Lenovo THINKPAD X100E инструкция обслуживания

T hinkP a d X1 00e Hard w ar e M a i nte n a n c e M a n ua l[...]

[...]

T hinkP a d X1 00e Hard w ar e M a i nte n a n c e M a n ua l[...]

Note Before using this information and the pr oduct it supports, be sure to read the general information under “Notices” on page 127. First Edition (December 2009) © Copyright Lenovo 2009. LENOVO products, data, computer softwar e, and services have been developed exclusively at private expense and are sold to governmental entities as commer c[...]

Contents About this manual .......... v Safety information .......... 1 General safety .............. 2 Electrical safety ............. 3 Safety inspection guide ........... 5 Handling devices that are sensitive to electr ostatic discharge ............... 6 Grounding r equirements .......... 6 Safety notices (multilingual translations) ..... 7 Impo[...]

W indows 7 Professional (32 bit) DVDs .... 1 2 5 Common service tools .......... 1 2 6 Notices .............. 1 2 7 T rademarks .............. 1 2 8 iv ThinkPad X100e Hardwar e Maintenance Manual[...]

About this manual This manual contains service and refer ence information for the following ThinkPad ® products. ThinkPad X100e MT 2876, 3506, 3507, and 3508 Use this manual along with the advanced diagnostic tests to troubleshoot problems. Important: This manual is intended only for trained service technicians who are familiar with ThinkPad produ[...]

vi ThinkPad X100e Hardwar e Maintenance Manual[...]

Safety information This chapter presents following safety information that you need to be familiar with before you service a ThinkPad Notebook. v “General safety” on page 2 v “Electrical safety” on page 3 v “Safety inspection guide” on page 5 v “Handling devices that are sensitive to electr ostatic discharge” on page 6 v “Groundin[...]

General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force. Never move suddenl[...]

Electrical safety Observe the following rules when working on electrical equipment. v Find the room emer gency power-off (EPO) switch, disconnecting switch, or electrical outlet. If an electrical accident occurs, you can then operate the switch or unplug the power cord quickly . v Do not work alone under hazardous conditions or near equipment that [...]

v Do not touch live electrical circuits with the r eflective surface of a plastic dental mirror . The surface is conductive; such touching can cause personal injury and machine damage. v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – B[...]

Safety inspection guide The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each machine was designed and built, requir ed safety items were installed to pr otect users and service technicians from injury . This guide addresses only those items. Y ou should use good judgment to identify potential s[...]

Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif ference in charge between objects. Pr otect against ESD damage by equalizing the charge so that the machine, t[...]

Safety notices (multilingual translations) The safety notices in this section are pr ovided in the following languages: v English v Arabic v Brazilian Portuguese v French v German v Hebrew v Japanese v Korean v Spanish v T raditional Chinese Safety information 7[...]

DANGER Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer . V erify this by shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. DANGER Some standby batteries contain a sma[...]

DANGER T o avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. DANGER Unless hot swap is allowed for the FRU being replaced, do as follows before removing[...]

10 ThinkPad X100e Hardwar e Maintenance Manual[...]

Safety information 11[...]

PERIGO Antes de ligar o computador após a substituição da FRU, certifique-se de que todos os parafusos, molas e outras peças pequenas estejam no lugar e não estejam soltos dentro do computador . V erifique isso sacudindo o computador e procurando ouvir sons de peças soltas. Peças metálicas ou lascas de metal podem causar curto-circuito. PER[...]

PERIGO Para evitar choque elétrico, não remova a capa plástica que protege a parte inferior da placa inversora. PERIGO Embora as principais baterias possuam baixa voltagem, uma bateria em curto-circuito ou aterrada pode produzir corrente o bastante para queimar materiais de pessoal ou inflamáveis. PERIGO A menos que uma hot swap seja permitida [...]

DANGER A vant de remettre l’ordinateur sous tension après remplacement d’une unité en clientèle, vérifiez que tous les ressorts, vis et autres pièces sont bien en place et bien fixées. Pour ce faire, secouez l’unité et assurez-vous qu’aucun bruit suspect ne se produit. Des pièces métalliques ou des copeaux de métal pourraient caus[...]

DANGER Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. DANGER Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de courant pour brûler des matériau[...]

VORSICHT Bevor nach einem FRU-Austausch der Computer wieder angeschlossen wird, muß sichergestellt werden, daß keine Schrauben, Federn oder andere Kleinteile fehlen oder im Gehäuse vergessen wurden. Der Computer muß geschüttelt und auf Klappergeräusche geprüft werden. Metallteile oder-splitter können Kurzschlüsse erzeugen. VORSICHT Die Ber[...]

