Toshiba a210 инструкция обслуживания

[CONFIDENTIAL] Toshiba Personal Computer Satellite A210 Maintenance Manual TOSHIBA CORPORATION[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual ii Copyright © 2007 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the inform at[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual iii Preface This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer Satellite A210, referred to as the M100 Series in this manual. The procedures described in this manual are intended to help service t[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual iv The manual is divided into the following parts: Chapter 1 Hardware Overview describes the M100 Series system unit and each FRU. Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems. Chapter 3 Test and Diagnostics describ[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual v Some operations require you to simultaneously use two or m ore keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same tim e press Pause (Break)[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual vi Table of Contents Chapter 1 Hardware Overview 1.1 Features ................................................................................................................... ......... 1-1 1.2 System Unit .................................................[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual vii 2.20 HDMI Troubleshooting…………………………………………………………………..48 2.21 MIC Troubleshooting ……………………………………………………………………54 2.22 Finger Troubleshooting …………?[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual viii Chapter 4 Replacement Procedures 4.1 General .......................................................................... Error! Bookmark not defined. 4.2 Battery ........................................................................... Error! Bookmark[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual ix Appendices Appendix A Handling the LCD Module ................................................................................. A-1 Appendix B Board Layout ..................................................................................................[...]

[CONFIDENTIAL] Chapter 1 Hardware Overview 1[...]

1 Hardware Overvi ew Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-ii[...]

1 Hardware Overvi ew Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-iii Chapter 1 Contents 1.1 Features ................................................................................................................... ... 1-1 1.2 System Unit .....................................................[...]

1 Hardware Overvi ew Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-iv Figures Figure 1-1 2.5-inch HDD ................................................................................................ 1-6 Tables Table 1-1 2.5-inch HDD specifications ...............................................[...]

1.1 Features 1 Hardware Overview Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-1 1.1 Features The Minnesota 10A/10AG (Satellite A210/ A2 15, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series)Series Personal Co mputer uses extensive Large Scale Integration (LSI), and Complementary Metal-Oxide S[...]

1 Hardware Overview 1.1 Features Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-2  Offers constant voltage 19V output source with 120W m ax output power capacity for Minnesota 10AG • 3 cells of Li-Ion 18650 size, smart battery pack with 2000mAH x 10.8V (21.6W) • 6 cells of Li-Ion 18650 si[...]

1.1 Features 1 Hardware Overview Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-3 • One S-Video port • One microphone port • One headphone-out jack • Digital/Rotary volume control • Wireless communication switch • One DC-in jack • One RJ-11 jack for 56kbps V.92 modem • One RJ-45 j[...]

1 Hardware Overview 1.1 Features Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-4  Switches • Power button • Two programmable launch buttons • Four control buttons for CD playing • Wirele ss communica tion swi tch  Security • Fingerprint authentication  AC Ad apt e r • Unive[...]

1.2 System Unit 1 Hardware Overview Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-5 1.2 System Unit The system unit is composed of the following major co mponents:  Processor • AMD Turion 64 Dual Core TL-50/ TL- 52/ TL-5 3/ TL-56/ TL-58/ TL-60/ TL- 64/ TL-66 • AMD Sempron Single Core 3400[...]

1 Hardware Overview 1.3 2.5-inch Hard Disk Drive Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-6 1.3 2.5-inch Hard Disk Drive The internal HDD is a random access non-volatile storage device. It has a non-removable 2.5-inch magnetic disk and mini-Winchester ty pe magnetic heads. The computer sup[...]

1.3 2.5-inch H ard Disk Drive 1 Hardware Over view Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-7 Items 160GB 200 GB 250GB 300GB Form atte d capacity (GB) 149.05 186.31 232.89 279.46 Logical Blocks (LBA) 312,581,808 39 0,720,96 8 488,397,168 58 6,072,368 Rotati onal speed (rpm) 5400/4200 4200 4[...]

1 Hardware Overvi ew 1.4 Optical Disc Devi ce Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-8 1.4 Optical Disc Device 1.4.1 DVD Super Multi Double Layer The DVD Super Multi drive accepts 12-cm (4.72-inch) and 8-cm (3.15-inch) discs. At maximum, the drive can play back a DVD at 8x speed, read CD[...]

1.4 Optical Disc D evice 1 Hard ware Overview Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-9 1.4.2 HD DVD-ROM The HD DVD drive accepts 12-cm (4.72-inch) and 8-cm (3.15-inch) discs. At maximum, HD DVD-ROM reads HD DVD-ROMs at maximum 1x speed DVD-ROMs at maximum 8x speed and CD-ROMs at maximum 2[...]

1 Hardware Overvi ew 1.5 Power Supply Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-10 1.5 Po wer Supp ly This specification defines the performance and characteristics of the 75W, 90W, and 120W AC adapter power supply. It sup plies a consta nt voltage 19V output source for the Minnesota 10A/10[...]

1.5 Power Supply 1 Hardware Overview Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-11  Battery charging control • The EC controls the following. – The quick charging ON/OFF – The detection of full charge  Detection of the low battery • The EC detects the low b attery point by the g[...]

1 Hardware Overvi ew 1.6 Batteries Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-12 1.6 Batter ies The computer has two types of battery :  Main battery pack (18650 size)  RTC battery The removable main battery pack is the co mputer’s main power source when th e AC adapter is not att ac[...]

1.6 Batteries 1 Hardware Overview Satellite A 210/ A215, Satell ite Pro A210, EQ U IUM A210, SA TEGO A210 Series Maintenance Manual 1-13 1.6.1 Main Battery Battery charging is contr olled by a power supply microprocessor that is mounted on the system board. The power supply microprocessor controls whether the charge is on or off and detects a full [...]

1 Hardware Overvi ew 1.6 Batteries Satellite A 210/ A215, Sa tellite Pro A 210, EQUIUM A210, SATEGO A 210 S eries Maintenance Manua l 1-14 1.6.2 RT C battery The RTC battery provides power to keep the current d ate, time and other setup infor mation in memory while the computer is turned off. The table below lis ts the charg ing time and data prese[...]

Chapter 2 Troubleshooting Procedures 2[...]

