Pride Mobility INFMANU3210 инструкция обслуживания

Silv erStar SIL VER BOOM 300 www .silverstarlif ts.com www .pridemobility .com ™[...]

SAFETY GUIDELINES Copyright © 2007 Pride Mobility Products Corp. INFMANU3210/Rev D/September 2007 The symbols below are used throughout this owner's manual and on the product to identify warnings and important information. It is very important for you to read them and understand them completely . WARNING! Indicates a potentially hazardous con[...]

3 SilverBoom 300 www .silverstarlifts.com CONTENTS I. INTRODUCTION ......................................................................................................................... 4 I I . SAFETY ......................................................................................................................................... 5 III. I[...]

4 SilverBoom 300 www .silverstarlifts.com W elcome to Pride Mobility Products Corporation (Pride). Congratulations on the purchase of your new SilverBoom. The SilverBoom design combines the most advanced state-of-the-art components with modern, attractive styling. W e are certain that the design features and trouble-free operation will add convenie[...]

5 SilverBoom 300 www .silverstarlifts.com II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the lift system to identify warnings, mandatory actions, and prohibited actions. It is very important for you to read and understand them completely . Read and f ollow the infor mation in the owner’ s manual. Pinch/Crush points created during[...]

6 SilverBoom 300 www .silverstarlifts.com Av oid exposure to rain, snow , ice, salt, or standing water whenev er possible. Maintain and store in a clean and dr y condition. Disposal and recyc ling-Contact your authorized Pride Pro vider for inf or mation on pr oper disposal of your Pride product and its packaging. Disposal and recy cling-Contact y [...]

7 SilverBoom 300 www .silverstarlifts.com LIFTING CAP ABILITIES The SilverBoom 300 is designed to lift a maximum weight of 300 lbs. (136 kg). Under no circumstances should the SilverBoom be made to exceed this weight limit. Subjecting the SilverBoom to the strain of lifting more than it is designed to, may cause it to fail, resulting in damage to t[...]

8 SilverBoom 300 www .silverstarlifts.com III. INST ALLA TION The SilverBoom can be installed in either side of your vehicle. The illustrations demonstrate installation on the right side. POWER RO T A TING BASE SHROUD RE- MO V AL Installing a power rotating base requires that the base shroud be removed in order to access the rear mounting holes of [...]

9 SilverBoom 300 www .silverstarlifts.com Figure 4. L-Base (T runk Installation) WHEEL WELL TRUNK INST ALLA TION (SIL VERBOOM 300 MANU AL RO T A TION ONL Y) Position the L-base as shown in figure 3. Y ou may need to situate the L-base so the wheel well does not interfere with the L-base extensions. Ensure there is adequate room for a mobility produ[...]

10 SilverBoom 300 www .silverstarlifts.com III. INST ALLA TION Figure 7. Motor Housing Installation 3 . Lower the motor housing over the upper post until it rests on the height adjustment ring. See figure 7 . WARNING! Pinch Point Hazard! Keep hands clear of the upper post when lowering the motor housing. WARNING! The lift will be top heavy until mo[...]

11 SilverBoom 300 www .silverstarlifts.com BOOM-ARM ADJUSTMENT Before adjusting the boom-arm, lower the lifting hook about 12 in. (30.5 cm). This will provide enough slack in the strap to enable the adjustable portion of the boom- arm (top tube) to be pulled out of the bottom tube to its farthest adjustment hole. See figure 9 . T o adjust the boom-[...]

12 SilverBoom 300 www .silverstarlifts.com III. INST ALLA TION NOTE: Choosing the correct length bolt allows enough bolt-thread to pass through the undercarriage, ensuring enough room for the mounting washer and nut to be installed securely . 6 . From under the vehicle, install the mounting washers and nuts to all five (5) mounting bolts and tighte[...]

13 SilverBoom 300 www .silverstarlifts.com ELECTRICAL WIRING INST ALLA TION 1. Route the lift’ s long power wire (starting at the lift) through the interior of the vehicle until you reach the automobile battery . See figure 13 and 13A . Conceal the wire behind or under the interior panels (there should be existing holes). Be certain that the wire[...]

14 SilverBoom 300 www .silverstarlifts.com III. INST ALLA TION ROUTE RED (+) POWER WIRE TO POSITIVE (+) BATTERY TERMINAL AUTOMOBILE BATTERY MOTOR HOUSING Figure 13. SilverBoom 300 Electrical Wiring Connections FUSE 25-AMP ROUTE BLACK (-) GROUND WIRE TO NEGATIVE (-) BATTERY TERMINAL CRIMP HERE ROUTE RED (+) POWER WIRE TO POSITIVE (+) BATTERY TERMINA[...]

15 SilverBoom 300 www .silverstarlifts.com IV . OPERA TION Figure 14. Hand Control (SilverBoom 300) PRESS TO OPERATE LIFTING STRAP IN A DOWNWARD DIRECTION PRESS TO OPERATE LIFTING STRAP IN AN UPWARD DIRECTION PROHIBITED! Avoid exposure to rain, snow , ice, salt, or standing water whenever possible. Maintain and store in a clean and dr y condition. [...]

16 SilverBoom 300 www .silverstarlifts.com LIFTING THE MOBILITY PRODUCT WARNING! Before operating the SilverBoom for the first time, be absolutely c er tain y ou ha v e the pr oper docking device for your mobility product. 1. Prepare your mobility product for transport. Ensure that the power is off or key is removed and properly secure the batterie[...]

17 SilverBoom 300 www .silverstarlifts.com WARNING! Pinch/Crush Hazard! Always keep hands clear of the lifting strap while the SilverBoom is lifting/ lowering a mobility product. The operator of the lift should stand a safe distance away from the mobility product being lifted/lowered to ensure that feet are never positioned under a raised mobility [...]

18 SilverBoom 300 www .silverstarlifts.com MANU AL LIFT STRAP OPERA TION The SilverBoom 300 with a power rotating base is equipped with a lift strap manual override that serves as backup in the event of a power failure. Using the sup- plied tool, rotate the manual crank located at the front of the boom-arm motor housing clockwise or counterclock- w[...]

19 SilverBoom 300 www .silverstarlifts.com V . TR OUBLESHOO TING LIFT WILL NO T OPERA TE " Check the circuit breaker reset button. Reset if nec- essary . See figures 21 and 22 . " Ensure all harness connections are secure. " Ensure the power wire leading to the positive battery terminal is tight and not corroded. " Check the fus[...]

20 SilverBoom 300 www .silverstarlifts.com LIFTING STRAP TRA VELS IN OPPOSITE DIRECTION OF BUTT ON BEING PUSHED ON HAND CONTROL Before each use, check that the lifting strap is traveling in the proper direction. If the belt travels in the wrong direction when you press either the up or down button, you must restore proper lifting strap travel. T o [...]

21 SilverBoom 300 www .silverstarlifts.com VI. MAINTENANCE SCHEDULE The following routine maintenance should be performed at the indicated intervals. Failure to perform the required maintenance procedures at the required intervals may void Pride’ s product warranty . Perform prior to daily use: " Inspect lift strap wear and replace if necess[...]

22 SilverBoom 300 www .silverstarlifts.com VII. WARRANTY THREE-YEAR TRANSFERABLE LIMITED WARRANTY For three (3) years from the date of purchase, Pride Mobility Products will repair or replace at our option, free of charge, any mechanical or electrical component found upon examination by an authorized representative of Pride to be defective in mater[...]

[...]

*INFMANU3210*[...]