Poulan Pro PP16H36RB инструкция обслуживания

IMPORTANT MANUAL Do Not Throw Away OWNER'S MANUAL MODEL: PP16H36RB LAWN TRACTOR WARNING" Read this Manual and follow all Warnings and Safety Instructions, Failure to do so can result in serious injury. ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 407139 05.18.06 rad Printed in U,S,A,[...]

A SAFETY RULES A Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVETHE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. • Operate machine only in daylight or good artificial IA A WARNING: In order to prevent ac- cidental st[...]

SAFETY RULES & Safe Operation Practices for Ride-On Mowers II1. CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the machine and the mowing activity. Never assume that children will remain where you last saw them, • Keep children out of the mowing area and in the wat[...]

PRODUCT SPECIFICATIONS Gasoline Capacity 2.0 Gallons and type: Unleaded Regular Oil Type (API-SG-SL): SAE 30 (above 32°F) SAE 5W-30 (below 32°F) Oil Capacity: 48 oz. (1.4 L) Spark Plug: Champion RC12YC (Gap: .030") Ground Speed (MPH): Forward: 0-5.5 Reverse: 0-2.4 Charging System: 3 Amps Battery 5 Amps Headlights Battery: AMP/HR: 28 MIN. CCA[...]

UNASSEMBLED PARTS Steering Wheel Steering Wheel Adapter Steering Wheel Insert Steering Boot (1) 5/16 Lock Washer O (1) Large Flat Washer Steering Extension Shaft (1) Hex Bolt 5/16-18 x 4 Seat @ (1) Washer 17/32 x 1-3/16 x 12 Gauge (1 ) Knob Battery (2) Hex Bolts 1/4-20 x 3/4 (2) Keps Nut 1/4-20 For Future Use Key (2) Keys Slope Sheet[...]

ASSEMBLY Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness, TOOLS REQUIRED FOR ASSEMBLY A socket wren[...]

ASSEMBLY • First connect RED battery cable to positive (+) ter- minal with hex bolt and keps nut as shown, Tighten securely. • Connect BLACK grounding cable to negative (-) ter- minal with remaining hex bolt and keps nut. Tighten securely. • Replace battery cover, Open battery cover for: • Inspection for secure connections (to tighten hard-[...]

ASSEMBLY • Sit on seat in operating position, depress clutch/brake pedal and set the parking brake, • Place motion control lever in neutral (N) position, • Press lift lever plunger and raise attachment lift lever to its highest position, • Remove key from bag and start the engine (see "TO START ENGINE" in the Operation section of [...]

ASSEMBLY SPREADER BARS RETAINER SPRING VINYL BINDING RETAINER SPRING FIG. 5B • Push cap over end of bagger dump handle. NOTE: For futu re use, the clevis pin may be removed in order to use the handle to clear the chute in the event it has become clogged. DUMP HANDLE TUBE CLEVIS PIN 10 X 44MM RETAINER SPRING CAP Install and carefully lower bag[...]

ASSEMBLY CHECK TIRE PRESSURE The tires on your tractor were overinflated at the factory for shipping purposes. Correct tire pressure is important for best cutting performance, • Reduce tire pressure to PSI shown on tires, CHECK DECK LEVELNESS For best cutting results, mower housing should be properly leveled, See "TO LEVEL MOWER HOUSING"[...]

OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean- ing, R N I'-,I FAST REVERSE NEUTRAL HIGH LOW CHOKE SLOW IGNITION SWITCH G G o, I 6 ENGINE OFF REVERSE ENGINE ON ENGINE START PARKING BRAKE PARKING BRAKE PARKING BRAKE OPERATION LOCKED UNLOCKED SYSTEM (ROS) OVER TEMP F[...]

OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments, Save this manual for future reference, SERVICE REMINDER/ LIGHT SWITCH CLUTCH/BRAKE PEDAL ATTACHMENT IGNITION CLUTCH LEVER[...]