VORSICHT Die Leuchtstoffröhre im LCD-Bildschirm enthält Quecksilber . Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll beachten. Der LCD-Bildschirm besteht aus Glas und kann zerbrechen, wenn er unsachgemäß behandelt wird oder der Computer auf den Boden fällt. W enn der Bildschirm beschädigt ist und die darin befindliche Flüssi[...]

18 ThinkPad X100e Hardwar e Maintenance Manual[...]

Safety information 19[...]

20 ThinkPad X100e Hardwar e Maintenance Manual[...]

Safety information 21[...]

22 ThinkPad X100e Hardwar e Maintenance Manual[...]

Safety information 23[...]

PELIGRO Antes de encender el sistema despues de sustituir una FRU, compruebe que todos los tornillos, muelles y demás piezas pequeñas se encuentran en su sitio y no se encuentran sueltas dentro del sistema. Compruébelo agitando el sistema y escuchando los posibles ruidos que provocarían. Las piezas metálicas pueden causar cortocircuitos eléct[...]

PELIGRO Para evitar descargas, no quite la cubierta de plástico que rodea la parte baja de la tarjeta invertida. PELIGRO Aunque las baterías principales tienen un voltaje bajo, una batería cortocircuitada o con contacto a tierra puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en el personal. PEL[...]

26 ThinkPad X100e Hardwar e Maintenance Manual[...]

Safety information 27[...]

28 ThinkPad X100e Hardwar e Maintenance Manual[...]

Important service information This chapter presents following important service information that applies to all machine types supported by this manual: v “Strategy for replacing FRUs” – “Strategy for replacing a har d disk drive” on page 30 – “Important notice for replacing a system boar d” on page 30 – “How to use error message[...]

Use the following strategy to prevent unnecessary expense for r eplacing and servicing FRUs: v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue . v Some computers have both a processor boar d and a system board. If you are instructed to r eplace either the proces[...]

Strategy for replacing FRUs for CT O, CMV , and GA V Product definition Dynamic Configure T o Order (CTO) This provides the ability for a customer to configur e an IBM ® or a Lenovo solution from an eSite, and have this configuration sent to fulfillment, wher e it is built and shipped directly to the customer . The machine label, Product Entitleme[...]

v Business Partners using Eclaim will access PEW when performing Entitlement Lookup. Business Partners will enter Loc ID, MT and Serial, and the key commodities will be returned in the Eclaim r ecord under SYSTEM DET AILS. v Authorized IBM Business Partners can access Eclaim at the following W eb site: https://wca.eclaim.com Using eSupport For Key [...]

General checkout This chapter presents following information: v “What to do first” on page 34 v “Checkout guide” on page 35 – “Diagnostics using PC-Doctor for DOS” on page 35 – “T esting the computer” on page 36 – “Detecting system information with PC-Doctor” on page 37 – “Lenovo ThinkV antage T oolbox (Lenovo System T[...]

What to do first When you do return a FRU, you must include the following information in the parts exchange form or parts return form that you attach to it: __ 1. Name and phone number of service technician __ 2. Date of service __ 3. Date on which the machine failed __ 4. Date of purchase __ 5. Failure symptoms, err or codes appearing on the displ[...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the ThinkPad Notebook. Note: The diagnostic tests are intended to test only ThinkPad pr oducts. The use of non-ThinkPad products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1. Identify[...]

T esting the computer In this product, you need an external optical drive to use the PC-Doctor diagnostic CD to test the hardwar e features. Note: The PC-Doctor diagnostic CD does not support any external optical drives connected through USB devices or any others. T o run the test, do as follows: 1. T urn off the computer . 2. Attach an external op[...]

The options on the test menu are as follows: Diagnostics Interactive T ests v Run Normal T est v Run Quick T est v CPU/Coprocessor v System board v V ideo Adapter v Fixed Disks v Diskette Drives v Other Devices v W ireless LAN v Advanced Memory T ests v Keyboard v V ideo v Internal Speaker v Mouse v Diskette v System Load v Optical Drive T est v In[...]

v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive Lenovo ThinkV antage T oolbox (Lenovo System T oolbox) Lenovo ThinkV antage ® T oolbox (Lenovo System T oolbox in W indows ® XP) is a diagnostic program that works thr ough the W indows operating system. It enables you to view symptoms of computer problems and solutions for t[...]