[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUI UM A210, SATEGO A210 Series Maintenance Manual 1 Chapter 2 Contents 2.1 Troubleshooting Introduction ................................................ ........................................3 2.2 Troubleshooting Flowchart ....................................................[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A2 10, SATEGO A210 Series Mainten ance Manual 2 Figures Figure 2-1 Troubleshooting flowchart (1/2) ....................................................................... 5 Figure 2-1 Troubleshooting flowchart (2/2) ........................................................[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 3 2.1 Troubleshooting Introduction Chapter 2 describes how to determine if a Fiel d Replaceable U nit (FRU) in the computer is causing the computer to malfunction. The FRUs covered are: 1. Display 7. Speaker 1 3. Camera 2. USB [...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 4 2.2 Troubleshooting Flowchart If you know the location of the malfunction, turn directly to the appropriate section of this chapter. If the problem is unspecified, use the flowchart in Figure 2-1 as a guide for determining w[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 5 STA R T C onnect t he A C adap t er t o t he D C -I N socket Is th e D C -IN L E D o n? I s t h e B at t ery L E D on ? T u rn th e P o w e r sw itch o n I s t h e P o we r On LE D o n ? I s t he " T os hi ba" l ogo[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 6 A Does ty ped characters appear correctly? Insert the diagnostics disk into the FDD. Then run the diagnostics test program . Is the diagnostics test loaded? Allow each test to perform automatically Is an error detected by an[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 7 If the diagnostics program cannot detect an error, the problem may be intermitte nt. The test program should be executed several times to isolate the problem. When a problem has been located, perform the appropriate troub les[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 8 Other problems that are not covered by the diagn ostics program may be discovered by a user. 1. If an error is detected when usin g an external USB d evice, perfor m the External USB Devices Troubleshooting procedur es in Se[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 9 2.3 Power Suppl y Troubleshooting STA RT A re t he D C-IN and B a tter y L E D s lit? C a n yo u tu rn th e com puter on? A re the in tern a l p ow e r connecti ons secure? END Check P ow er Supply St atus (Proced ure 1) No Y[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 10 The power supply controls many functions an d components. To deter mine if the power supply is functioning properly, start with Procedure 1 and continu e with the other Procedures as instructed . The flowchart in Figure 2- [...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 11 Amber color off Battery not in low or critical low state; It’ s in discharging state[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 12 Table 2-2 DC-IN LED AC-IN LE D Power supply sta tus Solid on AC power exists (LED is solid Blue). Of f No AC powe r exist s. To check the power supply status, install a battery p ack and connect an AC adaptor to the DC-IN p[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 13 Procedure 3 Po wer supply connection check The power supply wiring diagra m is shown below: AC adapt or Sys t em boar d Ba t t e r y A C adapt or cord A C p ow er cord Any of the connectors may be disconnected. Perform Check[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 14 Procedure 4 Diagnostic check The power supply may not charge the battery pack. Perfor m the following procedures: 1. Reinstall the b attery pack. 2. Attach the AC adaptor and turn on the power. If you cannot turn on the pow[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 15 2.4 Display Troubleshooting P erf o r m ex t erna l d i spl ay ch eck ( P r oce dur e 1) STA R T D o es the ex t e rnal di s pl ay f unc t i on ok? P erf o r m diagno st i c ch eck (P ro ce du re 2 ) No W as a d i sp l a y p[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 16 This section describes ho w to determine if the computer’s display is functioning properly. The process is outlined in Figure 2-3. Start w ith Procedure 1 and continue with the other procedures as instruc ted. Procedure 1[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 17 Procedure 3 Connector and replacement ch eck The FL inverter board, LCD module, and system board are co nnected to the display circuits. Any of these components may be damaged. Refer to Chapter 4, Replaceme nt Proc edures , [...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 18 2.5 Keyboard Troubleshooting P erfo rm ex tern al ke yb o ard ch ec k (P ro ce du re 1 ) STA R T D o es t h e ext ernal keyb oar d f unct i on ok? P erf o r m diagno st i c ch eck (P ro ce du re 2 ) W as a keyboa rd pr o bl[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 19 Figure 2-4 Keyboard troubleshooting process To determine if the computer’s keyboard is functioning properly, perform the following procedures. Figure 2-5 outlin es the process. Start with Procedure 1 and continue wi th the[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 20 Check 3 The system board may be damaged. Replace it with a n ew one following the instructions in Chapter 4 . 2.6 External USB De vices Troubleshooting R eplace syst em b oard ( P r oce dur e 2) END Or i g i n a l US B devi[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 21 Figure 2-5 External USB de vice troubleshooting process To determine if the co mputer’s external USB devices are fun ctioning properly, perform the following procedures. Figure 2-6 outlines the proc ess. S tart with Proced[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 22 2.7 TV-Out Failure Trou bl esh ooting Per f orm TV conn ec t i on c hec k (P ro ce du re 1 ) STA R T D o es rep l ac em e nt TV cable f unct i on pr oper l y? Perf orm T V s et check (P ro ce du re 2 ) R epl ace syst em b o[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 23 To determine if the computer’s TV-out port is functioning p roperly, perform the following procedures. Figure 2-7 outlin es the process. Start with Procedure 1 and continue as instructed. Procedure 1: TV connection check P[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 24 2.8 TouchPad Tr oubleshooting START END To uchPa d co nnectio n check (Procedure 1) TouchPad replacem ent check (Procedure 2) Replace sy stem board Figure 2-7 Touchpad troubleshoo ting process[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 25 To determine if the computer’s built-in TouchPad is functioning properly, perform the following procedures. Figure 2-9 outlines the proc ess. S tart with Procedure 1 and cont inue as instructed. Procedure 1: TouchPad conne[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 26 2.9 Speaker Troubleshooting START Do all sources have sam e problem ? END Perfor m earphone te st (Procedure 2) Do earphones function correctly? Perform connection check (Procedure 3) Perfor m repl acem ent check (Procedure[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenan ce Manual 27 To determine if the computer’s built-in speakers are functioning properly, perform the following procedures. Figure 2-10 outlines th e process. First adjust the speaker vo lume to an appropriate level. Start with Proce dur[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 28 2.10 Optical Dr ive Troubleshooting START Audio CD fun ctions ok? END Perform software check (Procedu re 3) Perform diagno stic test (Procedu re 4) Perfor m connection and replacement check (Procedu re 5) Perfor m audio CD [...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenan ce Manual 29 This section describes how to determine if the computer’s internal optical drive is functioning properly. The Satellite A210/ A215, Satellite Pr o A210, EQUIU M A210, SATEGO A210 Series Mainten ance Manual Ser ies can acco[...]

2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 30 Procedure 5 Connection chec k and replacement check The optical drive connects to the system board. The drive may be disconnected, or the driv e or system board may be damaged. Disasse mble the computer following the steps [...]

31 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 31 2.11 Modem Troubleshooting START Computer unable to detect telep hone signal? END Perfor m connection check (Proced ure 2) Perform replacement check (Proced ure 3) Perform telephone line connection chec k (Proced ure 1) C[...]

32 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 32 This section describes how to determine if the computer's modem is functi oning properly. Figure 2-12 outlines the process. Perform the steps below starting with Procedure 1 and continuing with the other procedures [...]

33 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 33 2.12 Express card Troubleshooting START D o erro rs o cc u r d urin g E xpres s car d t est ? Pe r form E xp r ess car d sock et r epl acem ent check ( Pr oce dur e 2) R epl ace syst em bo ard END Expre ss car d uni t is [...]

34 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 34 This section describes how to determine if th e Express card player is functioning properly. The process is summarized in Figure 2-13. P erform the steps below starting with Procedure 1 and continuing with the othe r pro[...]

35 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 35 2.13 IEEE 1394 Troubleshooting STA RT Per f o r m IEEE 1 39 4 d ev i c e c h ec k (P roce du re 1) I s I EEE 1394 tr ansmis si on ok? Perform diagnostic check (P roce du re 2) W as a n I EEE 1394 pr obl em det ect ed? Per[...]

36 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 36 To determine if the computer’s IEEE 1394 system is functioning properly, perfor m the following procedures. Figure 2-14 outlines the pr ocess. Start with Procedure 1 and continue with the other procedures as instructed[...]

37 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 37 2.14 Wireless LAN Troubleshooting STA RT Perfor m diagnosti c t est (Procedur e 1) W as a wireless L AN problem delected? Perfor m connector and repl acement check (Procedur e 2) Replace wirel ess L A N antenna/ unit Repl[...]

38 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 38 The wireless LAN antenna wire, wir eless LAN unit or sy stem board may each be th e source of a wireless LAN fault. Any of these components may be damaged. To determine if the computer’s wireless LAN system is function[...]

39 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 39 Check 4 The system board may be damaged. Repl ace it with a new one following the instructions in Chapter 4.[...]

40 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 40 2.15 Camera Troubleshooting Figure 2-14 Camera troubleshooting process[...]

41 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 41 The Camera board or system board may be the r eason of a Ca mera fault. Either of these two components may be damag ed. To determine if the computer’s Camera is functioning properly, perform the following procedures. Fi[...]

42 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 42 2.16 Bluetooth Troubleshooting STAR T Pr efor m diag nos ti c tes t (Proce du re 1 ) Was a Bluetooth probl em detect? Bluetooth is not faulty. Contin ue tro uble shoo ting-re fer to Figure 2.1 Replace syst em board Perfo[...]

43 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 43 The Bluetooth antenna wire, Bluetooth module or system board may be the reason of a Bluetooth fault. Any of these components may be damaged. To deter mine if the computer’s Bluetooth is functioning properly, perform the[...]

