Русский dropdown-ico

Nortec NH Series инструкция обслуживания

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92

Идти на страницу of

Похожие руководства по эксплуатации

Хорошее руководство по эксплуатации

Законодательство обязывает продавца передать покупателю, вместе с товаром, руководство по эксплуатации Nortec NH Series. Отсутствие инструкции либо неправильная информация, переданная потребителю, составляют основание для рекламации в связи с несоответствием устройства с договором. В законодательстве допускается предоставлении руководства в другой, чем бумажная форме, что, в последнее время, часто используется, предоставляя графическую или электронную форму инструкции Nortec NH Series или обучающее видео для пользователей. Условием остается четкая и понятная форма.

Что такое руководство?

Слово происходит от латинского "instructio", тоесть привести в порядок. Следовательно в инструкции Nortec NH Series можно найти описание этапов поведения. Цель инструкции заключается в облегчении запуска, использования оборудования либо выполнения определенной деятельности. Инструкция является набором информации о предмете/услуге, подсказкой.

К сожалению немного пользователей находит время для чтения инструкций Nortec NH Series, и хорошая инструкция позволяет не только узнать ряд дополнительных функций приобретенного устройства, но и позволяет избежать возникновения большинства поломок.

Из чего должно состоять идеальное руководство по эксплуатации?

Прежде всего в инструкции Nortec NH Series должна находится:
- информация относительно технических данных устройства Nortec NH Series
- название производителя и год производства оборудования Nortec NH Series
- правила обслуживания, настройки и ухода за оборудованием Nortec NH Series
- знаки безопасности и сертификаты, подтверждающие соответствие стандартам

Почему мы не читаем инструкций?

Как правило из-за нехватки времени и уверенности в отдельных функциональностях приобретенных устройств. К сожалению само подсоединение и запуск Nortec NH Series это слишком мало. Инструкция заключает ряд отдельных указаний, касающихся функциональности, принципов безопасности, способов ухода (даже то, какие средства стоит использовать), возможных поломок Nortec NH Series и способов решения проблем, возникающих во время использования. И наконец то, в инструкции можно найти адресные данные сайта Nortec, в случае отсутствия эффективности предлагаемых решений. Сейчас очень большой популярностью пользуются инструкции в форме интересных анимаций или видео материалов, которое лучше, чем брошюра воспринимаются пользователем. Такой вид инструкции позволяет пользователю просмотреть весь фильм, не пропуская спецификацию и сложные технические описания Nortec NH Series, как это часто бывает в случае бумажной версии.

Почему стоит читать инструкции?

Прежде всего здесь мы найдем ответы касательно конструкции, возможностей устройства Nortec NH Series, использования отдельных аксессуаров и ряд информации, позволяющей вполне использовать все функции и упрощения.

После удачной покупки оборудования/устройства стоит посвятить несколько минут для ознакомления с каждой частью инструкции Nortec NH Series. Сейчас их старательно готовят или переводят, чтобы они были не только понятными для пользователя, но и чтобы выполняли свою основную информационно-поддерживающую функцию.

Содержание руководства

  • Страница 1

    2522381-C NH Series NHTC / NHPC ELECTRODE STEAM HUMIDIFIER Inst allation Manual TM[...]

  • Страница 2

    2008-08-28 PROPRIETARY NOTICE This document and the info rmation disc losed herein are propriet ary data of W AL TER MEIER L TD. Neither this documen t nor the information cont ained herein shall be reproduced used, or disclosed to others without th e written authorization of W AL TER MEIER L TD., except to the extent required for installation or m[...]

  • Страница 3

    2008-08-28 TABLE OF CONTENTS Subject Page 10-00 I NTRODUCTI ON 1. PREINSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 A. RECEIVING & UNPACKING EQUIP MENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [...]