FRU tests The following table shows the test for each FRU. T able 1. FRU tests FRU Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard Power Diagnostics --> ThinkPad Devices --> AC Adapter , Battery 1 (Battery2) LCD unit 1. Diagnostics --> V ideo Adapter 2. Interactive T ests --> V ideo A[...]

T able 1. FRU tests (continued) FRU Applicable test T rackPoint or pointing device If the T rackPoint does not work, check the configuration as specified in the BIOS Setup Utility . If the T rackPoint is disabled, select Automatic to enable it. After you use the T rackPoint, the pointer may drift on the screen for a short time. This drift can occur[...]

Power system checkout T o verify a symptom, do the following: 1. T urn off the computer . 2. Remove the battery pack. 3. Connect the AC adapter . 4. Check that power is supplied when you turn on the computer . 5. T urn off the computer . 6. Disconnect the AC adapter and install the charged battery pack. 7. Check that the battery pack supplies power[...]

Checking operational charging T o check whether the battery charges pr operly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer . Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery pack and let i[...]

Checking the backup battery Do the following: 1. Power off the computer , and unplug the AC adapter from it. 2. T urn the computer upside down. 3. Remove the battery pack (see “1010 Battery pack” on page 71). 4. Remove the backup battery (see “1 120 System board, fan assembly , and backup battery” on page 92). 5. Measure the voltage of the [...]

44 ThinkPad X100e Hardwar e Maintenance Manual[...]

Related service information This chapter presents following information: v “Restoring the factory contents by using Recovery Disc Set” v “Passwords” on page 46 v “Power management” on page 50 v “Symptom-to-FRU index” on page 52 Restoring the factory contents by using Recovery Disc Set When the hard disk drive (HDD) or solid state dr[...]

1. Make the CD/DVD drive the first startup device in the startup sequence using the following procedur e: a. Press and hold down the F1 key , and then turn on the computer . When the logo screen is displayed or if you hear r epeating beeps, release the F1 key . The Setup Utility program opens. b. Use the arrow keys to select Startup → Boot . c. S[...]

Exception: If only an SVP is installed, the passwor d prompt does not appear when the operating system is booted. Power-on password A power-on password (POP) pr otects the system from being power ed on by an unauthorized person. The password must be enter ed before an operating system can be booted. For how to remove the POP , see “How to r emove[...]

After the POST ends, the password pr ompt does not appear . The POP has been removed. 5. Reinstall the backup battery and the battery pack. (B) If an SVP has been set and is known by the service technician: 1. T urn on the computer . 2. When the ThinkPad logo comes up, immediately press F1 to enter BIOS Setup Utility . For models supporting the Pas[...]

7. T ype the current master HDP in the Enter Current Password field. then leave the Enter New Password field blank, and press Enter twice. 8. Press F10. 9. Select Ye s in the Setup Configuration window . Both user HDP and master HDP will have been removed. Related service information 49[...]

Power management T o reduce power consumption, the computer has thr ee power management modes: screen blank, sleep (standby in W indows XP), and hibernation. Screen blank mode If the time set on the “T urn off monitor” timer in the operating system expir es, the LCD backlight turns off. T o put the computer into screen blank mode, do as follows[...]

Note: The computer does not accept any input immediately after it enters sleep (standby) mode. W ait a few seconds before taking any action to r eenter operation mode. Hibernation mode In hibernation mode, the following occurs: v The system status, RAM, VRAM, and setup data are stor ed on the hard disk. v The system is powered of f. Note: If the co[...]

Symptom-to-FRU index This section contains following information: v “Numeric error codes” v “Error messages” on page 55 v “No-beep symptoms” on page 55 v “LCD-related symptoms” on page 56 v “Intermittent problems” on page 57 v “Undetermined problems” on page 57 The symptom-to-FRU index in this section lists symptoms and erro[...]

T able 2. Numeric error codes (continued) Symptom or error (beeps, if any) FRU or action, in sequence 021 1 Keyboard err or (two short beeps) Run interactive tests of the keyboard and the auxiliary input device. 0230 Shadow RAM error—Shadow RAM fails at offset nnnn. (two short beeps) System board. 0231 System RAM error—System RAM fails at offse[...]

T able 2. Numeric error codes (continued) Symptom or error (beeps, if any) FRU or action, in sequence 02F0 CPU ID:xx Failed. 1. CPU. 2. System board. 02F5 DMA test failed. (two short beeps) 1. DIMM. 2. System board. 02F6 Software NMI failed (two short beeps) 1. DIMM. 2. System board. 02F7 Fail-safe timer NMI failed (two short beeps) 1. DIMM. 2. Sys[...]