44 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 44 2.17 4 in 1 card Troubleshooting START Do errors occur du ring 4 IN 1 CAR D test? Perform 4 IN 1 card socket replacement check (Procedure 2) Replace system board END 4 IN 1 unit is not faulty. Perform 4 i n 1 CARD test ([...]

45 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 45 This section describes how to determine if the 4 IN 1 Card play er is functioning properly. The process is summarized in Figure 2-16. Perfor m the steps below starting with Procedure 1 and continuing with the other proced[...]

46 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 46 2.18 HDD Trouble shooting Figure 2-17 HDD troubleshooting process[...]

47 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 47 The HDD or system board may be the reason of a HDD fault. Either of these two co mponents may be damaged. To determine if the comput er’s HDD is functioning properly, perform the following procedures. Figure 2-15 outlin[...]

48 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 48 2.19 CRT Troubleshooting P er f or m C R T co n n ect i o n ch eck ( P r oce dur e 1) ST A R T D o es r ep l acem en t CRT c a b l e f unc t i on pr ope r l y? P e rfo rm C R T s e t c h e c k ( P r oce dur e 2) R epl ac[...]

49 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 49 To determine if the computer’s CRT port is functioning properly, perform the following procedures. Figure 2-7 outlin es the process. Start with Procedure 1 and continue as instructed. Procedure 1: CRT connection check P[...]

50 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 50 2.20 HDMI Troubleshooting Per f or m H D M I conne ct i on check (P ro ce d u re 1 ) STA R T D oes r epl acem ent H D M I cable fu n c tio n p ro p e rly ? P erf o rm H D M I s et chec k (P ro ce d u re 2 ) R e pl ace sy[...]

51 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 51 To determine if the computer’s HDMI port is functioning properly, perfor m the following procedures. Figure 2-7 outlin es the process. Start with Procedure 1 and continue as instructed. Procedure 1: HDMI connection chec[...]

52 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 52 2.21. MIC Troubleshooting[...]

53 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 53 Figure 2.21. MIC troubleshooting process The MIC line or system board may be the reason of a MIC fault. Either of these two components may be damag ed. To determine if the computer’s MIC is functioning properly, perform[...]

54 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQU I UM A210, SATEGO A210 Series Maintenance Manual 54 2.22 Finger printer troubleshooting[...]

55 2 Troubleshooting Procedures Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Serie s Maintenance Manual 55 Figure 2-22 Finger printer troubleshooting process The Finger printer board or syste m board may be the reason of a finger printer fault. Either of these two components may be damaged. To deter mine if the computer’s Fi[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 1 Chapter 3 Tests and Diagnostics[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 2 Contents 3.1 The Diagnostic Test ........................................................................................................ .... 3 3.2 Executing the Diagnostic Test.............................................................................[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 3 3.1 The Diagnostic Test This chapter explains how to use the Test & Diagnostic program to test the functions of the (Base on Minnesota 10A T&D version 1.0) hardware modules. The Test & Diagnostic Program is stored on t[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 4 3.2 Executing the Diagnostic Test DOS is required to run the DIAGNOSTICS PROGRAM. To start the DIAGNOSTIC PROGRAM, follow these steps: 1. Insert the diagnostics diskette #1 in the floppy disk drive and turn on the computer. (The d[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 5 The below display will show up at the beginning of T&D program If the test result passes, the following display will show up:[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 6 If an error is detected and a test fails, the following message displays: Then press any key for next actions – the below display presented if copying test log file onto diskette is necessary. This action will be executed when ?[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 7 And then it will check if it’s necessary to leave this program. Program will quit when “ Y ” key pressed and it will go back main menu fo r next test if “ N ” key pressed.[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 8 3.3 Display Configuration This Item will show the unit configuration. It includes:  CPU type (Single/ Dual Yunah; Cache ; CPU speed ;CPU FSB)  DDRAM SIZE  ODD TYPE ((DVD-SuperMulti; COMBO; …)  Panel ID  HDD type &[...]

3 Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 9 3.4 Speaker Audio Test The speaker audio test allows the user to aurally confirm the speaker functions. And check both speakers if they are OK within 3 times “Beep” sound generated. NOTE : Remember to tune up the volume as “ [...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 10 3.5 Fan ON/OFF Test The fan test allows the user to test aurally whether the fan is working. And follow the below procedures for this test:  The computer will let the fan be “ON” after any key pressed. Feel the wind or lis[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 11 3.6 Main Battery Charge Test NOTE : The AC adaptor ( 90W, 19V ) should be connected to successfully run this test. This test shows and measures the main battery:  Battery type (Lion)  Manufacturer (Sanyo/Panasonic/Sony) [...]

3 Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 12 3. 7 FDD Test NOTE : Before running the FDD test, prepare a formatted work diskette (1.44 MB). Remove the diagnostics diskette and insert the work diskette into the FDD. The contents of the floppy diskette maybe erased. The Floppy[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 13 3. 8 ODD Test The ODD test allows a user to aurally confirm the ODD functions. NOTE : A CD disc (including data file) must be inserted into the ODD drive then must wait ODD drive initial OK (ODD LED stop flashing) before this tes[...]

3 Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 14 3. 9 Keyboard Test The keyboard test checks the all keys function. NOTE: The Num Lock and the Overlay mode must be off to execute the keyboard test. When you execute this test, the keyboard layout is drawn on the display. When any[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 15 3.10 Mouse (Pad) Test The Mouse test allows the user to select and assign values to the following, using the Touch Pad or “ Tab ” key to move between selections: 1. Mouse Speed (on a scale from slow to fast) 2. Acceleration ([...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 16 After checking T/Pad buttons and cursor’s function, use “Tab” key or use T/Pad cursor to click the “OK” column will end this test. It will indicate whether the subtests pass or fail after three questions. NOTE: The abov[...]

3.12 LCD Pixels Mode Test 3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 17 3. 11 LCD Pixels Mode Test This LCD pixels mode test checks whether video display is fine. This test includes two modes of the test: 1. Text Mode - including 40*25 (16 colors) and 80*25 (2/16colors). 2. [...]

3. Tests and Diagnostics 3.13 Magnetic Switch Test Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 18 3.12 Magnetic Switch Test The lid switch test checks the lid function of the unit. When LCD cover closed, the lid should enable to turn off the display. Follow below steps to run this test: 1. Close the [...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 19 2>. If the Lid switch test pass, it will show below display:[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 20 3.13 LAN Test The LAN test checks the LAN full-duplex environment. NOTE: LAN loopback needs to plug in before test begins. And LAN information will show on the test screen:  IO Base – Port: A000H  IRQ – BH, it’s “IR[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 21 The screen should display as below, indicating whether the subtests pass or fail when finished.[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 22 If an error is detected and a test fails, the following message displays:[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 23 3.14 RTC Test Checks the computer’s RTC (Real Time Clock) and calendar functions by com paring the DOS and CMOS values. The test runs automatically. The screen should display as below, indicating whether the test is passed or f[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 24 3.15 Read 1394 GUID This test will check if the computer’s EEPROM 1394GUID code is correct. NOTE: Must open the RAM Door to see RAM connector GUID bar code before test item begins. The figure below will be displayed:[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 25 3.16 Speaker EQ Type Check&Re-Write This test will check if the computer’s EEPROM EQ type is correct. The EQ Type test includes two subtests of the: 1. Read EQ Type from EEPROM 2. Re-Write EQ Type to EEPROM NOTE : To execut[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 26 3.17 Button Test The control button test allows the user to manually test each of the five CD control buttons. Key ”WWW” nee d t o pr es s fi rst . O ne w ill hear one “bi” sound when press”WWW ” or “Audio” Sound [...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 27 3.18 HDD Test The HDD test allows the user to verify the HDD ok or not. For data security concern, it is necessary to input password - “ hard disk ” before HDD test starts. Please choice Item1 or Item2 to test HDD After the c[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 28 If input password is Right, the screen would display as below: Press any key to test HDD function, the screen would display as below: If input password is wrong, the screen would display as below:[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 29 The screen will display as below picture to show the subtest is passed or failed when finished: If it is show the picture as below, it means HDD function is OK[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 30 If the picture shows as below, it means he HDD function is NG[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 31 3.19 Front Edge Logo Because this Model have Front Edge Logo, must se t the Front Edge Logo if the unit has this logo, if you select this item, The figure below will be displayed: Please check the units whether have the Front Edg[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 32 Notice: Check logo LED on/off function. 1. If we select “2” to disable the Front Edge logo function by program, there haven’t the item of Front Edge Logo in BIOS Menu, the picture likes below. 2. If we select “1” to ena[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 33 3.20 Fingerprint DOS Test This test will check if the computer’s Fingerprint function is OK. The subtests run step by step: (As below) Step1. Need you swipe your finger to enroll Step2. Need you swipe your finger 2 nd time to e[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 34 Step4. The test program auto compare 1 st , 2nd and 3 rd finger then to enroll. Step5. Need you swipe your finger then test program will verify it. Step6. Verify pass, Step7. Need you select your test result to show “PASS” or[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 35 3 . 21 Clear Fingerprint Test Working Instruction: Run command - " HWTEST 0 19 2 2 -cf " t o clear all information in TBX module The subtests run step by step: (As below) Step1: Step2: Display Notice for clear registere[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 36 Step4: Must to reboot system to make the setting effective. Step5: If you choice “Y”, the system will reboot. If you choice “N”, the system will show Notice again (see be photo). You can press any key to go back test MEMU[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 37 3.22 Write DMI When you want to write DMI data, please select which data you want to write, the figure below will be displayed: 1. Write OME string 2. Write Version 3. Write Serial 4. Write Product[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 38 After write OK, you should reboot the system that can make the setting effective, or you can write next data before reboot system, the figure below will displayed: NOTE : should input correct DMI data, and should reboot the syste[...]