  • Страница 4

    2008-08-28 E. HOW TO REMOVE THE STEAM CYLINDER . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 F. MANDATORY CLEANING OF THE DRAIN VA LVE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53 G. HOW TO INSTALL THE REPLACEMENT CYLINDER . . . . . . . . . . . . . . . . . . . . . . [...]

  • Страница 5

    2008-08-28 LIST OF FIGURES Figure Page 10-00 I NTRODUCTI ON Figure 1. NHTC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 Figure 2. Humidifier Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [...]

  • Страница 6

    2008-08-28 LIST OF TABLES Ta b l e Page 10-10 INSTALL ATION PR OCEDURE Table 1. Maximum Recommended Length of Steam Runs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Table 2. Steam Line Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .[...]

  • Страница 7

    2008-08-28[...]

  • Страница 8

    10-00 Page 1 2008-08-28 10-00 INTRODUCTION[...]

  • Страница 9

    10-00 Page 2 2008-08-28 Figure 1. NHTC[...]

  • Страница 10

    10-00 Page 3 2008-08-28 1. PRE-INSTALLATION A. RECEIVING & UNPACKING EQUIP MENT (1) Check packing slip to ensure ALL material has been delivered. (2) All material shortages are to be reported to NORTEC within 48 hours from receipt of goods. NORTEC assumes no responsibility for any material shortages beyond this period. (3) Inspect shipping boxe[...]

  • Страница 11

    10-00 Page 4 2008-08-28 H096 BOX WITH ABBREVIA TED INSTRUCTIONS AND BOX CONTENT STICKERS CONTROLS (IF ORDERED ONL Y) BAG WITH MANUAL, CLAMPS, HOSE SECTION HUMIDIFIER STEAM HOSE SECTION (NOT SUPPLIED IF BUIL T ON BLOWER P ACK ORDERED) Figure 2. Humidifier Box Figure 3. Distributor Box Figure 4. SAM-e Distributor Box Figure 5. Remote Mounted Blo wer [...]

  • Страница 12

    10-00 Page 5 2008-08-28 3. PREINSTALLATION EQ UIPMENT VERIFICATION A. GENERAL (1) Ensure that available voltage and phase corresponds with humidifier voltage and phase as indicated on humidifier’s specification label. (2) Ensure that the dedicated external fuse disconnect is of sufficient size to handle the rated amps as indicated on the specific[...]

  • Страница 13

    10-00 Page 6 2008-08-28 Figure 6. Typical NHTC Installation (Sheet 1 of 2)[...]

  • Страница 14

    10-00 Page 7 2008-08-28 Figure 7. Typical NHTC Installation (Sheet 2 of 2)[...]

  • Страница 15

    10-00 Page 8 2008-08-28 THIS PAGE INTENTIONALLY LEFT BLANK[...]

  • Страница 16

    10-10 Page 9 2008-08-28 10-10 INSTALLATION[...]

  • Страница 17

    10-10 Page 10 2008-08-28 1. HUMIDIFIER INSTALLATION A. LOCATION (1) The NORTEC NHTC series humidifier is designed to mount on a suitable wall or vertical surface. Do not sit the unit on the floor due to clearances require d for plumbing and electrical connections. The clearance dimensions shown in this manual are for reference only and are the mini[...]

  • Страница 18

    10-10 Page 11 2008-08-28 D. WATER SUPPLY LINE (4) All water supply and drain line connections should be insta lled in accordance with local plumbing codes. (5) For installation details see Figure 5 & 6. E. DRAIN LINE CAUTION DRAIN WATER FROM HUMI DIFIER CAN BE VERY HOT. (1) The drain line should not end in a sink used frequently by personnel, o[...]

  • Страница 19

    10-10 Page 12 2008-08-28 Figure 1. Clearances and Operating Conditio ns Figure 2. Mounting with Keyholes Figure 3. Mounting with Mounting Bracket[...]

  • Страница 20

    10-10 Page 13 2008-08-28 Figure 4. Drain Water and Supply Connec tion[...]