Error messages T able 3. Error messages Symptom or error (beeps, if any) FRU or action, in sequence Bad CRC2. Enter BIOS Setup Utility , and load Setup defaults. (two short beeps) Press F1 to enter BIOS Setup Utility . Press F9, and Enter to load the default setting. Then save the current setting by pressing F10, and restart the computer . Fan erro[...]

LCD-related symptoms T able 5. LCD-related symptoms Symptom or error FRU or action, in sequence No beep, power-on indicator on, and a blank LCD during POST . System board . v LCD backlight not working. v LCD too dark. v LCD brightness cannot be adjusted. v LCD contrast cannot be adjusted. 1. Reseat the LCD connectors . 2. LCD assembly . 3. System b[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

58 ThinkPad X100e Hardwar e Maintenance Manual[...]

Status indicators This chapter presents the system status indicators that show the status of the computer . 1 2 3 T able 6. Status indicators Indicator Meaning 1 Power on Green: The computer is on and ready to use. The power switch stays lit whenever the computer is on and is not lit when the computer is in sleep (standby) mode. 2 Sleep[...]

T able 6. Status indicators (continued) Indicator Meaning 3 Battery status Green: The battery has more than 20% char ge. Orange: The battery has between 5% and 20% charge. Fast blinking orange: The battery has less than 5% charge. Note: The battery may be charging. Slow blinking orange: The battery is being charged. When it r eaches 20%, the [...]

Fn key combinations The following table shows the function of each combination of Fn with a function key . T able 7. Fn key combinations Key combination Description Fn+F1 T urn the audio volume down. Fn+F2 T urn the audio volume up. Fn+F3 Mute the microphone Fn+F4 Put the computer in sleep (standby) mode. T o return to normal operation, press the F[...]

T able 7. Fn key combinations (continued) Key combination Description Fn+F7 For W indows XP: Apply a presentation scheme dir ectly , with no need to start Presentation Dir ector . T o disable this function and use the Fn+F7 key combination for switching a display output location, start Presentation Dir ector , and change the settings. Click Start -[...]

T able 7. Fn key combinations (continued) Key combination Description Fn+F12 Put the computer into hibernation mode. T o return to normal operation, press the power button for less than four seconds. Notes: T o use this combination of the keys, ThinkPad PM device driver must have been installed on the computer . Though the screen fades out immediat[...]

64 ThinkPad X100e Hardwar e Maintenance Manual[...]

FRU replacement notices This chapter presents notices r elated to removing and replacing parts. Read this chapter carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the ThinkPad Notebook, this problem is addr essed with special nylon-coated screws that have the following characteristics: v They main[...]

Retaining serial numbers This section includes the following descriptions: v “Restoring the serial number of the system unit” v “Retaining the UUID” v “Reading or writing the ECA information” on page 67 Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the [...]

The algorithm that generates the number is designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same number . When you replace the system boar d, you must set the UUID on the new system board as follows: 1. Install the LENOVO ThinkPad Hardwar e Maintenance Diskette V ersion 1.76 or later , and restart the [...]

68 ThinkPad X100e Hardwar e Maintenance Manual[...]

Removing and replacing a FRU This chapter presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU repla[...]

Before servicing ThinkPad X100e Some models of the ThinkPad X100e you are servicing might have the SIM car d that the customer has installed. If the computer you are servicing has the SIM car d, remove it before you start the servicing. T o remove the SIM car d, you need to remove following FRUs: v “1010 Battery pack” on page 71 v “1020 Botto[...]

1010 Battery pack T able 8. Removal steps of battery pack DANGER Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. Important notice for replacing a battery pack: ThinkV antage T oolbox (in W indows 7) and Lenovo System T oolbox (in W indows XP) have an automatic battery diagnostic that d[...]

T able 8. Removal steps of battery pack (continued) Unlock the battery latches 1 . Holding the battery latches in the unlocked position, remove the battery pack in the dir ection shown by arrow 2 . 1 1 2 When installing: Install the battery pack in the slot, and then make sure that the battery latch is in the locked position. 72 ThinkPa[...]

1020 Bottom door For access, remove this FRU: v “1010 Battery pack” on page 71 T able 9. Removal steps of bottom door Note: Loosen the screws 1 , but do not r emove them. 1 1 1 1 1 1 2 Removing and replacing a FRU 73[...]