OPERATION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your trac- tor or performing any adjustments or repairs. We recommend a wide vision safety mask over spectacles or standard safety glasses. HOW TO USE YOUR TRACTO[...]

OPERATION • Adjust mower to desired cutting height (See "TO AD- JUST MOWER CUTTING HEIGHT" in the Operation section of this manual), With mower in desired height of cut position, gauge wheels should be assembled so they are slightly off the ground. Install gauge wheel in appropriate hole with shoulder bolt, 3/8 washer, and 3/8-16 Iocknu[...]

OPERATION • Do not push or tow tractor at more than two (2) MPH. • To reengage transmission, reverse above procedure. NOTE: To protect hood from damage when transporting your tractor on a truck or a trailer, be sure hood is closed and secured to tractor. Use an appropriate means of tying hood to tractor (rope, cord, etc.). Transmission Engaged [...]

OPERATION • Place the motion control lever in neutral, Release the parking brake and let the clutch/brake slowly return to operating position, • Allow one minute for transmission to warm up, This can be done during the engine warm up period. • The attachmentscan also be used during the engine warm- up period after the transmission has been wa[...]

OPERATION TO DUMP BAGGER (See Fig.16) Your tractor is equipped with a Dump Bag Alarm. To turn off the alarm disengage the attachment clutch switch. • Position tractor in location you wish to dump bagger. • Place motion control lever in Neutral position and set parking brake. • Raise dump handle to its highest position. Pull handle forward to [...]

MAINTENANCE MAINTENANCE SCHEDULE Check Brake Operation Check Tire Pressure T Check Operator Presence & ROS Systems _ Check for Loose Fasteners ChecWReplace Mower Blades _ Lubrication Chart Check Battery Level R Clean Battery and Terminals Check Transaxle Cooling Check Mower Levelness Check V-Belts Check Enqine Oil Level Change Engine Oil (with [...]

MAINTENANCE TRACTOR Always observe safety rules when performing any main- tenance, BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in highest gear on a level, dry concrete or paved surface, then brake must be checked and adjusted. (See "TO ADJUST BRAKE" in the Service and Adjustments section of this ma[...]

MAINTENANCE FLAT i WASHER BLADE BOLT LEFT HAND THREADED% LOCK WASHER ASSEMBLY 6 STAR PATTERN 6 STAR CENTER HOLE TRAILING " _ EDGE FIG. 21 BATTERY You rtractor has a battery charging system which is sufficient for normal use. However, periodic charging of the battery with an automotive charger will extend its life, • Keep battery and terminal[...]

MAINTENANCE • Unlock drain valve by pushing inward and turning counterclockwise, • To open, pull out on the drain valve, • After oil has drained completely, close and lock the drain valve by pushing inward and turning clockwise until the pin is in the locked position as shown, • Remove the drain tube and replace the cap onto to the bottom f[...]

SERVICE AND ADJUSTMENTS WARNING: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: • Depress clutch/brake pedal fully and set parking brake. • Place motion control lever in neutral (N) position. • Place attachment clutch in "DISENGAGED" position. • Turn ignition key to "STOP" and remove key. • Ma[...]

SERVICE AND ADJUSTMENTS BOTTOM EDGE .... _ _ BOTTOM EDGE I OFMOWER / /!_// _ OFMOWER TOGROUND,, I _-__i_! / TOGROUND /7-- ..... ] I"A" FIG. 25 NOTE: Three full turns of adjustment nut will change mower height about 1/8". • Recheck measurements after adjusting. LIFT LINK ADJUSTM_ FIG. 26 FRONT-TO-BACK ADJUSTMENT (See Figs. 27 and 28[...]

SERVICE AND ADJUSTMENTS The rear wheels must lock and skid when you try to manually push the tractor forward, If the rear wheels rotate, the brake needs to be adjusted or the pads need to be replaced. TO ADJUST BRAKE • Depress clutch/brake pedal all the way down and en- gage parking brake. • Measure distance between brake operating arm and nut [...]