  • Страница 21

    10-10 Page 14 2008-08-28 Table 1. Maximum Recommended Length of Steam Line Unit Size Steam Output Distance Possible Loss Steam Line Size NH-005 5 lbs/hr 8 f eet 1.0 lbs/hr 3/4 NH-010 10 lbs/hr 15 f eet 1.5 lbs/hr 3/4 NH-020 20 lbs/hr 20 feet * 2.0 lbs/hr 3/4 NH-030 30 lbs/hr 25 feet * 2.5 lbs/hr 3/4 NH-050 50 lbs/hr 40 feet ** 4.0 lbs/hr 1 ½” NH[...]

  • Страница 22

    10-10 Page 15 2008-08-28 Figure 5. Steam Run and Condensate Return Installation Guidelines (Sheet 1 of 2)[...]

  • Страница 23

    10-10 Page 16 2008-08-28 Figure 6. Steam Run and Condensate Return Installation Guidelines (Sheet 1 of 2)[...]

  • Страница 24

    10-10 Page 17 2008-08-28 Table 4. Recommended Condens ate Line at Distributor(s) Dispersion Method Condensate Hose Copper Tube (Pota ble) Stainless Steel Tube (RO or DI) 1 x Steam Distributor 0.375 inch NORTEC 132-8840 0.250 inch. MED-L Tubing (0.375 inch OD) 0.375 Tube 0.049 inch thick 3 x Steam Distributor 0.375 inch NORTEC 132-8840 0.500 inch. M[...]

  • Страница 25

    10-10 Page 18 2008-08-28 Figure 7. Primary Voltage Supply Wiring[...]

  • Страница 26

    10-10 Page 19 2008-08-28 G. ELECTRICAL (1) Primary Voltage Supply Wiring to Humidifier (a) Local electrical codes should always be followed when installi ng a NORTEC Humidifier. Direct wiring to the high voltage terminal is shown in Figure 7. H. CONTROL WIRING (1) Controls are available from NORTEC as accessories. If controls were not ordered with [...]

  • Страница 27

    10-10 Page 20 2008-08-28 Figure 8. On/Off Control Guidelines and Low Voltage Terminal Strip[...]

  • Страница 28

    10-10 Page 21 2008-08-28 Figure 9. NORTEC Control Guidelines and Wiring (Optional)[...]

  • Страница 29

    10-10 Page 22 2008-08-28 I. OPTIONAL OUTDOOR TEMPERAT URE RESE T FUNCTION NOTE Order outdoor temperature sensor separately, Part #252-0263. (1) Each humidistat and controller is equipped with an integrated reset functio n that will limit the setpoint during cold weather operation. This will prevent condensation on windows and building structures. F[...]

  • Страница 30

    10-10 Page 23 2008-08-28 J. HUMIDITY TRANSDUCER SI GNAL INSTALL ATION (1) Figure 11 displays the NORTEC optional humidity transducer installation. K. NETWORKING NHTC (1) The wiring of master/slave networks are explained in Figure 12. It allows operation of multiple NHTCs with one control signal. L. NORTEC ONLINE INSTALLATION (1) An abbreviated reco[...]

  • Страница 31

    10-10 Page 24 2008-08-28 Figure 11. NORTEC Humidity Transducer Guideli nes and Wiring (Optional)[...]

  • Страница 32

    10-10 Page 25 2008-08-28 Figure 12. Networking NHTCs (Optional)[...]

  • Страница 33

    10-10 Page 26 2008-08-28 Figure 13. NORTEC OnLine Inst allation Guidelines (Optional)[...]

  • Страница 34

    10-20 Page 27 2008-08-28 10-20 OPERATION[...]

  • Страница 35

    10-20 Page 28 2008-08-28 1. NHTC A. NHTC COMPONEN TS (1) Refer to Figures 1 and 2 when reading Table 1. B. HUMIDIFIER START-UP (1) Figure 3 describes the method for powering up a humidifier and the cautions t o take. C. BASIC STEAM PRODUC TION METHOD (1) Figure 6 describes the method the NH Series humidifier uses to produce pure clean steam. The NO[...]