Note: Applying labels to the bottom door The new bottom door FRU is shipped with a kit containing label. When you replace the bottom door , you need to apply the following label: 1 Serial number blank label 79x16 Following labels need to be peeled off fr om the old bottom door , and need to be put on the new bottom door . 2 SIRM label ?[...]

1030 Hard disk drive (HDD) For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 T able 10. Removal steps of HDD 1 2 When installing: Make sure that the HDD connector is attached firmly . Attention: v Do not drop the drive or apply any physical shock to it. The drive is sensitive to physic[...]

1040 DIMM For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 T able 1 1. Removal steps of DIMM Note: Loosen the screws 1 , but do not r emove them. 1 1 2 a b Note: If only one DIMM is used on the computer you are servicing, the car d must be installed in SLOT -0 ( a ), but n[...]

1050 PCI Express Mini Card for wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 T able 12. Removal steps of PCI Express Mini Card for wireless LAN In step 1a and 1b , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the co[...]

T able 12. Removal steps of PCI Express Mini Card for wireless LAN (continued) 3 When installing: Plug the gray cable into the jack marked MAIN or M , and the black cable into the jack marked AUX or A on the card. 78 ThinkPad X100e Hardwar e Maintenance Manual[...]

1060 PCI Express Mini Card for wireless W AN For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 T able 13. Removal steps of PCI Express Mini Card for wireless WAN In step 1a and 1b , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the c[...]

T able 13. Removal steps of PCI Express Mini Card for wireless WAN (continued) 3 Note: Plug the red cable into the jack marked MAIN , and the blue cable into the jack marked AUX on the card. 80 ThinkPad X100e Hardwar e Maintenance Manual[...]

1070 Bluetooth daughter card (BDC-2) For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 T able 14. Removal steps of BDC-2 1 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, small-head, nylon-coated (1) Silver 0.181 Nm (1.85 kgfcm) When installing: Make sure that the connector i[...]

1080 Keyboard For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 T able 15. Removal steps of keyboard 1 1 Step Screw (quantity) Color T orque 1 M2 × 3 mm, big-head, nylon-coated (2) Black 0.181 Nm (1.85 kgfcm) 2 82 ThinkPad X100e Hard[...]

T able 15. Removal steps of keyboard (continued) 3 4 5 6 7 7 8 Removing and replacing a FRU 83[...]

T able 16. Installation steps of keyboard When installing the keyboard, do as follows: 1. Attach the keyboard connectors. 2. Attach the keyboard so that the fr ont edge of the keyboard are under the frame as shown in this figure. 3. Secure the keyboar d by tightening the screws from the bottom side of the computer . 84 ThinkPad X100e Hardwar e Main[...]

1090 Palm rest assembly , power-on board assembly (with cable), and microphone For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 v “1080 Keyboard” on page 82 T able 17. Removal steps of palm rest assembly , power-on board assembly (with[...]

T able 17. Removal steps of palm rest assembly , power-on board assembly (with cable), and microphone (continued) 1 2 3 4 5 6 6 Step Screw (quantity) Color T orque 6 M2 × 6 mm, wafer-head, nylon-coated (2) Silver 0.181 Nm (1.85 kgfcm) When installing: Make sure that the connectors ar e attached firmly . 86 ThinkPad X100e Hardwar e Maintenanc[...]

T able 17. Removal steps of palm rest assembly , power-on board assembly (with cable), and microphone (continued) 7 7 7 8 1 1 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, big-head, nylon-coated (2) Black 0.181 Nm (1.85 kgfcm) Removing and replacing a FRU 87[...]

T able 17. Removal steps of palm rest assembly , power-on board assembly (with cable), and microphone (continued) 1 2 When installing: Make sure that all the pr ojections of the palm rest assembly are attached firmly to the guide holes of the base cover . 88 ThinkPad X100e Hardwar e Maintenance Manual[...]

1 100 CRT board assembly (with cable) For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 v “1080 Keyboard” on page 82 v “1090 Palm rest assembly , power-on boar d assembly (with cable), and microphone” on page 85 T able 18. Removal s[...]

T able 18. Removal steps of CRT board assembly (with cable) (continued) 6 7 Step Screw (quantity) Color T orque 6 M2 × 4 mm, wafer-head, nylon-coated (1) Silver 0.181 Nm (1.85 kgfcm) 90 ThinkPad X100e Hardwar e Maintenance Manual[...]