3. Tests and Diagnostics Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual 39 3.23 Read DMI If you want to double check the DMI data, please select Read DMI item, the figure below will be displayed:[...]

[CONFIDE NTIAL] Chapter 4 Replacement Procedures[...]

4[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-i Chapter 4 Contents 4.1 General ....................................................................................................... ............. 4-1 4.2 Battery ....... ....................................................[...]

4 Replacement Procedures Satelli te A210/ A215, Satelli t e Pro A210, EQUIUM A210, SATEGO A210 Series Maint enance Manual 4-ii Figures Figure 4-1 Unlocking the battery lock ............................................................................. 4-7 Figure 4-2 Removing the ba ttery pack ................ ........................................[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-iii Figure 4-3 1 Removing the display assembly................................................................... 4-2 9 Figure 4-3 2 Removing the rubber pads .....................................................................[...]

4 Replacement Procedures Satelli te A210/ A215, Satelli t e Pro A210, EQUIUM A210, SATEGO A210 Series Maint enance Manual 4-iv Figure 4-6 2 Removing the USB board................... .......................................................... 4-53 Figure 4-6 3 Removing the MDC card screws............................... ...............................[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-1 4.1 General This chapter explains how to disassemble th e computer and replace Field Replac eable Units (FRUs). It may not be necessary to remove al l the FRUs in order to replace one. The chart below is a guide to which FRUs[...]

4 Replacement Procedures Satelli te A210/ A215, Satelli t e Pro A210, EQUIUM A210, SATEGO A210 Series Maint enance Manual 4-2 The example below shows FRUs to be rem oved before the CPU can be removed. The CPU is located on the system board. The USB board and the system fan are attached to the system board. The system board itself is located under t[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-3 Safety Preca u tio ns Before you begin disassembly, read the following safety precautions and observe them carefully as you work. DANGER: 1 . Always use the lithium ion battery pack or a backup battery t hat is authorized by [...]

4 Replacement Procedures Satelli te A210/ A215, Satelli t e Pro A210, EQUIUM A210, SATEGO A210 Series Maint enance Manual 4-4 Before You Begin Look over the procedures in this section before you begin disassembling the computer. Familiarize yourself with the disassembl y and reassembly steps. Begin eac h procedure by removing the AC adaptor and the[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-5 Disassembly Procedures The computer has tw o basic types of cable connectors:  Pressure Plat e Connectors  Standard Pin Connectors To disconnect a Pressure Plate connector, lift up the tabs on either side of the connect[...]

4 Replacement Procedures Satelli te A210/ A215, Satelli t e Pro A210, EQUIUM A210, SATEGO A210 Series Maint enance Manual 4-6 Tools and Equipment The use of Electrostatic Discharge (ESD) equipmen t is very important for your safety and the safety of those around you. Proper use of th ese devices will in crease the success rate of your repairs and l[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-7 4.2 Battery Removing the Battery Pack To remove the battery pack from the battery bay, follow these steps: 1. Turn the computer upside down. 2. Unlock the battery compartment loc k. Figure 4-1 Unlocking the battery lock 3. Sl[...]

4 Replacement Procedures Satelli te A210/ A215, Satelli t e Pro A210, EQUIUM A210, SATEGO A210 Series Maint enance Manual 4-8 Instal l i ng the Batt er y Pack To install the battery pack in the battery bay, follow these steps and refer to the figures in the preceding section. WARNING: The battery is a lithium ion battery and can explode if not prop[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-9 4.3 PC Card Removing a PC Card To remove a PC card, follow the steps below: 1. Push the PC card’s eject button. The button pops out when you release it. 2. Push the eject button again to pop the PC card out slightly. 3. Gra[...]

4 Replacement Procedures 4-10 Minnesota 10A/10AG Serie s Mai nte nance Manual Inserting the PC Card To insert a PC card, follow the steps below: 1. Make sure the eject button does not stick out . Push it back into place if required. 2. Insert the PC card in the slot and gent ly press to ensure a firm connection. Figure 4-4 Installing the PC card[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-11 4.4 Memory Card Removing a Memory Card To remove a memory card, follow the steps below: 1. Press the memory card gently in to the socket until it pops out. Figure 4-5 Pr essing th e memory car d 2. Grasp the memory and rem o[...]

4 Replacement Procedures 4-12 Minnesota 10A/10AG Serie s Mai nte nance Manual Inserting the Memory Card To insert a mem ory card, follow the steps below : 1. Insert the memory ca rd in the slot and ge ntly press to ensure a firm connection. Figure 4-7 Installing the memory card[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-13 4.5 HDD CAUTION : When handling the HDD, do not press the top surface. Hold the disk by the sides to prevent damage and loss of data. Figure 4-8 HDD Removing the HDD Modules The Dual HDD feature makes it easy to handle deman[...]

4 Replacement Procedures 4-14 Minnesota 10A/10AG Serie s Mai nte nance Manual 3. Pull up and lift the HDD door to remove it. Figure 4-10 Removing the HDD door 4. Pull out the black Mylar tab to remove the HDD unit. Figure 4-11 Removing the HDD 5. Remove the HDD fr om the HDD case.[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-15 6. Pull the HDD outwards and remove the four M3x3 black screws that secure the HDD case and bracket to the HDD. Figure 4-12 Removing the HDD screws from bracket[...]

4 Replacement Procedures 4-16 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.6 Expansion Memory Removing the Expansion Memory Modules To remove the memory m odule, make sure the computer is in boot mode before rem oving the memory m odule. Remove the battery pack, cabl es and any optional de vices before you start and then follow these steps: 1.[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-17 3. Push the latches to release the memory m odule. A spring will force one end of the module up. Figure 4-15 Releasing the memory module 4. Grasp the module and pull it out. Figure 4-136 Removing the expansion memory module [...]