  • Страница 36

    10-20 Page 29 2008-08-28 Table 1. NHTC/NHPC Components Item Number Component Name Description 1 Steam Connector Used to allow easy repla c ement of cylinders without disconnecting the steam line. 2 Con densate Return This inlet is to return condensate to the unit. 3 Fill Cup The fill cup allows isolation from th e fill line by supplying an air ga p[...]

  • Страница 37

    10-20 Page 30 2008-08-28 Table 1. NHTC/NHPC Components (cont) Item Number Component Name Description 17 Cylinder Plug Cylinder plugs are press fit on cylinder electrode p ins. These color coded connections sh ould fit snuggly , on same color pins. Re place if loose or frayed. 18 Low V olt age T erminal S trip The low voltage terminal strip is the l[...]

  • Страница 38

    10-20 Page 31 2008-08-28 Figure 3. Humidifier Start-Up Figure 5. Capacity Setting and Cylinder Life Figure 4. Drain Rate Versus Water Conductivity[...]

  • Страница 39

    10-20 Page 32 2008-08-28 Figure 6. Basic Steam Production Me thod[...]

  • Страница 40

    10-20 Page 33 2008-08-28 E. SOFTWARE INITIAL SELF-TEST Table 2. Self-Test Messages F. SOFTWARE FLOW CHART WITH DEFINITIONS (1) The flow chart in Figure 7 depicts the so ftware logic and definitions. G. SELF-HELP (1) The microcomputer applies corrective a ction s wh enever its self-diagnostics iden tifies a problem that it is able to co rrect by its[...]

  • Страница 41

    10-20 Page 34 2008-08-28 Figure 7. Software Flow Chart (Sheet 1 of 7 )[...]

  • Страница 42

    10-20 Page 35 2008-08-28 Figure 7. Software Flow Chart (She et 2 of 7)[...]

  • Страница 43

    10-20 Page 36 2008-08-28 Figure 7. Software Flow Chart (Sheet 3 of 7 )[...]

  • Страница 44

    10-20 Page 37 2008-08-28 Figure 7. Software Flow Chart (She et 4 of 7)[...]

  • Страница 45

    10-20 Page 38 2008-08-28 Figure 7. Software Flow Chart (Sheet 5 of 7 )[...]

  • Страница 46

    10-20 Page 39 2008-08-28 Figure 7. Software Flow Chart (She et 6 of 7)[...]

  • Страница 47

    10-20 Page 40 2008-08-28 Figure 7. Software Flow Chart (Sheet 7 of 7 )[...]

  • Страница 48

    10-20 Page 41 2008-08-28 H. SYSTEM MESSAGES AND LIGHTS (1) Table 3 describes general signal light status meanings. Table 3. Signal Light Status (2) Table 4 describes common status messages and the lights displayed for each and their meaning. For a list of warnings and faults, see Chapter 10-40 Troubleshooting. I. DOUBLE UNIT OPERATION (1) The unit [...]

  • Страница 49

    10-20 Page 42 2008-08-28 Table 4. Status Messages with LED State NHTC Display Message LED state System Action Idle None Unit is made idle. Humidifying GRN (after steam production starts) The unit has closed the contactor and is sending current to the cylinder to humidify . MANUAL DRAIN: ON YEL (blink) The drain valve is activated. SAFETY LOOP; OPEN[...]

  • Страница 50

    10-20 Page 43 2008-08-28 Symptom Diagnose d Probable Cau se Corrective Acti on Unit is awaiting a demand or control signal. This is normal when there is no need for humidity . If you believe there is a need for humidity , and the unit should not be idl e, refer to trouble shooting Normal Operation The unit is now boiling water in the cylinder and f[...]