1 1 10 Speaker assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 v “1080 Keyboard” on page 82 v “1090 Palm rest assembly , power-on boar d assembly (with cable), and microphone” on page 85 T able 19. Removal steps of speake[...]

1 120 System board, fan assembly , and backup battery Note: The fan assembly and the backup battery are attached to the system boar d. Important notices for handling the system board: When handling the system board, bear the following in mind. v The system board has an acceler ometer , which can be broken by applying several thousands of G-forces. [...]

T able 20. Location of major sensitive components on the system board Following components soldered on the top side of the system boar d are extremely sensitive. When you service the system boar d, avoid any kind of rough handling. a Accelerometer chip for the HDD Active Protection System ™ b North Bridge c CPU d South Bri[...]

T able 21. Removal steps of system board, fan assembly , and backup battery 4 4 1 2 3 Step Screw (quantity) Color T orque 4 M2 × 4 mm, wafer-head, nylon-coated (2) Silver 0.181 Nm (1.85 kgfcm) When installing: Make sure that the connectors ar e attached firmly . 94 ThinkPad X100e Hardwar e Maintenance Manual[...]

T able 21. Removal steps of system board, fan assembly , and backup battery (continued) 5 6 When installing: Make sure that the connector is attached firmly . Removing and replacing a FRU 95[...]

T able 21. Removal steps of system board, fan assembly , and backup battery (continued) DANGER Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. 7 7 8 9 10 11 When installing: Make sure that the connectors ar e attached firmly . When installing: Before you attach the fan assembly to the [...]

1 130 LCD unit For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 v “1080 Keyboard” on page 82 v “1090 Palm rest assembly , power-on boar d assembly (with cable), and microphone” on page 85 v “1 120 System board, fan assembly , and[...]

T able 22. Removal steps of LCD unit (continued) 3 3 3 Step Screw (quantity) Color T orque 3 M2 × 4 mm, wafer-head, nylon-coated (3) Silver 0.181 Nm (1.85 kgfcm) 4 4 98 ThinkPad X100e Hardwar e Maintenance Manual[...]

1 140 DC-in cable and base cover assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 v “1080 Keyboard” on page 82 v “1090 Palm rest assembly , power-on boar d assembly (with cable), and microphone” on page 85 v “1 120 Syste[...]

Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover , you need to apply the following labels: 2 Homologation label 3 FFC label 5 Certified label under battery 6 Serial number barcode blank label 9 Information label unde[...]

2010 LCD bezel assembly For access, remove the following FRU: v “1010 Battery pack” on page 71 T able 24. Removal steps of LCD bezel assembly 1 1 Step Screw (quantity) Color T orque 1 M2 × 4 mm, wafer-head, nylon-coated (2) Silver 0.181 Nm (1.85 kgfcm) 2 2 2 2 2 2 2 2 3 Removing and replacing a FRU 101[...]

2020 Integrated camera For access, remove these FRUs, in or der: v “1010 Battery pack” on page 71 v “2010 LCD bezel assembly” on page 101 T able 25. Removal steps of integrated camera 2 1 When installing: Make sure that the connector is attached firmly . 102 ThinkPad X100e Hardwar e Maintenance Manual[...]

2030 LCD panel, hinges, and LCD cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 v “1080 Keyboard” on page 82 v “1090 Palm rest assembly , power-on boar d assembly (with cable), and microphone” on page 85 v “1 120 System bo[...]

T able 26. Removal steps of LCD panel, hinges, and LCD cable (continued) 3 3 3 3 Step Screw (quantity) Color T orque 3 M2 × 4 mm, wafer-head, nylon-coated (6) Silver 0.181 Nm (1.85 kgfcm) When installing: When attaching the LCD panel to the cover , press the left and right edges covered with metal gently with your fingers. DO NOT pr ess the [...]

T able 26. Removal steps of LCD panel, hinges, and LCD cable (continued) 6 7 8 Removing and replacing a FRU 105[...]

2090 Antenna kit and LCD rear cover assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 71 v “1020 Bottom door” on page 73 v “1030 Hard disk drive (HDD)” on page 75 v “1080 Keyboard” on page 82 v “1090 Palm rest assembly , power-on boar d assembly (with cable), and microphone” on page 85 v “1 120 Sy[...]

Locations This chapter presents the location of ThinkPad X100e featur es and hardware. Front view 1 Integrated camera (for some models) 2 Power switch 3 Security keyhole 4 Universal serial bus (USB) connector 5 4-in-1 Media Card Reader slot 6 Power status indicators Note: For the description of each indicator , s[...]

