Quantum 1107 инструкция обслуживания

Owner’s Manual 1-800-800-8586 (Exeter , P A) • 1-888-570-1 1 13 (S t. Catharines, ON) • www .quantumrehab.com[...]

2 www .quantumrehab.com Quantum 1 107 SAFETY GUIDELINES Copyright © 2006 Pride Mobility Products Corp INFMANU2882/Rev B/Feb06 The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information. It is very important for you to read them and understand them completely . WARNING! F ail[...]

Quantum 1 107 www .quantumrehab.com 3 I . INTRODUCTION ..................................................................................................................................... 4 I I . SAFETY ..................................................................................................................................................[...]

4 www .quantumrehab.com Quantum 1 107 I. INTRODUCTION SAFETY WELCOME to Quantum Rehab, a division of Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of-the-art components with safety , comfort, and styling in mind. W e are confident that these design features will provide you with the conveniences you [...]

Quantum 1 107 www .quantumrehab.com 5 I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product's warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed product registration card or by visiting Pride's web site at www .pridemobility .com. As [...]

6 www .quantumrehab.com Quantum 1 107 II. SAFETY Cor rosive chemicals contained in ba tter y . Use only AGM or Gel-Cell batteries to reduce the risk of leakage or explosive conditions. This product has been tested and passed at an immunity level of 20 V/m. R ead and follo w the infor mation in the o wner’s manual. Maximum seating weight. Locked a[...]

Quantum 1 107 www .quantumrehab.com 7 II. SAFETY Do not remove anti-tip wheels. Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Av oid exposure to r ain, sno w , ice, salt, or standing wa ter w hene ver possibl e . Maintain and store in a clean and dr y condition. Rem o v al of g rounding prong can cr ea [...]

8 www .quantumrehab.com Quantum 1 107 II. SAFETY SAFETY MAND A T OR Y! Do not operate your new pow er chair for the first time without completel y reading and understanding this owner’s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to best fi[...]

Quantum 1 107 www .quantumrehab.com 9 II. SAFETY Weight Limitations Y our power chair is rated for a maximum weight capacity . Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity voids y our war ranty and may result in per sonal injur y and/or damage to your power c hair . Pride will not be held responsib[...]

1 0 www .quantumrehab.com Quantum 1 107 II. SAFETY 5 (8.7%) Figure 1. Maximum Safe Slope (Ascending and Descending) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications pre- sented in this manual. Doi[...]

Quantum 1 107 www .quantumrehab.com 1 1 II. SAFETY Figure 2. Correct Curb Approach Figure 3. Incorrect Curb Approach Freewheel Mode Y our power chair is equipped with a manual freewheel system to allow for manual maneuverability by a trained attendant. For more information about how to place your power chair into and out of freewheel mode, see III.[...]

1 2 www .quantumrehab.com Quantum 1 107 II. SAFETY T ransfers T ransferring onto and off of your power chair requires a good sense of balance. Always have an attendant or healthcare professional present while learning to properly transfer yourself. T o eliminate the possibility of injury , Pride recommends that you or a trained attendant perform th[...]

Quantum 1 107 www .quantumrehab.com 1 3 II. SAFETY Elevators Modern elevators have a door edge safety mechanism that, when pushed, reopens the elevator door(s). ! If you are in the doorway of an elevator when the door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contact the power chair and the door will reopen. ![...]

1 4 www .quantumrehab.com Quantum 1 107 II. SAFETY Preventing Unintended Movement WARNING! If y ou anticipate being sea ted in a stationar y position f or an extended period of time, tur n of f the power . This will pr ev ent unexpected motion fr om inadv er tent jo ystic k contact. This will also eliminate the possibility of unintended chair movem[...]

Quantum 1 107 www .quantumrehab.com 1 5 Electromagnetic and Radio Frequency Interference (EMI/RFI) WARNING! Labor a tor y tests have sho wn that electromagnetic and r adio frequenc y waves can have an ad ver se affect on the perf or mance of electrically-powered mobility vehicles. Electromagnetic and Radio Frequency Interference can come from sourc[...]

1 6 www .quantumrehab.com Quantum 1 107 III. Y OUR PO WER CHAIR THE QU ANTUM 1107 The Quantum 1 107 has two main assemblies: the seat assembly and the power base assembly . See figure 5. T ypically , the seat assembly includes the armrests, seatback, and seat base. The power base assembly includes two motor/brake assem- blies, two drive wheels, two[...]