  • Страница 51

    10-20 Page 44 2008-08-28 2. STEAM DISTRIBUTION A. STEAM DISTRIBUTOR OPERATION (1) Figure 8 describes the method by which the steam distrib utor releases pure clean steam into the duct while collecting co ndensate and removing it by the condensate return. B. SAM-e OPERATION (1) Figure 9 describes the method by which the Short Absorption Manifold rel[...]

  • Страница 52

    10-20 Page 45 2008-08-28 Figure 9. SAM-e Operation Figure 10. Blower Pac k Operation and Adjustments[...]

  • Страница 53

    10-20 Page 46 2008-08-28 3. CONTROLS AND REMOTE COMMUNICATION (OPTIONAL) A. DIGITAL CONTROL OPERATION (1) Figure 11 shows the components of the NORTEC Controller and how to adjust t he setpoint. (2) In the case of a modulating NORTEC Cont roller, Figure 12 shows the relation between the difference from setpoint to %rh in th e room and the 0-10 V DC[...]

  • Страница 54

    10-20 Page 47 2008-08-28 Figure 12. Difference from Setpoint in Relation to Demand Signal Figure 13. Duct and Wall Mounted Transducer D. NORTEC LINKS 2 OPERATION (1) NORTEC LINKS 2 is an option that can be integrate d with the NHTC. This allows a BMS to monitor and in the right config urat ion, control the humidifier. For additional information abo[...]

  • Страница 55

    10-20 Page 48 2008-08-28 THIS P AGE INTENTIONALL Y LEFT BLANK[...]

  • Страница 56

    10-30 Page 49 2008-08-28 10-30 MAINTENANCE PROCEDURES[...]

  • Страница 57

    10-30 Page 50 2008-08-28 MAINTENANCE PROCEDURES 1. NH ELECTRODE STEAM HUMIDIFIERS A. MAINTENANCE WARNING DISCONNECT MAIN POWER BEFORE ANY SERVICING. WARNING THE PLUMBING AND ELECTRICAL COMPARTMENTS CONTAIN HIGH VOLTAGE COMPONENTS AND WIRING. ACCESS SHOULD BE LIMITED TO AUTHORIZED PERSONNEL ONLY. (1) The NHTC and its components are a very low mainte[...]

  • Страница 58

    10-30 Page 51 2008-08-28 D. COMPONENTS OF THE STEAM CY LIN DER (1) Consult Figure 1 for NORTEC cylinder componen ts. Figure 1. Cylinder Components[...]

  • Страница 59

    10-30 Page 52 2008-08-28 Figure 2. Cylinder Removal Procedure E. HOW TO REMOVE THE STEAM CYLINDER (1) Consult Figure 2 for removal of the steam cylinder.[...]

  • Страница 60

    10-30 Page 53 2008-08-28 F. MANDATORY CLEANING OF THE DRAIN VALVE (1) Always clean the drain valve before in stalling a new cylinder since th e valve port may be as dirty as the use d cylinder. Figure 3 describes the process of removing and cleaning the drain valve. Perform paragra ph E. before proceeding. Figure 3. Drain Valve Maintenance[...]

  • Страница 61

    10-30 Page 54 2008-08-28 G. HOW TO INSTALL THE REPLACEMENT CYLINDER (1) Consult Figure 4 to install the replace ment cylinder. Figure 4. Cylinder Replacement Pro cedure[...]

  • Страница 62

    10-40 Page 55 2008-08-28 10-40 TROUBLESHOOTING[...]

  • Страница 63

    10-40 Page 56 2008-08-28 1. TROUBLESHOOTING NH EL ECTRODE STEAM HUMIDIFIERS A. PREPARATION (1) Ensure the installation detail conform to installation require ments. (2) Understanding the Principle of Opera tion and the software me nus is an asset when troubleshooting. This information is foun d in chapter 10-20 Operatio n and can be elaborated on b[...]