4 Replacement Procedures 4-18 Minnesota 10A/10AG Serie s Mai nte nance Manual Installing the Expansion Memory Module CAUTION : Do not touch the connectors on the expansion memory module or on the computer. Debris on the connectors may cause memory access problems. Follow these steps to install a memory module: 1. Set the computer to boot mode and t[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-19 4.7 Optical Drive Module Removing the Optical Drive Module To remove the optical drive module, you need to remove the expansion m emory module cover first as described in the previo us section. Follow the steps below: 1. Tur[...]

4 Replacement Procedures 4-20 Minnesota 10A/10AG Serie s Mai nte nance Manual Installing the Opti cal Drive Mod ule To install a device in the optical drive module bay, follow the steps below and refer to the figure in the preceding section. 1. Make sure that the expansion memo ry door is opened and the ODD screw (M2x3, black) is removed. 2. Slide [...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-21 4.8 Optical Drive This computer may be fitt ed with a: DVD-ROM device CD-RW/DVD-ROM combo device DVD Super Multi device Disassembling the O ptical Dr iv e To disassemble the optical drive, first remove the drive from it s mo[...]

4 Replacement Procedures 4-22 Minnesota 10A/10AG Serie s Mai nte nance Manual Reassemb ling the Optica l Drive NOTE : The small arrow shown on the metal bracke t indicates the top side of the optical bracket. Keep this in mind when removing or installing the drive. To reassemble an optical drive, follow the step s below and refer to the figure in t[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-23 4.9 Keyboard Removing the Key board Before removing the keyboard, remove the batt ery and any optional devices. Follow the steps below to remove the keyboard: 1. Open the display panel. 2. Insert a thin tool such as a flat s[...]

4 Replacement Procedures 4-24 Minnesota 10A/10AG Serie s Mai nte nance Manual 4. Remove the two black M2.5x2.5 black screws securing the keyboard. Figure 4-22 Removing the keyboard screws 5. Push the center of the keyboard, press the center tab, and lift the keyboard out, revealing the keyboard cable underneath. Disconnect th e keyboard cable from [...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-25 6. Lift and remove the keyboard. Figure 4-24 Removing the keyboard Installing the Keyboard To install the keyboard, follow the steps below and refer to the figures in the preceding section. 1. Connect the keyboard cable to t[...]

4 Replacement Procedures 4-26 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.10 Display Assembly Removing th e Di splay Assembly To remove the display assembly, first remove the battery and any optional devices. Also remove the keyboard, as described in the prev ious sections. Then follow the steps below: 1. Turn over the laptop. Remove seventee[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-27 3. Disconnect the right and left speaker cables, Bl uetooth cable, FPC cabl e, touch pad cable, function button cable and microphone cable from the system board. Figure 4-27 Disconnecting cables 4. First remove the CM OS cab[...]

4 Replacement Procedures 4-28 Minnesota 10A/10AG Serie s Mai nte nance Manual 5. Disconnect the microphone cable, WLAN cable, and LVDS cable from the system board. Carefully disconnect all cables and pla ce them to the side of the notebook. Figure 4-29 Disc onnecting cables 6. Remove two hexagonal VGA screws from the CRT module on the left side of [...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-29 7. Lift and remove the LCD assembly. Figure 4-31 Removing the display assembly[...]

4 Replacement Procedures 4-30 Minnesota 10A/10AG Serie s Mai nte nance Manual Installing the Di splay A ssembly To install the display assembly, f ollow the steps below and refe r to the figures in the preceding section. 1. Seat the display assembly, taking care not to crush to the LCD display cable, the C MOS cable, the WLAN cables, the Bluetoot h[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-31 4.11 Display Mask Removing the Display Mask To remove the display mask, first rem ove the di splay assembly as described earlier, and then follow the steps below: 1. Remove four rubber pads to reveal the four M2.5x6 screws s[...]

4 Replacement Procedures 4-32 Minnesota 10A/10AG Serie s Mai nte nance Manual Figure 4-33 Removing the display mask screws[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-33 3. Carefully insert your fingers between the disp lay mask and the LCD panel, and pry open the latches. Start with the f our latches at th e top of the display mask. Continue releasing the latches along the two sides and the[...]

4 Replacement Procedures 4-34 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.12 FL Inverter Board Removing the FL In ve rt er Board To remove the FL inverter board, first remove the battery pack, display assembly, and display mask; then foll ow the steps below. 1. Remove the M2x3 black screw securing the FL inverter board to the LCD display asse[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-35 3. Remove the FL inverter board. Figure 4-37 Removing the FL inverter board Installing the F L Inverter Board To install the FL inverter board, follow the steps below and refer to the figure in the preceding section. 1. Plac[...]

4 Replacement Procedures 4-36 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.13 LCD Module Removing the LCD Module To remove the LCD module, first remove th e display assembly, display m ask, and FL inverter board and then follow the steps below. 1. Disconnect all cables from the guides around the edge of the top chassis. Figure 4-38 Removing th[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-37 3. Lift the LCD module from the top chassis. Figure 4-40 Removing the LCD Module 4. Remove six M2x3 screws securing the LCD module bracket to the LCD module. Figure 4-41 Removing the bracket sc rews NOTE : If the LCD module [...]

4 Replacement Procedures 4-38 Minnesota 10A/10AG Serie s Mai nte nance Manual 5. Turn the LCD screen over and rem ove the tape securing the LVDS cable. Disconnect the LVDS cable. Figure 4-42 Removing the LVDS cable Installing the LCD Module To install the LCD module, follow the steps belo w and refer to the figures in the preceding section. 1. Secu[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-39 4.14 WLAN antennas To remove the WLAN antennas, first remove th e display assembly, display mask, FL inverter board and the LCD display module. Then follow the steps below. 1. Remove the three square tabs securing the WLAN a[...]

4 Replacement Procedures 4-40 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.15 Camera and Microphone To remove the camera and microphone, first rem o ve the display assembly, display mask, FL inverter board and the LCD display m odule. Then follow the steps below. 1. Remove the CMOS cable from the camera m odule. Remove the camera module by gen[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-41 Installing the Camera and Microphone To install the camera and microphone, follow the steps below and refer to the figures in the preceding sections. 1. Secure the camera m odule to the adhesive backing at the top of the dis[...]

4 Replacement Procedures 4-42 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.16 Bluetooth module To remove the Bluetooth module, first remove the display asse mbly, keyboard, and top cover. Then follow the steps below: Removing the Bluetooth Module 1. Turn the top cover over. Remove the Bluetooth cable from the Bluetooth module. Figure 4-46 Disc[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-43 Installing the Bluetooth Module To install the Bluetooth module, follow the steps below and refer to the figures in the preceding section. 1. Insert the Bluetooth module into the module holder on the back of the top cover at[...]

4 Replacement Procedures 4-44 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.17 Touch Pad To remove the Touch Pad, first remove the di splay assembly, keyboard, and top cover. Then follow the steps below: Removing the Touch Pad 1. Turn the top cover over. Remove the Touc h Pad cable from the Touch Pad module. Figure 4-48 Removing the touch pad c[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-45 3. Remove the Touch Pad bracket by sliding it away from you and lifting it gently. Figure 4-50 Removing the touch pad bracket 4. Remove the Touch Pad by lifting it gently. Figure 4-51 Removing the touch pad Installing the To[...]

4 Replacement Procedures 4-46 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.18 Fingerpr int Module To remove the Fingerprint module, first re mo ve the display assembly, keyboard, and top cover. Then follow the steps below: Removing the Fingerprint Module 1. Turn the top cover over. Remove four M2.0x2. 5 screws securing the Fingerprint Module B[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-47 3. Remove the Fingerprint module by lifting it gently. Figure 4-54 Removing th e fingerprint module Installing the Fingerprint Module To install the Fingerprint Module, follow the steps below and refer to the figures in the [...]

4 Replacement Procedures 4-48 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.19 Speakers To remove the speakers, first remove the di splay assembly, keyboard, and top cover. Then follow the steps below: Removing th e Spea ke rs 1. Turn the top cover over. Remove three M2. 5x4 screws securing the right speaker to the top cover. Remove three M2.5x[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-49 3. Remove the speakers. Figure 4-57 Removing the speakers Install ing t h e Speak er s To install the speakers, foll ow the steps below an d refer to the figures in the preceding section. 1. Seat the speaker brackets in the [...]