Quantum 1 107 www .quantumrehab.com 1 7 III. Y OUR PO WER CHAIR QUANTUM 1107 S PECIFICA TIONS Suspension: Active-Trac Drive Wheels: 10 in., pneumatic, (10 in., solid are optional) Caster Wheels: 6 in., solid, rear-mounted Anti-tip Wheels: 5 in., solid, front-mounted Maximum S peed:¹ Up to 4.5 mph Brakes: “Intelligent Braking” electronic regene[...]

1 8 www .quantumrehab.com Quantum 1 107 Figure 6. The Quantum 1107 P ower Base SIDE FRAME HANDLES BATTERY BOXES FRONT TRAPEZE BAR MANUAL FREEWHEEL LEVER MOTOR/BRAKE ASSEMBLY CONTROLLER CABLE CONNECTOR III. Y OUR PO WER CHAIR[...]

Quantum 1 107 www .quantumrehab.com 1 9 III. Y OUR PO WER CHAIR Electrical Components The electrical components consist of the controller assembly , the batteries, and the motors. The batteries, motors, and controller power module (if equipped) are located on the power base assembly . See figures 6 and 7. The controller is located on the seat assem[...]

2 0 www .quantumrehab.com Quantum 1 107 Main Circuit Breaker (located on rear battery box): The main circuit breaker is a safety feature built into your power chair . When the batteries and the motors are heavily strained (e.g., from excessive loads), the main circuit breaker trips to prevent damage to the motors and the electronics. If the circuit[...]

Quantum 1 107 www .quantumrehab.com 2 1 Figure 10. Quantum 1107 Assembly Vie w INITIAL ASSEMBL Y Y our power chair may require some assembly either before initial use or after transportation. It may also require disassembly to make some comfort adjustments. Figure 10 details those parts of the power chair that are designed to be disassembled and as[...]

2 2 www .quantumrehab.com Quantum 1 107 Figure 11. Rear Seat Interface Installation (Shown Without Armrests for Clarity) Figure 12. Seat Installation (Shown Without Armrests f or Clarity) Seat Installation The Quantum 1 107 use a seat interface system to attach the seat assembly to the power base assembly . Th is en- ables you to install and remove[...]

Quantum 1 107 www .quantumrehab.com 2 3 Power Base Disassembly The Quantum 1 107 power base disassembles into six parts for easy transportation and storage. See figure 13. T o disassemble the power chair: 1. Turn of f the power to the controller . 2. Disconnect the controller . See figure 6. 3. Remove the seat. 4. Press the foot platform release bu[...]

2 4 www .quantumrehab.com Quantum 1 107 Figure 14. Quantum 1107 Battery Box Removal and Frame Separation BATTERY BOX LATCH (LOCKED) BATTERY BOX LATCH (UNLOCKED) IV . ASSEMBL Y/DISASSEMBL Y CENTER SECTION LATCH[...]

Quantum 1 107 www .quantumrehab.com 2 5 V . COMFORT ADJUSTMENTS COMFORT ADJUSTMENTS After becoming familiar with your power chair ’ s operation, you may find the need to make some adjustments to increase your comfort. These adjustments include seat height and angle, armrest angle, foot platform height and angle, and controller position. If your p[...]

2 6 www .quantumrehab.com Quantum 1 107 Figure 17. Seat Position (Extrusion Location on Contour Seat) V . COMFORT ADJUSTMENTS 10 . Reinstall the seat. 1 1. Reconnect the controller to the power base. Seat Position Y ou can move the seat forward or rearward by changing the extrusion mounting position. T o change the position: 1. T urn off the power [...]

Quantum 1 107 www .quantumrehab.com 2 7 V . COMFORT ADJUSTMENTS T o change the armr est width: 1 . Locate the armrest knob on each side of the armrest receiver bracket. See figure 18. 2 . Loosen each knob. 3. Slide the armrests in or out to the desired width. 4. Tighten each knob. Armrest Angle Adjustment T o change the armrest angle: 1. Lift the a[...]

2 8 www .quantumrehab.com Quantum 1 107 V . COMFORT ADJUSTMENTS 3 . Reinstall the quick release fasteners into the foot platform bracket and tighten. Foot Plat form Depth Adjustment T o adjust the foot platform depth: 1 . Remove the quick release fasteners from the foot platform bracket. See figure 21. 2. Move the foot platform in or out to the des[...]

Quantum 1 107 www .quantumrehab.com 2 9 V . COMFORT ADJUSTMENTS Swing-away Footrests Swing-away Footrests (SFRs) enable you to rotate the footrests to the side before you transfer onto or off of your power chair . T o rotate the SFRs: 1. Push in the release lever . See figure 24. 2. Rotate the SFRs. T o adjust the SFR length: 1 . Remove the two adj[...]