  • Страница 64

    10-40 Page 57 2008-08-28 Table 1. Troubleshooting Sympto ms System What to Check Why Nothing is h appening when the on/off switch is turned on Main power is on and matches the specified voltage on the specification label. No, or improper voltage can cause the electronics or compone nts not to respond. 24 V AC output from the step-down transformer .[...]

  • Страница 65

    10-40 Page 58 2008-08-28 Table 2. Ensuring A Demand Signal 2. TROUBLESHOOTING DISTRIBUTORS CAUTION KEEP IN MIND WHEN TROUBLESHOOTING DISTRIBUTORS THAT THEY ARE BEING USED WITH STEAM AND THEREFORE, ARE AND CAN REMAIN VERY HOT DURING THE TROUBLESHOOTING PROCESS. A. TROUBLESHOOTING ATMOSPHERIC DISTRIBUTORS (1) If the distributor is spitting out water,[...]

  • Страница 66

    10-40 Page 59 2008-08-28 (2) If the SAM-e is condensing insid e the duct, make sure that the design conditions have not changed. (3) If grommets leak, make sure the tube s are firmly inserted, if cracks or damage are found, replace grommet. 4. BLOWER PACKS TROUBLESHOOTING A. PROCEDURE (1) An optional blower pack (BP), ensure power supplied to blowe[...]

  • Страница 67

    10-40 Page 60 2008-08-28 Table 3. NH System Messages NHTC Display Message LED state System Action Symptom Diagnosed E5: Cylinder B Controller missing RED Humidifier is in standby until problem corrected. On power up, the controller cannot detect the driver board for cylinder B. E6: Extendet Missing RED Humidifier activates its fault relay and inter[...]

  • Страница 68

    10-40 Page 61 2008-08-28 Probable Ca use Corrective Action 1. T he driver board is damaged. 2. C ontroller is not configured correctly . 1. Replace the driver board. 2. Verify that the humidifier is a double unit. 3. Ch eck that the driver board ribbon cable is connected to the main board. 1. T he master unit is not configured correctl y . 2. Is th[...]

  • Страница 69

    10-40 Page 62 2008-08-28 Table 3. NH System Messa ges (cont) NHTC Display Messag e LED state System Action Symptom Diagnos ed E17: Req off current RED Humidifier interrupts operation and the fault rel a y is activated. With no system de mand, current is detected in the cylinder . W18: Foam YEL Syste m will activate selected foam algorithm. (See Fig[...]

  • Страница 70

    10-40 Page 63 2008-08-28 Probable Cause Corre ctive Action 1. Is th e contactor closed but not energized? 2. D oes the processor board display capacity output but contactor is open? 1. Replace the cont actor . 2. Re place the driver b oard. 1. Back pressure? 2. Organ ics present in water? 3. Insu fficient drain or over concentration. 1. Verify drai[...]

  • Страница 71

    10-40 Page 64 2008-08-28 Table 3. NH System Messa ges (cont) NHTC Display Messag e LED state System Action Symptom Diagnos ed W27: Safety loop instability YEL The safety loop is interruptin g humidifier operation. A security control is causing the safety loop to switch on and off too rapidly . W28: demand signal instability YEL The deman d signal i[...]

  • Страница 72

    10-40 Page 65 2008-08-28 Probable Cause Corre ctive Action 1. T he high limit is too close to the distributor . 2. Is th ere loose wiring? 3. Are there defective con t rols? 4. Is th e safety high limit set point is too low? 1. Re locate high limit 10 feet from the steam distributor . 2. Ch eck all wires at the safety controls. 3. Replace any defec[...]

  • Страница 73

    10-40 Page 66 2008-08-28 Table 4. Term Definitions 6. 0-10V DIGITAL HUMIDIST AT SENSOR CALIBRATION A. PROCEDURE (1) The humidity sensor is factory calibrated, however, it can be field recalibrated. The calibration routine can be accessed by pr essing and holding down th e option button for five seconds. A new screen will appear with the calibration[...]

