ul ti p le s, a jo ut ez l es v al eu rs R d e cha qu e co uc he a n d e dé te rm in er la va le[...]

Ussc 7 INSTALLATION AV IS DE S ÉC UR IT É • L' IN STA LL AT IO N IN COR RE CT E DE C E PO ÊL E PO URR AI T ENT RA ÎN ER L 'I NCE ND IE DU DO MI CIL E. AF IN DE R ÉDU IR E LE RI SQ UE D' IN CE ND IE , RE SPE CT EZ LE S IN ST RU CT IO NS D 'IN ST AL LA TI ON . NE P AS R ES PE CTE R LE S IN ST RUC TI ONS PEU T EN TR AÎ NE R[...]

6 Ussc I N S T R U C T I O N S D ' A S S E M B L É E L'ENSEMBLE DE LA SOUFFLANTE DOIT ÊTRE DÉCONNECTÉ DE LA SOURCE D'ALIMENT A TION É L E C T R I Q U E A V A N T L E D É M A R R A G E D E L ' I N S T A L L A T I O N . N’ ACH EM INE Z P A S LE COR DON D’A LIM ENT A TIO N À P R O X I M I T É O U S U R D E S S U R F A C[...]

Ussc 5 VIS 5/16-18 X 1-1/2 HA UT DE L' AP P AREI L DE CH AU FF AGE LA NG UETT E SO UD ÉE O u ti ls e t éq ui pe me nt s n é c es sa ir es p ou r l' in st a l la ti on Vo us au rez bes oi n d' une per ce us e éq ui pée d'u n fo re t d e 1/ 8” a n d' ins ta lle r le s vi s à t ôle dan s l e r acc or d de co ndu it[...]

4 Ussc " DÉCOUPEZ ICI " DÉCOUPEZ ICI Ê É       ?[...]

Ussc 3 " DÉCOUPEZ ICI " DÉCOUPEZ ICI C A R T E D E G AR AN TI E                                        ?[...]

2 Ussc FÉLICITATIONS : Vous avez acheté un poêle auprès du plus ancien fabricant de produits de combustion du bois d'Amérique du nord. En vous chauffant au bois, vous aidez à ÉCONOMISER DE L'ÉNERGIE ! Le bois est notre seule source d'énergie renouvelable. Veuillez contribuer à la préservation de nos ressources en bois. Pla[...]

United States Stove Company 227 Industrial Park Road P.O. Box 151 South Pittsburg, TN 37380 Manuel d'utilisation destiné au propriétaire A VI S D E S ÉC U RI T É : L 'i n st al l at i on i nc o rr e ct e de c e p o êl e po u rr a it e nt r aî n er l 'i n ce nd i e du d om ic i le . P ou r vo tr e sé cu r it é , re s pe c te z[...]