Quadra-Fire SANTAFEI-CE-MBK инструкция обслуживания

R www .quadrare.com October 27, 201 1 CASTILE & SANT A FE PELLET INSERT Owner ’ s Manual Installation and Operation CASTILEI-CE-MBK SANT AFEI-CE-MBK Models: DO NOT DISCARD THIS MANUAL NOTICE • Important operating and maintenance instruc - tionsincluded. • Leave this manual with party responsible f[...]

Page2 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B and Welcome to the Quadra-Fire Family ! Hearth & Home T echnologies welcomes you to our tradition of excellence!InchoosingaQuadra-Fire appliance,youhaveour assurance of commitment to quality , dur[...]

R October 27, 201 1 Page3 Castile & Santa Fe CE Insert 7069-101B T ABLE OF CONTENTS Safety Alert Key: • DANGER! Indicatesahazardoussituationwhich,ifnotavoidedwillresultindeathorseriousinjury . • W ARNING! Indicatesahazardoussituationwhich,ifnotavoidedcouldre[...]

Page4 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B[...]

R October 27, 201 1 Page5 Castile & Santa Fe CE Insert 7069-101B[...]

Page6 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Appliance Certication B. Glass Specications D. Specications This appliance is equipped with 5mm ceramic glass.  Replace glass only with 5mm ceramic glass.  Please contact your dealerforreplacement?[...]

R October 27, 201 1 Page7 Castile & Santa Fe CE Insert 7069-101B HOT SURF ACES! Glassandothersurfacesarehotduringoperation ANDcooldown. Hot glass will cause burns. • Donottouchglassuntilitiscooled • NEVERallowchildrentotouchglass • Keepchildrenaway ?[...]

Page8 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B A. Fire Safety T o provide reasonable re safety , the following should be givenseriousconsideration: • Install at least one smoke detector and CO  monitor on each  oorofyourhome. • Loc[...]

R October 27, 201 1 Page9 Castile & Santa Fe CE Insert 7069-101B D. General Operating Information 1. Thermostat Calls For Heat The appliance is like most modern furnaces; when the thermostat  callsfor heat,your appliancewill automaticallylight anddeliver heat. When the r[...]

Page10 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Fire Characteristics A properly adjusted re with the heat output control button seton“HIGH”hasashort activeamepatternthatextends outoftherepotapproximately102mm. If the[...]

R October 27, 201 1 Page1 1 Castile & Santa Fe CE Insert 7069-101B J. Ignition Cycles 1. At the beginningof eachignition cycle, itis normalto see some smoke in the rebox.  The smoke will stop once therestarts. 2. The convection blower will a[...]

Page12 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 3 Maintaining & Servicing Y our Appliance C. General Maintenance 1. T ypes of Fuel Depending on the type of fuel you are burning will dictate how oftenyouhavetocleanyourrepot. Ifthe fuelyou are?[...]

R October 27, 201 1 Page13 Castile & Santa Fe CE Insert 7069-101B 5. Disposal of Ashes • Frequency:  Asneeded • By: Homeowner Ashes should be placed in a metal container with a tight-tting lid.  The closed container of ashes should be placedon anon-[...]

Page14 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B The amount of ash buildup in the repot will be a good guide to determine how often you should clean the heat exchangers. W ARNING Heatexchangercleaningrodsmaybewarm tothetouch.?[...]

R October 27, 201 1 Page15 Castile & Santa Fe CE Insert 7069-101B 12. Cleaning Combustion Blower - Requires No Lubrication • Frequency: Y earlyorasneeded • By: QualiedServiceT echnician • T ask:  Contact your local dealer  13. Cleaning Convection Blower - Requires No Lubrication • Frequency: [...]

Page16 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B D. High Ash Fuel Content Maintenance • Frequency:  Asneeded • By: Homeowner Correct Flame Size, Y ellow/White in Color Correct Figure 16.3 Ash Build Up in Firebox Pellets Back Up In Feed T ube Firepot Overfills T all, Lazy Flame, Orange in Color Incorrect[...]

R October 27, 201 1 Page17 Castile & Santa Fe CE Insert 7069-101B NOTICE: Odors and vapors are released during initial operation due to the curing of high tem - peraturepaint.Openwindowsforaircirculation.Odorsmaybeirritatingtosensitiveindividuals. 4 T r[...]

Page18 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 5 Getting Started Installer ’ s Guide A . Design, Installation & Location Considerations W ARNING! Risk of Fire Damaged parts could impair safe operation. Do NOT install damaged, incomplete or substitute components. 1. Applian[...]

R October 27, 201 1 Page19 Castile & Santa Fe CE Insert 7069-101B B. Thermostat Location The thermostat’s location will have some effect on the  appliance’soperation. When the thermostat is located close to the appliance, it may  require aslightly highert[...]

Page20 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 6 Dimensions and Clearances A. A ppliance Dimensions Figure 20.3- Front View Figure 20.1 - T op View Figure 20.2 -Side View 819mm 707mm 594mm 203mm 483mm 629mm 249mm 330mm 51mm Overall Size A B MetalSurroundw/CastT rim,STD 1080mm 762mm MetalSurroundw/Cast?[...]