  • Страница 74

    10-50 Page 67 2008-08-28 10-50 TECHNICAL[...]

  • Страница 75

    10-50 Page 68 2008-08-28 1. WIRING AND TERMINALS A. HUMIDIFIER CONTROL INFORMATION (1) See Figure 7 and Figure 9 in Chapter 10-10 for Controller and Transducer terminal definitions. See Figure 6 in Chapter 10-10 for low voltage terminal strip terminal definitions. Table 1. Controller and Sens or Specifications Power Supply Operating V oltage 24 V A[...]

  • Страница 76

    10-50 Page 69 2008-08-28 B. NH WIRING (1) See Figure 1and 2 for the NHTC/NHPC Single and Double Unit Wiring d iagrams. Figure 1. NHTC/NHPC Double Unit Wiring Diagram[...]

  • Страница 77

    10-50 Page 70 2008-08-28 Figure 2. NHTC/NHPC Wiring Diagram[...]

  • Страница 78

    10-50 Page 71 2008-08-28 2. CHECK LISTS A. PRE-NORTEC ONLINE START UP CH ECKLIST WIRING (1) Humidifier-to-Humidifier Connection: Each individual Humidifie r linked to lead Unit. Connection can be direct or daisy-chained to other units. (2) Network Connection: Lead Unit wired to Local Network (Ethernet, GPRS, Dial-up). Network activity verified. (3)[...]

  • Страница 79

    10-50 Page 72 2008-08-28 C. HUMIDIFIER MANDATORY PRE-START UP CHECK LIST Unit Serial # : _______ __________ No. of humidifiers: ___ ____ T ag: _______________ Unit type: _______ __________ V olt age: _____V/___ph S team output: ____lbs/hr Customer/Job: ______________ Address: ________ _____________________ Inspected by: ________________ Date of ins[...]

  • Страница 80

    10-50 Page 73 2008-08-28 D. HUMIDIFIER MANDATORY START-UP CHECKLIST AND QUICK REFERENCE Unit Serial # : _ ________________ No. of humidifiers: _______ T ag: _______________ Unit type: ______ _____________ V oltage: _____V/___ph S team output: ____lbs/hr Customer/Job: ______________ Address: _________ ___________________________ __ Inspected by: ___[...]

  • Страница 81

    10-50 Page 74 2008-08-28 E. PERIODIC MAINTENANCE CHECKLIST A ND QU ICK REFERENCE (PAGE 1 OF 2) Unit Serial # : _______ __________ No. of humidifiers: ___ ____ T ag: _______________ Unit type: ____________ _______ V oltage: _____V/__ _ph Ste am output: ____lbs/hr Customer/Job: ______________ Address: ____ __________________________ ________ Inspecte[...]

  • Страница 82

    10-50 Page 75 2008-08-28 E. PERIODIC MAINTENANCE CHECKLIST AND QU ICK REFERENCE (PAGE 2 OF 2) Unit Serial # : _ ________________ No. of humidifiers: _______ T ag: _______________ Unit type: ______ _____________ V oltage: _____V/___ph S team output: ____lbs/hr Customer/Job: ______________ Address: _________ ___________________________ __ Inspected b[...]

  • Страница 83

    10-50 Page 76 2008-08-28 3. SPARE PARTS AND EXPLODED VIEWS A. ASD, BSD, CSD DISTRIBUTOR (1) See Figure 3 for the ASD, BSD, CSD Dist ributor exploded view and spare parts. Figure 3. Distributor Exploded View and Spare Parts B. SAM-e SPARE PART S (1) See Figure 4 for the SAM-e exploded view an d spare parts. Figure 4. SAM-e Exploded View an d Spare P[...]