4 Replacement Procedures 4-50 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.20 Function Button Board To remove the function button board, first remove the display assembly, keyboard, and top cover. Then follow the steps below: Removing the Function Button Board 1. Turn the top cover over. Remove three M2.0x2.5 screws securing the function butto[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-51 Installing the Function Button Board To install the function button board, follow the steps below and refer to the figures in the preceding section. 1. Place the function button board into the holder on the rear of the top c[...]

4 Replacement Procedures 4-52 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.21 USB Board To remove the USB board, first remove the disp lay assembly, keyboard, and top cover. Then follow the steps below: Removing t h e US B Board 1. Remove one M2.5x4 screw securing the USB board to the bottom cover. Figure 4-60 Removing the USB board screw 2. R[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-53 3. Remove the USB board. Figure 4-62 Removing the USB board Installing the U SB Board To install the USB board, follow the steps be low and refer to the figures in the preceding section: 1. Place the USB board in position. 2[...]

4 Replacement Procedures 4-54 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.22 MDC Card Removing the MDC Ca rd To remove the MDC card, first remove the di splay assembly, keyboard, and top cover. Then follow the steps below: 1. Remove the two M2.5x2.5 screws securing the MDC card. Figure 4-63 Removi ng the MDC card sc rews 2. Disconnect and rem[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-55 Installing the MD C Card To install the MDC card, f ollow the steps belo w and refer to the figures in the preceding section. 1. Seat the MDC card in the system board. 2. Connect the RJ-11 connector and attach the RJ-11 cabl[...]

4 Replacement Procedures 4-56 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.23 Wireless Module Removing the Wi reless Module To remove the wireless module, first remove the display asse mbly, keyboard, and top cover. Then follow the steps below: 1. Remove the two M2x3 screws securing th e wireless module to the system board. Figure 4-66 Removin[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-57 4.24 System Fan Removing the System Fan To remove the system fan, fi rst remove the display assembly , keyboard, and top cover. Then follow the steps below: 1. Remove the three M2.5x2.5 screws securi ng the system fan to the[...]

4 Replacement Procedures 4-58 Minnesota 10A/10AG Serie s Mai nte nance Manual 3. Remove the system fa n. Figure 4-70 Removing the system fan Instal li ng t h e Syste m Fan To install the system fan, follow the steps below and refer to the figures in the preceding section. 1. Seat the system f an in the chassis. 2. Connect the system fan ca ble to t[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-59 4.25 System Board Removing the Syste m Board To remove the system board, first remove th e display assem bly, keyboard, top cover, MDC card, USB board, wireless module, and syst em fan. Then follow the steps below: 1. Discon[...]

4 Replacement Procedures 4-60 Minnesota 10A/10AG Serie s Mai nte nance Manual 3. Remove one M2.5x4 screw securing the system board to the bottom cover. Figure 4-73 Removing system board screw 4. Remove the system board. Figure 4-74 Removing the system board[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-61 Installing t he System Board To install the system board, follow the steps below and ref er to the figures in the preceding section. 1. Seat the system board in the chassis. 2. Replace one M2.5x4 screw securing the sy stem b[...]

4 Replacement Procedures 4-62 Minnesota 10A/10AG Serie s Mai nte nance Manual 4.26 VGA Board Removing th e VG A Boa r d To remove the VGA board, first remove the display assembly, keyboa rd, top cover, MDC card, USB board, wireless module, syste m fan, and system board. Then follow the steps below: 1. Turn the system board over and remove the four [...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-63 3. Remove the four M2.5x4 screws securi ng the VGA board to the system board. Figure 4-77 Removing the VGA board screw 4. Remove the VGA board. Figure 4-78 Removing the VGA board[...]

4 Replacement Procedures 4-64 Minnesota 10A/10AG Serie s Mai nte nance Manual Instal li ng the VGA Board To install the VGA board, follow the steps be low and ref er to the figure in the preceding section: CAUTION: If you remove the heat sink, use the grea se tool (ex. stain remover) to remove the grease on the VGA board and heat sink. Reappl y fre[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-65 4.27 CPU Removing the Fan & CPU To remove the heat sink, and CPU, first remo ve the display assembly, keyboard, top cover, MDC card, USB board, wireless module, system fan, and VGA board. Then follow the steps below: 1. [...]

4 Replacement Procedures 4-66 Minnesota 10A/10AG Serie s Mai nte nance Manual 3. Turn the cam on the CP U socket with a flat-b lade screwdriver so that the notch on the cam is aligned with the open side of the CPU socket to unlock the CPU Figure 4-81 Turning the CPU cam 4. Gently lift out the CPU. Figure 4-82 Removing the CPU[...]

