Traulsen RAC3T инструкция обслуживания

This T raulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated cabinets this way as a matter of pride. This philosophy has made Traulsen the leader in commercial refrig- eration since 1938. W e thank you for your choice and confidence in T raulsen equipment and we know you will receive many years of u[...]

T ABLE OF CONTENTS The serial tag is a permanently affixed sticker on which is recorded vital electrical and refrigeration data about your T raulsen product, as well as the model and serial number . This tag is located on the upper right interior side wall of all air curtain models. I. THE SERIAL T AG -1- FORT WORTH, TX. SERIAL MODEL VOL TS Hz PH T[...]

III. e - CORD & PLUG: T raulsen Air Curtain models are supplied with a cord & plug attached. It is shipped coiled at the bottom of the cabinet, secured by a nylon strip. For your safety and protection, all units supplied with a cord and plug include a special three-prong grounding plug on the service cord. Select only a dedicated electrical[...]

IV . INTENDED USE (continued) V . PRODUCT FEA TURES (cont ’ d) V. f - TRA Y SLIDES: T en (10) pairs of removable tray slides are provided standard at 4-1/2 ” spacing. Additional tray slides may also be purchased for a total of no more than 15 pairs at 3 ” spacing. Each tray slide can accommodate ei- ther one (1) 18 ” x 26 ” or one (1) 12 [...]

VI. ELECTRONIC CONTROLLER (cont ’ d) -4- VI. d - CONTROL FEA TURE - ON LIGHT : When illuminated the ON light indicates that the power is ON. VI. e - CONTROL FEA TURE - CYCLE LIGHT : When illuminated the CYCLE light indicates that the cabinet is cooling down to the desired SET -POINT tem- perature. When the refrigeration system is ON, this light w[...]

-5- VII. a - CLEANING THE CONDENSER: The most important thing you can do to insure a long, reliable service life for your T raulsen is to regularly clean the condenser coil. The condensing unit requires regularly scheduled cleaning to keep the finned con- denser clean of lint and dust accummulation. Keeping the condenser clean allows the cabinet to[...]

-6- IX. TROUBLESHOOTING GUIDE 1. Condensing unit fails to start - no hum. 1. Line Disconnected - Reconnect 2. Fuse - Replace Fuse 3. Overload Protection - Determine Reason & Correct, Replace If Necessary 2. Condensing unit fails to start - hums but 1. Improperly Wired - Check Wiring Against Diagram trips on overload protector . 2. Low V oltage [...]

-7- 6. Condensing unit operates for prolonged 1. Shortage Of Refrigerant - Fix Leak, Add Charge periods or continuously . 2. Control Contacts Stock or Frozen Closed - Clean Contacts or Replace Control 3. Excessive Heat Load Placed Into Cabinet - Allow Unit Sufficient Time For Removal Of Latent Heat 4. Prolonged or T oo Frequent Door Openings - Plan[...]

-8- X. WIRING DIAGRAM[...]

-9- XI. W ARRANTY INFORMA TION ST ANDARD DOMESTIC W ARRANTY TRAULSEN & CO., INC. warrants new equipment to the original purchaser , when installed within the United States against defective material and workmanship for one (1) year from the date of original installation. Under this war- ranty , TRAULSEN & CO., INC. will repair or replace, a[...]

XII. INDEX -10- A Air-Flow , Proper 2 B Bill Of Lading (carrrier ’s) 2 Bumper , Perimeter 3 C Casters 3 Cleaning 3 Clearance 2 Compressor Oils 2 Condensate Evaporator 3 Cord & Plug 2 Condenser Clean 7 Clearance 2 Cycle Light 4 D Defrost 3 Defrost, Manual On-Demand 3 Digital Thermometer 2 E Electronic Controller 3-4 F Freight Damage 2 G Grips,[...]

T raulsen & Co., Inc. 4401 Blue Mound Road Fort Worth, TX 76106 Phone: (800) 825-8220 Fax-Svce: (817) 740-6757 W ebsite: www .traulsen.com HOURS OF OPERA TION: Monday thru Friday 7:30 am - 4:30 pm CST Quality Refrigeration[...]