3 0 www .quantumrehab.com Quantum 1 107 V . COMFORT ADJUSTMENTS T o change foot plate tilt (C): 1. Loosen the hardware. 2. Tilt the foot plate to desired position. 3. Tighten the hardware. T o change foot plate angle (D): 1. T urn the setscrew clockwise to decrease the angle. 2. Turn the setscrew counterclockwise to increase the angle. NOTE: Each d[...]

Quantum 1 107 www .quantumrehab.com 3 1 VI. B A TTERIES AND CHARGING BA TTERIES AND CHARGING Y our p ower chair uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep-cycle batteries are designed to handle a longer an[...]

3 2 www .quantumrehab.com Quantum 1 107 VI. BA TTERIES AND CHAR GING T o charge the batteries using the off-board charger: 1. Position your power chair next to a standard elec- trical outlet. 2. Be certain the controller power is turned off. 3. Plug the off-board charger into the off-board charger/programming socket on the controller . See VII. “[...]

Quantum 1 107 www .quantumrehab.com 3 3 VI. B A TTERIES AND CHARGING Can I use a different battery charger? Y ou should use the char ger supplied with the power chair . It is the safest, most efficient tool to char ge the batteries. W e do not recommend using other types of chargers (e.g., an automotive battery charger). NOTE: Y our power chair’ [...]

3 4 www .quantumrehab.com Quantum 1 107 W e work closely with our battery manufacturer to provide a battery that best suits your power chair ’ s specific demands. Fresh batteries arrive regularly at Pride and are promptly shipped with a full charge. During shipping, the batteries encoun- ter temperature extremes that may influence initial perform[...]

Quantum 1 107 www .quantumrehab.com 3 5 VII. OPERA TION Figure 29. FLIGHT Controller 2 3 4 5 1 FLIGHT CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system. The electronic controller enables you to move the power chair , as well as monitor battery charg[...]

3 6 www .quantumrehab.com Quantum 1 107 Figure 30. FLIGHT Controller Keypad VII. OPERA TION BA TTER Y CONDITION METER TOR TOISE KEY ON/OFF KEY SPEED SETTING INDICA T OR HARE KEY HAZARD LIGHT KEY (OPTIONAL) HORN KEY HEADLIGHT KEY (OPTIONAL) LEFT TURN SIGNAL KEY (OPTIONAL) RIGHT TURN SIGNAL KEY (OPTIONAL) ACTU A TOR LIGHTS INDICA T OR LIGHT INDICA T [...]

Quantum 1 107 www .quantumrehab.com 3 7 VII. OPERA TION Horn Key The horn key activates the horn. Speed Keys There are two keys that control the speed. Press the hare key to increase the speed. Press the tortoise key to decrease the speed. The speed setting is displayed on the speed setting indicator . If your power chair was programmed with a driv[...]

3 8 www .quantumrehab.com Quantum 1 107 VSI ELECTRONIC CONTROLLER The electronic controller is what you use to operate your power chair . The electronic controller enables you to move the power chair , as well as monitor battery charge, electronic controller functions, and the condition of your electrical system. The VSI electronic controller is an[...]

Quantum 1 107 www .quantumrehab.com 3 9 VII. OPERA TION On/Off Key The on/off key turns the VSI on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the power c hair . T his will cause the power chair to stop ab ruptly . WARNING! Always tur n the power off wh en you are stationar y to prev ent unexpected [...]

4 0 www .quantumrehab.com Quantum 1 107 Actuator Keys and Actuator Lights (For Optional Equipment) Actuator keys and actuator lights are used for optional equipment such as power elevating leg rests. For specific operation of the actuator keys and actuator lights, contact your Quantum Rehab Specialist. Horn Key The horn key activates the horn. Lock[...]

Quantum 1 107 www .quantumrehab.com 4 1 Thermal Rollback The VSI controller is equipped with a thermal rollback circuit. This circuit monitors the temperature of the controller , which roughly translates to motor temperature. In the event that the VSI controller becomes excessively hot (above 140° F), motor current (amperage) is reduced. For every[...]

4 2 www .quantumrehab.com Quantum 1 107 REMOTE PLUS CONTROLLER The electronic controller is what you use to operate your power chair . The electronic controller enables you to move the power chair , as well as monitor battery charge, electronic controller functions, and the condition of your electrical system. The Remote Plus is part of a modular e[...]

Quantum 1 107 www .quantumrehab.com 4 3 Mode Key (Speed Settings) The mode key controls the speed settings. The Remote Plus speed settings range from 1 to 5. T ypically , the slow- est speed setting is 1 and the fastest speed setting is 5. The settings are indicated by the number of lights that are lit on the speed setting indicator . NOTE: The spe[...]