SERVICE AND ADJUSTMENTS TO ADJUST STEERING WHEEL ALIGNMENT If steering wheel crossbars are not horizontal (left to right) when wheels are positioned straightforward, remove steer- ing wheel and reassemble per instructions in the Assembly section of this manual, FRONT WHEEL TOE-IN/CAMBER The front wheel toe-in and camber are not adjustable on your t[...]

STORAGE ENGINE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more, & WARNING: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark. Allow the engine to cool before storing in any enclosure. TRACTOR Remove mower f[...]

TROUBLESHOOTING POINTS CAUSE CORRECTION PROBLEM Will not start Hard to start Engine will not turn over Engine clicks but will not start Loss of power Excessive vibration 1. Out of fuel. 2. Engine not "CHOKED" properly. 3. Engine flooded. 4. Bad spark plug. 5. Dirty air filter. 6. Dirty fuel filter. 7. Water in fuel. 8. Loose or damaged wi[...]

TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Engine continues to run when operator leaves seat with attachment clutch engaged Poor cut - uneven Mower blades will not rotate Poor grass discharge Headlight(s) not working (if so equipped) Battery will not charge Loss of drive Engine "backfires" when turning engine "OFF" Mower wi[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 SCHEMATIC 03087_197434 01-57 IGNITION SWITCH POSITION CIRCUIT "MAKE" OFF M+G+A1 RUN/OVERRIDE B+A1 RUN B+A1 L+A2 START B + S + A1 AMMETER t_ (OPTIONAL) _I_S _E _ RED NGAGED) WHITE I I 1 iC G I I I i H (PEDAL UP) J I D i ...... i WIRING INSULATED CLIPS NOTE: IF WI[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 ELECTRICAL : 25 / / / / 27 22 26 i/ f/ 40 f 94 16 // 48 66 --_= .-::" 4_3_2_6__ ............................ 30 59 93 16[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 ELECTRICAL KEY PART NO. NO. DESCRIPTION 1 532 16 34-65 2 874 76 04-12 16 532 17 61-38 21 532 18 37-59 22 532 00 41-52 24 532 12 47-80 25 532 16 59-87 26 532 17 51-58 27 873 51 04-00 28 532 12 77-25 29 532 19 27-49 30 532 19 33-50 33 532 14 04-01 34 532 11 07-12 40 532[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 CHASSIS AND ENCLOSURES 259 /258 261 189 188 188 187 164 > 24 33 10 209 209 209 24 163 209 24 89 30 35 205 209 34 39 278 Chassis Elite Pro CRD 1 32[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 CHASSIS AND ENCLOSURES KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. 1 532 17 46-20 Chassis 164 532 16 2 532 18 03-84 Drawbar 165 532 18 3 8170606-12 Screw 3/8-16x3/4 170 5321994-88 5 532 15 52-72 Bumper Hood/Dash 171 872 14 06-20 6 532 18 44-19 Saddle 172 819 13 20-1[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 DRIVE 199 / 169 171 1671 10 J 264 171 263 73 252 27 252 drive-hydro CRD Laser 19 200 71 263 34[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 DRIVE KEY PART NO. NO. 1 8 532 19 27-06 9 532 18 03-54 10 876 02 04-16 14 810 04 04-00 15 874 49 05-44 16 873 80 05-00 19 873 80 06-00 21 532 12 66-39 22 532 17 56-07 24 873 35 06-00 25 532 19 20-36 26 819 13 13-16 27 876 02 04-12 28 532 17 57-65 29 532 07 16-73 30 53[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 STEERING ASSEMBLY --97 -_2J_ 39 _42 88 29 68 15 15 15_ steering_pl.lt 60 68 67 67 3 95 36[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 STEERING ASSEMBLY KEY