4 Replacement Procedures Satellit e A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 S eries Mai ntenance Manual 4-67 Installing the C PU To install the CPU, follow the steps be low and refer to the figures in the preceding sec tion. CAUTION: If you remove the heat sink, use the CP U grease tool (ex. stain remover) to remove the grease on t[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual A-1 Appendix A Appendix A Handling the LCD Module Precautions for handling the LCD module The LCD module can be easily damaged during assem bly or disassembly. Observe the following precautions when handling it to prevent damaging it. 1. When installing the[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual A-2 3. If the panel’s surface gets dirty or moist, wipe it with cotton or a soft cloth. If it is still dirty, try breathing on the surface to create a light condensate and wipe it again. If the surface is very dirty, we recommend a CRT cleaning agent. App[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual A-3 5. Glass is used in the panel, so be careful not to drop it or let it strike a hard object, which could cause breakage or cracks. 6. CMOS-LSI circuits are used in the module, so guard against damage from electrostatic discharge. Be sure to wear a wrist [...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual A-4 7. Do not expose the module to direct sunlight or strong ultraviolet rays for long periods. 8. Do not store the module at temperatures below its specifications. Cold can cause the liquid crystals to freeze, lose their elasticity or otherwise suffer dama[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual A-5 10. If you transport the module, do not use packing material that contains epoxy resin (am ine) or silicon glue (alcohol or oxime). These materials can release gas that can dam age the panel’s polarization.[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual B-1 JP3 JP2 JP7 JP6 JP11 JP16 JP15 JP19 JP22 JP20 JP18 JP5 JP5 JP2 JP8 U5 U8 U4 JP14 JP5 JP1 JP17 JP12 Appendix B Appendix B Board Layout B.1 System Board T op V iew Figure B-1 System Board Layout (Top) U11[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual B-2 JP26 JP28 JP30 JP32 JP37 JP34 JP29 JP23 JP24 PJP2 PJP1 JP36 JP24 U24 U26 JP27 U29 U30 JP38 JP39 SW6 SW2 JP35 U23 U25 B.2 System Board Bottom V iew Figure B-2 System Board Layout (Bottom) SW5 JP31 JP33[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual B-3 Table B-1 System Board ICs (top and bottom) Number Name U5 AMD North Bridge RS690MC/ RX690 U26 ATI South Bridge SB600 U24 EC KB926 U23 LAN transformer U4 RTL8101E/ RTL8111B ( Option ) U11 Card bus/1394/5-in1 controller TI PCI8402 U29 HD codec ALC268 U30[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual B-4 Table B-2 System Board Connectors (top and bottom) Number Name JP27 CPU Socket JP8 Fan conn. JP31, JP33 DDRII conn. JP26 TV-Out conn. JP23 VGA/B conn. JP37 1394 conn. JP36 5 in 1 Card Reader conn. JP28 RJ45 conn. JP39 Microphone conn. JP38 Headphone con[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual B-5[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-1 C. Appendix C Pin Assignments System Board C.1 JP31,JP33 Table C-1 SODIMM I/F pin assignments (200-PIN) (1/4) Pin No. Signal name I/O Pin No. Signal Name I/O 1 VREF O 2 VSS O 3 VSS O 4 DQ4 I/O 5 DQ0 I/O 6 DQ5 I/O 7 DQ1 I/O 8 VSS O 9 VSS O 10 DM0 I/O 11 [...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-2 Table C-1 SODIMM I/F pin assignments (200-PIN) (2/4) Pin No. Signal name I/O Pin No. Signal Name I/O 51 DQS2 I/O 52 DM2 I/O 53 VSS O 54 VSS O 55 DQ18 I/O 56 DQ22 I/O 57 DQ19 I/O 58 DQ23 I/O 59 VSS O 60 VSS O 61 DQ24 I/O 62 DQ28 I/O 63 DQ25 I/O 64 DQ29 I[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-3 Table C-1 SODIMM I/F pin assignments (200-PIN) (3/4) Pin No. Signal name I/O Pin No. Signal Name I/O 115 NC/S1# I/O 116 NC/A13 I/O 117 VDD O 118 VDD O 119 NC/ODT1 I/O 120 NC - 121 VSS O 122 VSS O 123 DQ32 I/O 124 DQ36 I/O 125 DQ33 I/O 126 DQ37 I/O 127 VSS O 128 VSS O 129 DQS4# I/O 130 DM4 [...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-4 Table C-1 SODIMM I/F pin assignments (200-PIN) (4/4) Pin No. Signal name I/O Pin No. Signal Name I/O 181 DQ57 I/O 182 DQ61 I/O 183 VSS O 184 VSS O 185 DM7 I/O 186 DQS7# I/O 187 VSS O 188 DQS7 I/O 189 DQ58 I/O 190 VSS O 191 DQ59 I/O 192 DQ62 I/O 193 VSS [...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-5 C.3 JP34 Table C-3 HDD I/F pin assignments (22-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 GND 2 A+ 3 A- 4 GND 5 B- 6 B+ 7 GND 8 VCC3.3 9 VCC3.3 10 VCC3.3 11 GND 12 GND 13 GND 14 VCC5 15 VCC5 16 VCC5 17 GND 18 NC 19 GND 20 NC 21 NC 22 NC C.4 JP29 Table C-4 ODD I/F pin assignment[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-6 23 GND - 24 IDE_DIOR# O 25 IDE_DIOW# O 26 GND O 27 IDE_DIORDY I 28 IDE_DDACK# O 29 IDE_IRQ I 30 NC O 31 IDE_DA1 O 32 +5VS I 33 IDE_DA0 O 34 IDE_DA2 I 35 IDE_DCS1# O 36 IDE_DCS3# - 37 SHDD_LED# I 38 +5VS O 39 +5VS - 40 +5VS - 41 +5VS - 42 +5VS - 43 GND -[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-7 25 PCIE_PTX_C_ IRX_P5 I/O 26 GND - 27 GND - 28 NC - 29 GND - 30 ICH_SMBCLK I/O 31 PCIE_ITX_C_ PRX_N5 I/O 32 SMBDATA I/O 33 PCIE_ITX_C_ PRX_P5 I/O 34 GND - 35 GND - 36 USB20_N2 I/O 37 GND - 38 USB20_P2 I/O 39 +3VS - 40 GND - 41 +3VS - 42 3G_LED - 43 GND - 44 NC - 45 NC - 46 NC - 47 NC - 48 [...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-8 25 PCIE_PTX_C_IRX _P3 O 26 GND - 27 GND - 28 +1.5VS O 29 GND - 30 ICH_SMBCLK I/O 31 PCIE_ITX_C_PRX _N3 I 32 ICH_SMBDAT A I/O 33 PCIE_ITX_C_PRX _P3 I 34 GND - 35 GND - 36 USB20_N3 O 37 NC - 38 USB20_P3 O 39 NC - 40 GND - 41 NC - 42 NC - 43 NC - 44 NC - 4[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-9 19 21 23 25 KSO13 KSO6 KSO5 KSO4 O O O O 20 22 24 26 KSO7 KSO14 KSO3 KSO0 O O O O 27 29 31 33 KSO1 +3VS NC NC O O - - 28 30 32 34 KSO2 NC NC +3VS O - - O C.8 JP8 Table C-8 Fan I/F pin assignments (3-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 +FAN1_VOUT I 2 FANSPEED1 O 3 GND - C[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-10 C.10 PJP1 Table C-10 AC Adaptor Connector pin assignments (4-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 DC_IN_S1 I 2 DC_IN_S2 - 3 GND - 4 GND - C.1 1 JP39 Table C-11 Microphone I/F pin assignments (6-pin) Pin No. Signal name I/O Pin No. Sig[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-11 C.13 JP23 Table C-13 VGA/B Connector pin assignments (200-PIN) (1/4) Pin No. Signal name I/O Pin No. Signal Name I/O 1 B+ O 2 +1.8VS O 3 B+ O 4 +1.8VS O 5 B+ O 6 +1.8VS O 7 B+ O 8 +1.8VS O 9 B+ O 10 +1.8VS O 11 B+ O 12 +1.8VS O 13 B+ O 14 +1.8VS O 15 B+ O 16 +1.8VS O 17 B+ O 18 +1.8VS O 1[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-12 Table C-13 VGA/B Connector pin assignments (200-PIN) (2/4) Pin No. Signal name I/O Pin No. Signal Name I/O 51 PCEI_GTX_C_MRX_P14 I 52 PCIE_MTX_C_GRX_P14 O 53 PCEI_GTX_C_MRX_N14 I 54 PCIE_MTX_C_GRX_N14 O 55 GND - 56 GND - 57 PCEI_GTX_C_MRX_P13 I 58 PCIE[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-13 Table C-13 VGA/B Connector pin assignments (200-PIN) (3/4) Pin No. Signal name I/O Pin No. Signal Name I/O 115 GND - 116 GND - 117 PCEI_GTX_C_MRX_P3 I 118 PCIE_MTX_C_GRX_P3 O 119 PCEI_GTX_C_MRX_N3 I 120 PCIE_MTX_C_GRX_N3 O 121 GND - 122 GND - 123 PCEI_GTX_C_MRX_P2 I 124 PCIE_MTX_C_GRX_P2 [...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-14 Table C-13 VGA/B Connector pin assignments (200-PIN) (4/4) Pin No. Signal name I/O Pin No. Signal Name I/O 181 GND - 182 VGA_TZOUT0+ O 183 +5VALW O 184 GND - 185 +CRT_VCC O 186 VGA_TZOUT1- O 187 +CRT_VCC O 188 VGA_TZOUT1+ O 189 SUSP# I 190 GND - 191 VG[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-15 C.16 JP36 Table C-16 5 in 1 Card Reader Connector pin assignments (44-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 GND - 2 MSBS_SDCMD_SMWE# I/O 3 MSD1_SDD1_SMD1 I/O 4 MSD0_SDD0_SMD0 I/O 5 MSD2_SDD2_SMD2 I/O 6 MS_CD# I/O 7 MSD3_SDD3_SMD3 I/O 8 MSCLK_SDCLK2 I/O 9 +VCC_5IN1 O 10 GN[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-16 C.17 JP20 Table C-17 New Card Connector pin assignments (26-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 GND - 2 USB20_N9 I/O 3 USB20_P9 I/O 4 CP_USB# O 5 NC - 6 NC - 7 ICH_SMBCLK O 8 ICH_SMBDATA I/O 9 +1.5VS_CARD O 10 +1.5VS_CARD O 11 EC_SWI[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-17 C.19 JP15 Table C-19 TP Connector pin assignments (12-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 +5VS O 2 +5VS O 3 TP_DATA I/O 4 TP_CLK O 5 GND - 6 GND - 7 SW_R O 8 NC - 9 NC - 10 NC - 11 NC - 12 SW_L O C.20 JP1 1 Table C-20 Int. Camera Connector pin assignments (5-pin) Pin No[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual C-18 C.22 JP28 Table C-22 RJ45 Connector pin assignments (12-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 RJ45_MIDI0+ I/O 2 RJ45_MIDI0- I/O 3 RJ45_MIDI1+ I/O 4 RJ45_MIDI2+ I/O 5 RJ45_MIDI2- I/O 6 RJ45_MIDI1- I/O 7 RJ45_MIDI3+ I/O 8 RJ45_MIDI3- I/O[...]