4 4 www .quantumrehab.com Quantum 1 107 NOTE: When the batteries approach a discharged state, the first red light will begin to slowly flash, remind- ing you the batteries need to be charged immediately! Right/Lef t T urn Indicator Keys (Optional) The right/left turn indicator keys toggle either the left or right turn indicators. Press once to turn[...]

Quantum 1 107 www .quantumrehab.com 4 5 Remote Plus Error Codes In addition to indicating the current state of battery charge, the battery condition meter can also indicate possible problems with your power chair ’ s electrical system. If any of the battery condition meter lights are flashing rapidly , the controller ma y be indicating an error .[...]

4 6 www .quantumrehab.com Quantum 1 107 THE MICRODRIVE CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system. The electronic controller also enables you to monitor battery charge, electronic controller functions, and the condition of your electrical sys[...]

Quantum 1 107 www .quantumrehab.com 4 7 Profile and Speed Indicator The profile and speed indicator is a 5-segment illumi- nated display that indicates speed setting as well as drive profile. Actuator Indicator The actuator indicator is a 4-segment illuminated dis- play that indicates power re cline, power tilt, power leg rest, and power elevating [...]

4 8 www .quantumrehab.com Quantum 1 107 Drive Profile Selection Y our Microdrive controller may be programmed for more than one drive profile that allows the system to be custom tailored to your environment. T o select a profile setting: 1. Use the on/of f switch to power on the chair and the controller . 2. Press the mode button. 3. Move the joyst[...]

Quantum 1 107 www .quantumrehab.com 4 9 FLASHING LIGHTS DIAGNOSIS SOLUTION 10 High Battery V oltage Check batteries. 9 Solenoid Brake Fault Check motor/brake wiring. 8 Possible Controller Fault See Quantum Rehab S pecialist. 7 Possible Joystick Fault See Quantum Rehab S pecialist. 6 Inhibit Active Unplug charger . Check connections. 5 Right Motor W[...]

5 0 www .quantumrehab.com Quantum 1 107 VIII. CARE AND MAINTENANCE CARE AND MAINTENANCE Y our power chair is a sophisticated device. Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from your Quantum Rehab Specialist. Preventive maintenance is very important. If[...]

Quantum 1 107 www .quantumrehab.com 5 1 VIII. CARE AND MAINTENANCE ! The body shroud has been sprayed with a clear sealant coating. Y ou can apply a light coat of car wax to help it retain its high-gloss appearance. ! Check all electrical connections. Make sure they are tight and are not corroded. ! All wheel bearings are prelubricated and sealed. [...]

5 2 www .quantumrehab.com Quantum 1 107 VIII. CARE AND MAINTENANCE WARNING! If you fail to store the unit pr operl y , the frame can r ust and the electr onics can be damaged. Disposal of Y our Power Chair Y our power chair must be disposed of according to applicable local and national statutory regulations. Contact your local waste disposal agency[...]

Quantum 1 107 www .quantumrehab.com 5 3 VIII. CARE AND MAINTENANCE F ollow these easy steps for a quick and safe repair for both pneumatic and solid tires: 1. Turn of f the power to the controller . 2. Set the power chair up on blocks. 3. If you are changing a pneumatic tire, completely deflate it before removing the wheel. 4. Remove the drive whee[...]

5 4 www .quantumrehab.com Quantum 1 107 VIII. CARE AND MAINTENANCE 7. Reconnect the battery harnesses according to the bat- tery wiring diagram label. See figure 40. WARNING! Prev ent injur y . Mak e sur e y ou tighten the fasteners so that the connections are secure. 8. Reinstall the battery boxes onto the power base. Make sure that the battery bo[...]

Quantum 1 107 www .quantumrehab.com 5 5 IX. WARRANTY LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of char ge, any of the following parts found upon examination by an authorized representative of Pride to be defective in material [...]

5 6 www .quantumrehab.com Quantum 1 107 IX. WARRANTY RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EX CL USIONS This warranty does not extend to those items which may require replacement due to normal wear and tear . ! ABS Plastic shrouds ! Motor bru[...]

Quantum 1 107 www .quantumrehab.com 5 7 NO TES[...]

5 8 www .quantumrehab.com Quantum 1 107 NO TES[...]

Quality Control- Model 14 0 0 Thank you for making the Quantum 1107 your choice in power chairs. We have thoroughly inspected your Quantum 1107. The following check marks indicate that it has been tested, driven, and inspected. #1 In Quality Quality Control - Quantum 1 107 Pride keeps a more detailed r eport on file at the factory . Date Inspected [...]