R October 27, 201 1 Page21 Castile & Santa Fe CE Insert 7069-101B Figure 20.4 - T op View A B C D C. Minimum Opening for Masonry and Factory-Built Fireplaces Inches Millimeters A Insertsidetocombustiblesidewall 16 406 B Inserttoptomantel 12 305 C Inserttoptomaximum.2-1/4inch (57mm)facetrim 4[...]

Page22 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Do not terminate vent inanyenclosedorsemi-enclosed areasuchasacarport,garage,attic,crawlspace,undera sundeckorporch,narrowwalkwayorcloselyfencedarea, oranylocationthatcanbuild[...]

R October 27, 201 1 Page23 Castile & Santa Fe CE Insert 7069-101B V ent Congurations T oreduce probability ofreverse drafting duringshut-down conditions Hearth & Home T echnologies strongly recom - mends:  •  Installing the pellet vent with a minimum vertical[...]

Page24 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B E. Chimney and Exhaust Connection 1. Chimney & Connector :Use76mmto102mmdiameter type "L" or "PL" venting system.  It can be vented vertically orhorizontally . 2. Residential:  Use 24 [...]

R October 27, 201 1 Page25 Castile & Santa Fe CE Insert 7069-101B F. P ellet V enting Charts FireRisk. • Only LISTED venting components may be used. • NOOTHER ventcomponentsmaybe used. Substituteordamagedventcomponentsmay impairsafeoperation. W ARNING The maximum?[...]

Page26 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 8 V enting Systems Figure 28.1 CAUTION Neverdrawoutsidecombustionairfrom: • W all,oororceilingcavity • Enclosedspacesuchasanatticorgarage NOTE: •  Illustrationsreecttypicalinstallationsandar[...]

R October 27, 201 1 Page27 Castile & Santa Fe CE Insert 7069-101B B. Full Reline With V ertical Outside Air Figure 29.1 Outside Air T ermination at Chimney T op 12” (305mm) min. below 12” (305mm) min. above NOTE; Use metal plate around exhaust vent pipe and seal all edges with non-flammable insulation such as mineral wool or ceramic. [...]

Page28 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 9 Appliance Set-Up A. Leveling System B. Outside Air Kit Instructions Parts Included in Kit: 1pieceof51mmx914mmex hose,2hoseclamps,1collarassembly ,1terminationcap assembly ,1trimring,fastenersand[...]

R October 27, 201 1 Page29 Castile & Santa Fe CE Insert 7069-101B C. Door Handle Removal 1. Opentheouterdoor . 2. Unlatchandopenthereboxdoor . 3. Continue to turn handle until it is free from the rebox door . D. Door Removal 1. Opentheouterdoor . 2. [...]

Page30 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B Figure 32.2 1 2 3 4 5 6 7 8 F . Hearth Support For Standard Surround Only Figure 33.1 - Assembled View Item Description 1 Front,76mm 2 Front,127mm 3 CastRing,T op&Bottom,Interchangeable 4 Side,127mm 5 Side,76mm 6 PanelExtension,127mm 7 Pane[...]

R October 27, 201 1 Page31 Castile & Santa Fe CE Insert 7069-101B Base Plate Only Installation Parts Needed :(1)castring(2)basezeroclearancepanel extensions.Discardbalanceofparts. T ools Needed: Phillipsheadscrewdriver 1. Attachbasezeroclearancepanelextensionstocast?[...]

Page32 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B H. Surround and Cast T rim Set (CASTILE INSERT) I ncluded in Surround Kit: (2)sidesurrounds,leftand right;(1)surroundtop;(1)fastenerpackage. Included in Cast T rim Kit:  (2)casttrimlegs,leftandright;(1) ca[...]

R October 27, 201 1 Page33 Castile & Santa Fe CE Insert 7069-101B I. Panel and T rim Set (SANT A FE INSERT) 1. Laypanel topand legs facedown onprotective cov - eringtopreventscratching. 1. Attachthe panellegs tothe toppanel usinga Phillips head screwdriver . [...]

Page34 October 27, 201 1 R Castile & Santa Fe CE Insert 7069-101B 1. Opendoortoexposetherebox. 2. Install the left log rst and then the right log. Figure 37.1 3. Lean the logs against the cast iron brick in the back of therebox. 4. Pus[...]

R October 27, 201 1 Page35 Castile & Santa Fe CE Insert 7069-101B 1 . A  12 volt ACthermostat is required to operate this pellet appliance.  Y ou may use the included wall mount thermo - stator purchase an optional programmablethermostat orremotecont[...]

Page36 R Hearth & Home T echnologies 1445 North Highway Colville, W A 991 14 Division of HNI CORPORA TION www .quadrare.com CONT ACT INFORMA TION : Please contact your Quadra-Fire dealer with any questions or concerns. For the number of your nearest Quadra-Fire dealer visit our website at www .quadrare.com This product may be covere[...]