Satellite A215 Series Maintenance Manual [CONFIDENTIAL] C-19 C.26 JP22 Table C-26 USB/B Connector pin assignments (12-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 +USB_VCCA O 2 +U SB_VCCA O 3 +USB_VCCA O 4 +U SB_VCCA O 5 USB20_P1 I/O 6 USB20_N1 I/O 7 GND - 8 USB20_P0 I/O 9 USB20_N0 I/O 10 GND - 11 GND - 12 GND - C.27 JP30 Table C-27 USB C[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-1 Appendix D Appendix D Keyboard Scan/Character Codes Table D-1 Scan codes (set 1 and set 2) (1/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 01 ‘ ~ 29 A9 0E F0 0E 02 1 ! 02 82 16 F0 16 03 2 @ 03 83 1E F0 1E 04 3 # 04 84 26 F0 26 05[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-2 Table D-1 Scan codes (set 1 and set 2) (2/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 29 | 2B AB 5D F0 5D *5 30 Caps Lock 3A BA 58 F0 58 31 A 1E 9E 1C F0 1C 32 S 1F 9F 1B F0 1B 33 D 20 A0 23 F0 23 34 F 21 A1 2B F0 2B 35 G 22 A2 [...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-3 Table D-1 Scan codes (set 1 and set 2) (3/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 58 Ctrl(L) 1D 9D 14 F0 14 *3 60 Alt (L) 38 B8 11 F0 11 *3 61 Space 39 B9 29 F0 29 62 ALT (R) E0 38 E0 B8 E0 11 E0 F0 11 64 Ctrl(R) E0 1D E0 9D E[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-4 Table D-1 Scan codes (set 1 and set 2) (4/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 122 F11 57 D7 78 F0 78 *3 123 F12 58 D8 07 F0 07 *3 124 PrintSc *6 *6 *6 *6 *6 126 Pause *7 *7 *7 *7 *7 X Fn — — — — *4 X Win E0 5B E0 D[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-5 Table D-2 Scan codes with left Shift key Code set 1 Code set 2 Cap No. Key top Make Break Make Break 55 / E0 AA E0 35 E0 B5 E0 2A E0 F0 12 E0 4A E0 F0 4A E0 12 75 INS E0 AA E0 52 E0 D2 E0 2A E0 F0 12 E0 70 E0 F0 70 E0 12 76 DEL E0 AA E0 53 E0 D3 E0 2A E[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-6 Table D-3 Scan codes in Numlock mode Code set 1 Code set 2 Cap No. Key top Make Break Make Break 75 INS E0 2A E0 52 E0 D2 E0 AA E0 12 E0 70 E0 F0 70 E0 F0 12 76 DEL E0 2A E0 53 E0 D3 E0 AA E0 12 E0 71 E0 F0 71 E0 F0 12 79 ← E0 2A E0 4B E0 CB E0 AA E0 [...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-7 Table D-5 Scan codes in overlay mode Code set 1 Code set 2 Cap No. Key top Make Break Make Break 09 8 (8) 48 C8 75 F0 75 10 9 (9) 49 C9 7D F0 7D 11 0 (*) 37 B7 7C F0 7C 23 U (4) 4B CB 6B F0 6B 24 I (5) 4C CC 73 F0 73 25 O (6) 4D CD 74 F0 74 26 P (–) 4[...]

Satellite A210/ A215, Satellite Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual D-8 Table D-7 No.126 key scan code Code set 1 Code set 2 Key top Shift Make Make Pause Common E1 1D 45 E1 9D C5 E1 14 77 E1 F0 14 F0 77 Ctrl E0 46 E0 C6 E0 7E E0 F0 7E *: This key generates only make codes.[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 1 Appendix E Key Layout 1. United S tatus (U S) K eyboa rd Figure US keyboard 2. T raditional Chinese (CH) K eyboard Figur e CH keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 2 3. Thai (TI) K eyboard Figur e TI keyboar d 4. K orean ( K O) K eyboard Figur e KO keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 3 5. United Kingd om (UK) K e yboard Figur e UK keyboard 6. US International (UI) K e yboard Figur e UI keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 4 7. Hebrew (HB) K eyboard Figur e HB keyboard 8. Danish (DM) K e yboard Figur e DM keyboar d[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 5 9. Swiss (SW) K eyboard Figur e SW keyboar d 10. Arabic (ARE) K eyboard Figur e ARE keyboar d[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 6 11. Czech (CZ) K eyboard Figur e CZ keyboard 12. Russian (R U) Ke yboard Figur e RU keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 7 13. Portuguese (PO) K eyboard Figur e PO keyboard 14. Slov akian (SL) K eyboard Figur e SL keyboar d[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 8 15. Italian (IT) K eybo ard Figur e IT keyboar d 16. Fr e n c h ( F R ) Ke y b o a r d Figur e FR keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 9 17. German (GR) K eyboard Figur e GR keyboard 18. Greek (GK) K eyboard Figur e GK keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 10 19. Canada F rench (CF) K eyboard Figur e CF keyboar d 20. Hungarian ( HG) K eyboard Figur e HG keyboar d[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 11 21. Spanis h (SP) K eyboard Figur e SP keyboar d 22. Tu r k i s h ( T R ) K e y b o a r d Figur e TR keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 12 3. T urki sh F (T F-F) K eyboard Figur e TF-F keyboar d 24. S wed i sh ( SD ) Ke yb o ar d Figur e SD keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 13 25. Belgian (BE) K e yboard Figur e BE keyboard 26. Y ugoslavian (YU) Ke yboar d Figur e YU keyboar d[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 14 2 7 . Nor wegian (NW) K eyboard Figur e NW keyboar d 28. Scandinavian (ND) K eyboard Figur e ND keyboard[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 15 29. Canadian Multinational (A C) K eyboard Figur e AC keyboard 30. Canadian Bilingual (CB ) K eyboard Figur e CB keyboar d[...]

Satellite A210/ A215, Satell ite Pr o A210, EQUIU M A210, SAT EGO A210 Series Mainte nance Manual 16 3 1 . Japanese (JP) Ke yboard Figur e JP keyboar d[...]

Satellite A210/ A215, Satellit e Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual F-1 F. Appendix F Series Screw Torque List (IALAA) Table F-1 Series Screw To rque List (High-end) SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MAAA00153G0 M2.0*3 6 LCD BRK T O LCD PANEL(R/L) 2.5~3.0 kg LCD BRACKET ASSY (R/L) TO COVER SUB ASSY (LCD [...]

Satellite A210/ A215, Satellit e Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual F-2 Table F-2 Seri es Screw Torque List ( Low-end) SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MAAA00153G0 M2.0*3 3 LOW T O UP 2.5~3.0 kg MAC925025G0 M2.5*2.5 2 KB TO UP 2.5~3.0 kg MA0000061G0 M2.5*4 4 HDD DOOR TO LOW 2.5~3.0 kg MA0000035G0 M2.5D [...]

Satellite A210/ A215, Satellit e Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual F-3[...]

Satellite A210/ A215, Satellit e Pro A210, EQUIUM A210, SATEGO A210 Series Maintenance Manual G-1 Appendix G Appendix G Reliability The followin g table shows M TBF (Mean Tim e Between Failures) for each com ponent. Table G-1 MTBF Component Time (hours) LCD 10,000 Keyboard 60,000 HDD 300,000 Optical (DVD/CD) drive 60,000 AC adaptor 60,000[...]