Invacare 1148114 инструкция обслуживания

Dealer: This manual MUST be given to the end user. User: Before using this cylinder, read this manual and save for future reference. For more information regarding Invacare products, parts, and services, please visit www.invacare.com Operator’s Manual HomeFill ™ Oxygen Post Valve Cylinder HF2POST6 HF2POST9 HF2POSTD “Caution: Federal law restr[...]

HomeFill ™ 2 Part No 114811 4  WARNING DO NOT OPERATE THIS EQUIPMENT WITHOUT FIRST READING AND UN DERSTANDING THIS MANUAL. IF YOU ARE UNABLE TO UNDERSTAND THE WARNINGS, CAUTIONS, AND INSTRUCTIONS, CONTACT A HEALTHCARE PROFESSI ONAL, DEALER OR A QUALIFIED TECHNICIAN BEFORE ATTEMPTING TO USE THIS EQUIPM E NT - OTHERWISE INJURY OR DAMAGE MAY RESU[...]

TABLE OF CONTENTS Part No 1148114 3 HomeFill ™ TABLE OF CONTENTS SPECIAL NOTES ............................................... 4 RECEIVING INSPECTION .................................. 4 INTENDED USE ................................................ 4 SECTION 1—GENERAL GUIDELINES .................. 5 SECTION 2—FEATURES ........................[...]

SPECIAL NOTES HomeFill ™ 4 Part No 114811 4 SPECIAL NOTES Signal words are used in this manual and apply to hazards or unsafe practices which could re sult in personal injury or property damage. Refer to the following table for definitions of the signal words. RECEIVING INSPECTION Remove product from package and inspect for damage. If there is an[...]

SECTION 1—GENERAL GUIDELINES Part No 1148114 5 HomeFill ™ SECTION 1—GENERAL GUIDELINES  WARNING SECTION 1 - IMPORTANT SAF EGUARDS contains important information for the safe operation and use of this product. DO NOT use this prod uct or any available optional equipment without fi rst completely reading and understanding these instruct ions[...]

SECTION 1—GENERAL GUIDELINES HomeFill ™ 6 Part No 114811 4  WARNING DO NOT attempt to repair product. DO NOT immerse product in any kind of liquid. Store product in a clean area when not in use. Only use an Inv acare Co rporation HF2POST6BAG or HF2POST9BAG carrying bag. NEVER smoke in an area where oxygen is being administered. AL W A YS con[...]

SECTION 1—GENERAL GUIDELINES Part No 1148114 7 HomeFill ™  WARNING NEVER oil or lubricate the cylinder fittings. NEVER use any penetrating oil or lubricant such as WD-40 or 3 in One. If connection difficulty is experien ced v erify that the cylinder fitting is being inserted straight down into the compressor coupler . If continued difficul t[...]

SECTION 2—FEATURES HomeFill ™ 8 Part No 114811 4 SECTION 2—FEATURES FIGURE 2.1 Product Diagram Cylinder Fill Port Toggle Valve[...]

SECTION 3—TYPICAL PRODUCT PARAMETERS Part No 1148114 9 HomeFill ™ SECTION 3—TYPICAL PRODUCT PARAMETERS DIMENSIONS : HF2POST6: Weight 4.0 lbs (1.81 kg) HF2POST6: Overall L ength 11.1 in. (2.8 cm) HF2POST6: Diameter 4.4 in. (11.1 cm) HF2POST9: Weight 5.0 lbs (2.27 kg) HF2POST9: Overall Length 14 in (35.5 cm) HF2POST9: Diameter 4.4 in (11.1 cm) [...]

SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ™ 10 Part No 1148114 SECTION 4—INSPECTION AND COMPRESSOR INTERFACE NOTE: Refer to the HomeFill ™ Compr essor Owner’s Manual for compressor operating instructions. Cylinder Prefill Inspection  WARNING All cylinders MUST be inspected before attempting to fill; otherwise, injury or da[...]

SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1148114 11 HomeFill ™ External Examination NOTE: For this procedur e, r efer to FIGURE 4.1 on page 12. 1. Examine the outside of the cylinder for the following conditions and replace the cylinder if they exist: • Dents or dings • Arc burns • Oil or grease • Any other signs of damage[...]

SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ™ 12 Part No 1148114 FIGURE 4.1 External Examination Checking Cylinder Pressure  WARNING NEVER use tools of any kind to conn ect/disconnect the cylinder and the compressor. Otherwise, severe injury and/or damage may occur. DO NOT drop oxygen cylind ers. Use two hands when handling/transp[...]

SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1148114 13 HomeFill ™ 2. Ensure toggle v alve is open. Open the toggle v alve by rotating counterclockwise. 3. Examine the gauge on the connected conserver or regulator . P erform one of the following: • If the cylinder pressure is less than 1500 psig, fill the cylinder . Connect the cyli[...]

SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ™ 14 Part No 1148114 FIGURE 4.2 Component Identification 4. Remove the post v alve cov er (located on the cylinder) and the connector fillport covers (located on the compressor) (FIGURE 4.3). FIGURE 4.3 Fillport Covers 5. On the compressor unit, mome ntarily push DOWN on the outer ring (sle[...]

SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1148114 15 HomeFill ™ NOTE: If the outer ring (sleeve) is in the UP position (GREEN dots not visible), the connector fillport will not be able to accept the cylinder fillport. Pushing DOWN momentarily will reset the connector fill port (GREEN dots visible) to accept the cylinder fillport. F[...]

SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ™ 16 Part No 1148114 NOTE: Refer to Cylinder Fill T ime s on page 20 for the length of time it will take to fill the cylinder . FIGURE 4.5 Connecting the Cylinde r to the Compressor Cylinder Compressor Cradle Outer Ring (Sleeve) Connector Fillport Power Switch Cylinder Fillport PULL UP DETA[...]

SECTION 4—INSPECTION AN D COMPRESSOR INTERFACE Part No 1148114 17 HomeFill ™ 11. After the cylinder is full , press the compressor powe r switch to the Off (O) position (FIGURE 4.6). 12. Grasp the cylinder assembly (FIGURE 4.6). 13. W ith the other hand, grasp the outer ring (sleeve) of the connector fillport and push DOWN (FIGURE 4.6). 14. Lif[...]

SECTION 4—INSPECTION AND COMPRESSOR INTERFACE HomeFill ™ 18 Part No 1148114  WARNING The fillport cover on the co nnector fillport and the post valve fillport MUST be replaced after filling and whenever not in use. If either of th e fillport covers are missing contact your healthcare provider before using. 17. Place the fillport covers onto [...]

SECTION 5—MAINTENANCE Part No 1148114 19 HomeFill ™ SECTION 5—MAINTENANCE 1. After each use, clean exterior of the product with a dry , lint free cloth only . 2. Store product in a clean area free from grease, oil, and other sources of contamination. CAUTION DO NOT use cleaning solutions. DO NOT immerse product in any kind of liquid. All repa[...]

SECTION 6—CYLINDER FILL TIMES HomeFill ™ 20 Part No 1148114 SECTION 6—CYLINDER FILL TIMES NOTE: All filling times ar e a ppr oximate and may vary on environmental conditions. * Troubleshooting If post v alv e cylinder fails to function, try the following solutions. If problem cannot be corrected, consult your dealer/home care equipment provid[...]

NOTES Part No 1148114 21 HomeFill ™ NOTES[...]

LIMITED WARRANTY HomeFill ™ 22 Part No 1148114 LIMITED WARRANTY PLEASE NOTE: THE WARRANTY BELOW HAS BEEN DRAFTED TO COMPLY WITH FEDERAL LAW APPLICABLE TO PRODUCTS MANUFACTURED AFTER JULY 4, 1975. This warranty is extended only to the origina l purchaser/user of our products. This warranty gives you specific legal rights and you may also have othe[...]

LIMITED WARRANTY Part No 1148114 23 HomeFill ™ LIMITATIONS AND EXCLUSIONS : THE FOREGOING WARRANTY SHALL NOT APPLY TO SERIAL NUMBERED PRODUCTS IF THE SERIAL NUMBER HAS BE EN REMOVED OR DEFACED; PRODUC TS SUBJECTED TO NEGL IGENCE, ACCIDENT, IMPROPER OPERATION, MAINTENA NCE, OR STORAGE; PRODUCTS MODIFIED WITHOUT INVACARE’S EXPRESS WRITTEN CONSENT[...]

Invacare Corporation www.invacare.co m USA One Invacare Way Elyria, Ohio USA 44036-2125 800-333-6900 Technical Services 800-832-4707 All rights reserved . Trademarks are identified by the symbols ™ and ®. All trademarks are owned by or licensed to Invacare Corporation unless otherwise noted. © 2007 Invacare Corporation Part No 1148114 Rev B - 9[...]