PART NO. NO. 1 532 19 45-95 2 532 18 47-06 3 532 16 98-40 4 532 16 98-39 5 532 12 49-31 6 532 12 17-48 8 812 00 00-29 10 532 17 51-21 11 810 04 06-00 13 532 13 65-18 15 532 14 52-12 17 532 19 07-53 29 8170006-12 32 532 17 01-62 33 819 11 12-16 34[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 SEAT ASSEMBLY r 17 12 seat It.knob 11(CRD) 25 8 KEY NO. 1 2 3 4 5 6 7 8 9 10 11 12 PART NO. 532 18 87-12 532 14 05-51 871 11 06-16 819 13 16-10 532 14 50-06 873 80 06-00 532 12 41-81 817 00 06-16 819 13 16-14 532 19 55-30 532 16 63-69 532 17 46-48 DESCRIPTION Seat Bra[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 DECALS 01-57 6 14 16 21 17 13 11 KEY PART NO. NO. 1 532 40 03-89 2 532 18 96-83 3 532 18 61-63 4 532 19 68-41 5 532 18 61-64 6 532 16 88-69 7 532 17 27-43 8 532 40 36-21 10 532 14 50-05 11 532 18 21-66 12 532 15 97-37 13 532 16 69-60 16 1 20 10 DESCRIPTION KEY PART NO. NO. [...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 ENGINE 3 72 / 62 81 13 4 31 33 78 44 37 33 29 OPTIONAL EQUIPMENT Spark Arrester 38 23 78 engine-bs.lcyl 48 40[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 ENGINE KEY PART NO. NO. DESCRIPTION 1 2 3 532 17 05-51 817 72 04-08 4 532 13 73-52 13 532 16 52-91 14 532 14 84-56 23 532 16 98-37 29 532 13 71-80 31 532 18 55-34 32 532 19 77-25 33 532 12 34-87 37 532 13 70-40 38 532 18 16-54 44 817 67 04-12 45 8170006-12 46 819 09 1[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 MOWER 44 46 124_ 130 131 " _41 i _36 2_ 26 13 33 30 36 ( 18 i i I 118 21 35 119 117 116 46 I " 45 16 ,/ 36(92cm) deck-elect.(CRD) 42[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 MOWER KEY PART NO. NO. 1 532 40 01-08 2 872 14 05-06 3 532 16 55-69 4 532 16 55-58 5 532 12 46-70 6 532 16 55-57 8 532 18 17-12 9 810 03 06-00 11 532 18 63-85 13 532 13 76-45 14 532 12 87-74 15 532 11 04-85 16 532 18 63-86 17 873 68 06-00 18 872 11 06-06 19 532 13 28-[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 MOWER LIFT 13 5 4 6 12 3 2 / I I I ] I / ' I' 6 5 13 19 31 32 KEY PART NO. NO. 1 532 19 84-17 2 532 19 80-70 3 532 18 88-22 4 812 00 00-02 5 819 21 16-21 6 532 12 01-83 7 532 10 94-13 8 532 12 43-85 11 532 16 58-29 12 532 16 58-31 32 19 DESCRIPTION Washer [...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 BAGGER 34 15 / ? 33 01-57 17 9 _- _,_12 7 53 51 52 Bagger Asy (CRD) 12 45[...]

REPAIR PARTS TRACTOR--MODEL NO. PP16H36RB (96061015701), PRODUCT NO. 960 61 01-57 BAGGER KEY PART NO. NO. 1 532 16 52-49 3 532 12 39-76 4 532 16 99-16 5 874 98 10-24 6 874 98 10-32 7 873 40 10-00 8 532 18 25-14 9 872 14 04-18 10 532 18 12-82 11 532 16 57-19 12 532 18 88-48 14 874 52 06-36 15 532 12 46-70 16 873 90 06-00 17 872 14 05-06 19 873 90 05[...]

SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL 15 DEGREES MAX. _ ARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mow slopes greater than 15 degrees. Make turns gradually to prevent tipping or loss of control. Exercise extreme caut[...]

PARTS AND SERVICE This product has been expertly engineered and carefully manufactured to rigid quality standards. As with all mechanical products, some adjustments or part replacement may be necessary during the life of your unit, For Parts and service, contact an authorized distributor. • For replacement parts, have available the following info[...]