Rear view 1 Combo audio jack 2 RJ-45 (Ethernet) connector 3 Universal serial bus (USB) connectors 4 External monitor connector 5 AC power connector 5 4 3 2 1 Bottom view 1 Battery pack 2 Battery pack latch 3 Built-in stereo speaker 4 Bottom door 3 3 4 1 1 2 108 ThinkPad X100e Hardwar e Maintenan[...]

Parts list This chapter contains following lists of the service parts. v “Overall” on page 1 10 v “LCD FRUs” on page 1 17 v “Keyboard” on page 1 19 v “AC adapters” on page 120 v “Miscellaneous parts” on page 120 v “Power cords” on page 121 v “Recovery discs” on page 122 v “Common service tools” on page 126 Notes: v E[...]

Overall 1 2 3 4 5 6 7 8 9 10 19 20 18 17 16 15 14 13 12 11 11 0 ThinkPad X100e Hardwar e Maintenance Manual[...]

T able 28. Parts list—Overall No. FRU (Overall) FRU no. CRU ID 1 LCD unit (see “LCD FRUs” on page 1 17.) 2 Power-on boar d assembly (with cable) 63Y2090 N 3 Palm rest assembly 60Y5284 N 4 System board assembly , AMD Athlon (DX9) v 2876-CTO, 36x v 3506-CTO v 3507-CTO v 3508-CTO, 22x, 24x, 25x, 2Bx, 2Cx, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Kx, 6Lx, [...]

T able 28. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 5 SA T A hard disk drive, 250 GB, 5,400 rpm v 2876-CTO, 27x, 28x, 2Bx, 2Ex, 2Fx, 2Nx, 2Sx, 2Vx, 2Xx, 2Zx, 33x, 34x, 35x, 37x, 38x, 39x, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Tx, 3Ux, 3Vx, 42x, 43x, 45x, 46x, 48x, 49x, 4Bx, 4Qx, 4Rx, 4Sx, 4Tx, 4Ux, 4Vx, 4Xx, 4Yx, 53x, 62x v 3506-CTO v [...]

T able 28. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 8 Battery pack, Li-ion (3 cell) 17 v 2876-CTO, 2Px, 2Tx, 2Xx, 3Qx, 3Tx, 3Vx, 3Yx, 3Zx, 44x, 45x, 46x, 47x, 48x, 49x, 4Bx, 4Fx, 4Gx, 4Hx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px v 3506-CTO v 3507-CTO v 3508-CTO, 27x, 2Px, 2Rx, 49x, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Lx, 4Nx, 4Px, 4Qx, 4Rx[...]

T able 28. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 9 Base cover assembly for 2876 (red) v 2876-CTO, 2Cx, 2Dx, 2Ex, 2Qx, 2Rx, 2Sx, 2Tx, 2Yx, 2Zx, 39x, 3Cx, 3Fx, 3Px, 3Vx, 3Xx, 3Zx, 42x, 47x, 4Ax, 4Bx, 4Dx, 4Hx, 4Lx, 4Px, 4Ux, 4Xx, 55x 60Y5278 N 9 Base cover assembly for 2876 (white) v 2876-CTO, 29x, 2Ax, 2Bx, 2Lx, 2Mx, 2Nx,[...]

T able 28. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 12 CR T board assembly (with cable) 63Y2091 N 13 Backup battery 93P4905 ** 14 Thermal module for AMD Athlon 60Y5262 N 15 Bluetooth daughter card (BDC-2.1) v 2876-CTO, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Nx, 2Px, 2Sx, 2Tx, 2Vx, 2Xx, 2Zx, 33x, 34x, 3[...]

T able 28. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 16 Intel Centrino Advanced-N + W iMAX 6250, WW SKU v 2876-CTO, 2Gx, 2Px, 2Tx, 33x, 34x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Mx, 3Nx, 3Px v 3506-CTO v 3507-CTO v 3508-CTO, 26x, 27x 60Y3195 ** 16 Intel Centrino Advanced-N + W iMAX 6250, Russia SKU v 2876-CTO v 3506-CTO v 3507-CTO[...]

LCD FRUs 1 4 3 2 5 7 6 Parts list 11 7[...]