  • Страница 84

    10-50 Page 77 2008-08-28 Figure 5. NHTC/NHPC Plumbing Compartment Exploded View and Spare Parts C. NH SERIES HUMIDIFIER SPARE PARTS (1) See Figure 5 for the NHTC/ NHPC plumbing compartment exp loded view and spare parts and Table 2 for the parts list . See Figure 6 for the NHTC/NHPC electrical compartment exploded view and spare p arts and Table 3 [...]

  • Страница 85

    10-50 Page 78 2008-08-28 Table 2. NHTC/NHPC Plumbing Part List ITEM NO. DESCRIPTION NORTEC PA R T N O . SINGLE PHASE THREE PHASE MODEL 005 010 020 020 030 050 075 100 1 50 200 VOL TS/PH 1 10-120 208/1 220-240/1 227/1 380/1 440-480/1 550-600/1 208/1 220-240/1 277/1 380/1 440-481/1 550-600/1 208/3 220-240/3 380/3 440-480/3 550-600/3 208/3 220-240/3 3[...]

  • Страница 86

    10-50 Page 79 2008-08-28 Table 2. NHTC/NHPC Plumbing Pa rt List (cont) ITEM NO. DESCRIPTION NORTEC PA R T N O . SINGLE PHA SE THREE PHASE MODEL 005 010 020 02 0 030 050 075 100 150 200 VOL TS/PH 1 10-120 208/1 220-240/1 227/1 380/1 440-480/1 550-600/1 208/1 220-240/1 277/1 380/1 440-481/1 550-600/1 208/3 220-240/3 380/3 440-480/3 550-600/3 208/3 22[...]

  • Страница 87

    10-50 Page 80 2008-08-28 Figure 6. NHTC/NHPC Electrical Compartm ent Exploded View and Spare Parts[...]

  • Страница 88

    10-50 Page 81 2008-08-28 Table 3. NHTC/NHPC Electrical Parts List ITEM NO. DESCRIPTION NORTEC PA R T N O . SINGLE PHASE THREE PHASE MODEL 005 010 020 020 030 050 075 100 1 50 200 VOL TS/PH 1 10-120 208/1 220-240/1 227/1 380/1 440-480/1 550-600/1 208/1 220-240/1 277/1 380/1 440-481/1 550-600/1 208/3 220-240/3 380/3 440-480/3 550-600/3 208/3 220-240/[...]

  • Страница 89

    10-50 Page 82 2008-08-28 Table 3. NHTC/NHPC Electrical Parts List (con t) ITEM NO. DESCRIPTION NORTEC PA R T N O . SINGLE PHA SE THREE PHASE MODEL 005 010 020 020 030 05 0 075 100 150 200 VOL TS/PH 1 10-120 208/1 220-240/1 227/1 380/1 440-480/1 550-600/1 208/1 220-240/1 277/1 380/1 440-481/1 550-600/1 208/3 220-240/3 380/3 440-480/3 550-600/3 208/3[...]

  • Страница 90

    10-50 Page 83 2008-08-28 THIS P AGE INTE NTION ALL Y LEFT BLA NK[...]

  • Страница 91

    WARRANTY (1) Walter Meier Inc. and/or Walter Meier Ltd. ( hereinafter collectively referred to as THE COMPANY), warrant for a period of two years afte r installation or 30 months from manufacturer’s ship date, whichever da te is earlier, that THE COMPANY’s manufactured and assembled products, not ot herwise expressly warranted (with the excepti[...]

  • Страница 92

    Cylinder Replacement Da te (MM/DD/YYYY) Authorized Agent: INST ALLA TION DA TE (MM/DD/YYYY) MODEL # SERIAL # CYLINDER # U.S.A. W alter Meier (Climate USA) In c. 826 Proctor Avenu e Ogdensburg, NY 13669 TEL: 1-866-NORTE C-1 EMAIL: northamerica.climate@waltermeie r .com WEBSITE: www .humidity .com CANADA W alter Meier (Cli mate Canada) Ltd. 2740 Fent[...]