T able 29. Parts list—1 1.6-inch HD LED-backlight LCD No. FRU (11.6-inch HD LED-backlight LCD) FRU no. CRU ID 1 LCD bezel assembly 60Y5263 N 2 Hinges for 1 1.6-inch LCD v 2876-CTO v 3506-CTO v 3507-CTO v 3508-CTO 60Y5279 N 2 Hinges for 1 1.6-inch LCD v 2876-CTO v 3506-CTO v 3507-CTO v 3508-CTO 60Y5280 N 3 W ireless LAN/W AN antenna cable 45M2886 [...]

Keyboard T able 30. Parts list—Keyboard Language FRU no. CRU ID Arabic 60Y9371 45N2976 N Belgian 60Y9372 45N2977 Brazilian Portuguese 60Y9370 45N2975 Bulgarian 60Y9373 45N2978 Canadian French (058) 60Y9368 45N2973 Canadian French (Acnor) 60Y9367 45N2972 Czech 60Y9374 45N2979 Danish 60Y9375 45N2980 Dutch 60Y9385 45N2990 Finnish, Swedish 60Y9392 45[...]

AC adapters T able 31. Parts list—2-pin AC adapters FRU FRU no. CRU ID 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T5282 * 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T4423 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T4419 T [...]

Power cords A ThinkPad power cord for a specific country or region is usually available only in that country or region: T able 34. Parts list—2-pin power cords Country or region FRU no. CRU ID Argentina v models -CTO, xxY 42T5020 42T5105 * Brazil v models -CTO, xxP 42T5180 42T5183 Canada, U.S. v models -CTO, xxF , xxL, xxS, xxU 42T5008 42T5093 Ja[...]

Recovery discs Windows XP Home Edition (32 bit) DVDs W indows XP Home Edition (32 bit) is pr einstalled as the operating system in the following models: v 2876-CTO, 36x v 3506-CTO v 3507-CTO v 3508-CTO, 22x, 24x, 25x, 2Bx, 2Cx, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Kx, 6Lx, 6Mx T able 36. Parts list—Windows XP Home Edition (32 bit) recovery DVDs Languag[...]

Windows 7 Starter (32 bit) DVDs W indows 7 Starter (32 bit) is preinstalled as the operating system in the following models: v 2876-CTO, 3Xx, 3Yx, 3Zx, 47x, 4Rx, 4Tx, 4Ux, 4Vx, 4Xx v 3506-CTO v 3507-CTO v 3508-CTO, 46x, 47x, 4Bx, 4Qx, 4Rx, 4Wx, 4Xx, 6Fx T able 37. Parts list—Windows 7 Starter (32 bit) recovery DVDs Language P/N CRU ID English 58Y[...]

Windows 7 Home Premium (32 bit) DVDs W indows 7 Home Premium (32 bit) is pr einstalled as the operating system in the following models: v 2876-CTO, 27x, 2Hx, 2Lx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 39x, 3Ax, 3Bx, 3Fx, 3Px, 3Sx, 3Ux, 3Vx, 3Wx, 4Px, 4Qx, 62x, 63x, 64x v 3506-CTO v 3507-CTO v 3508-CTO, 28x, 2Mx, 2Nx, 4Gx, 4Hx, 4Jx, 4Nx, 4Px, 63x,[...]

Windows 7 Professional (32 bit) DVDs W indows 7 Professional (32 bit) is pr einstalled as the operating system in the following models: v 2876-CTO, 25x, 26x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Jx, 2Mx, 2Wx, 2Xx, 2Yx, 34x, 35x, 37x, 38x, 3Cx, 3Tx, 45x, 46x, 48x, 49x, 4Ax, 4Bx, 4Dx, 4Fx, 4Hx, 4Jx, 4Kx, 4Wx, 4Yx, 4Zx v 3506-CTO v 3507-CTO v[...]

Common service tools T able 41. Parts list—Common service tools T ool P/N Screwdriver kit 95F3598 1/4 ″ drive spinner handle 1650840 1/4 ″ Sq. to 1/4 ″ hex torx adapter 93F2838 TR7-TR-10 tamper resistant torx bits 00P6967 Removal tool antenna RF connector 08K7159 USB 2.0 CD-R W/DVD-ROM combo drive II 40Y8687 USB cable 40Y8704 USB floppy dis[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

vary significantly . Some measurements may have been made on development-level systems and there is no guarantee that these measur ements will be the same on generally available systems. Furthermore, some measur ements may have been estimated through extrapolation. Actual results may vary . Users of this document should verify the applicable data f[...]

[...]

Part Number: 63Y0640 (1P) P/N: 63Y0640[...]