Husqvarna 70R21HV инструкция обслуживания

70R21HV Owner’s Manual 532 19 99-80 Rev . 1 05.1 1.06 BY Printed in U.S.A.[...]

2 W ARNING: Battery posts, terminals and related ac ces so ries contain lead and lead compounds, chemicals known to the State of Cal i for nia to cause can cer and birth defects or oth er re pro duc tive harm. W ash hands after handling. W ARNING: Engine exhaust, some of its con stit u ents, and certain vehicle com po - nents contain or emit chem i[...]

3 CONGRA TULA TIONS on your purchase of a new lawn mower . It has been designed, engineered and man u fac tured to give you the best possible dependability and performance. Should you experience any problem you cannot easily remedy , please contact your nearest authorized service center/department. We have competent, well-trained tech ni cians and [...]

4 ASSEMBL Y Read these instructions and this man u al in its entirety before you attempt to assemble or operate your new lawn mow er. IMPORT ANT : THIS LA WN MOWER IS SHIPPED WITH- OUT OIL OR GASOLINE IN THE ENGINE. Y our new lawn mower has been as sem bled at the factory with the ex cep tion of those parts left unassembled for ship- ping purposes.[...]

5 KNOW YOUR LA WN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERA TING YOUR LA WN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. MEETS CPSC SAFETY REQUIREMENTS Our rotary walk-behind power lawn mowers confor[...]

6 2. T urn nut on underside of drive control to increase drive speed. 3. Operate mower to test drive speed. Readjust as required. 4. If condition fails to improve after the above steps (for- ward speed remains the same), your drive belt is worn and should be re placed. TO ADJUST CUTTING HEIGHT (See Fig. 4) Both front wheels are adjusted by a single[...]

7 OPERA TION • Secure rear of discharge chute to lawn mower housing with knob. • Place rear handle of grass catcher on the crossbar of the lawn mower's lower handle as shown. • Lift the round door of the discharge chute and place the grass catcher into place on the discharge chute. NOTE: Be sure round door of discharge chute rests on gra[...]

8 BEFORE ST ARTING ENGINE ADD OIL (See Fig. 10) Y our lawnmower is shipped without oil in the engine. For type and grade of oil to use, see “EN GINE” in the Maintenance section of this manual. CAUTION: DO NOT overfi ll engine with oil, or it will smoke heavily from the muffl er on startup. 1. Be sure lawnmower is level. 2. Remove oil dipstick[...]

9 ADD GASOLINE (See Fig. 10) • Fill fuel tank to bottom of tank fi ller neck. Do not over- fi ll. Use fresh, clean, regular unleaded gasoline with a minimum of 87 octane. Do not mix oil with gasoline. Purchase fuel in quan ti ties that can be used within 30 days to assure fuel freshness. CAUTION: Wipe off any spilled oil or fuel. Do not store, [...]

10 ➁ ENGINE OIL ➀ HANDLE BRACK ET MOUNT ING PINS ➀ REAR DOOR HINGE ➀ MULCHER DOOR HINGE PIN Check f or Loose F asteners Clean / Inspect Grass Catcher * Check Tires Check Driv e Wheels *** Clean Lawn Mo wer **** Clean under Drive Co v er *** Check Driv e Belt / Pulle ys *** Check / Sharpen / Replace Blade Lubrication Clean and Recharge Batte[...]

11 LA WN MOWER Always observe safety rules when performing any main- te nance. TIRES • Keep tires free of gasoline, oil, or insect control chem- i cals which can harm rubber . • Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage. DRIVE WHEELS Check rear drive wheels each time be fore you mow to be sure t[...]

12 MUFFLER Inspect and replace corroded muffl er as it could create a fi re hazard and/or damage. SP ARK PLUG Replace spark plug at the beginning of each mowing season or after every 100 hours of operation, whichever occurs fi rst. Spark plug type and gap setting are shown in the “PROD UCT SPEC I FI CA TIONS” section of this manual. CLEANING[...]

13 LA WN MOWER TO ADJUST CUTTING HEIGHT See “TO ADJUST CUTTING HEIGHT” in the Operation section of this manual. REAR DEFLECTOR The rear defl ector , attached between the rear wheels of your mower , is provided to minimize the possibility that objects will be thrown out of the rear of the mower into the operator's mowing position. If the d[...]

14 ST ORAGE Immediately prepare your lawn mower for storage at the end of the season or if the unit will not be used for 30 days or more. 3. Be sure that all nuts, bolts, screws, and pins are se- curely fastened. Inspect moving parts for damage, breakage and wear . Replace if necessary . 4. T ouch up all rusted or chipped paint surfaces; sand light[...]

15 FIG. 20 MOWING POSITION OPERA TOR PRES ENCE CONTROL BAR FOLD FORW ARD FOR STORAGE LOWER HANDLE HANDLE KNOB UPPER HANDLE ENGINE FUEL SYSTEM IMPORT ANT : IT IS IMPORT ANT TO PREVENT GUM DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM P ARTS SUCH AS CARBURETOR, FUEL FIL TER, FUEL HOSE, OR T ANK DURING STORAGE. ALCOHOL BLENDED FUELS (CALLED GASOHOL O[...]

16 TROUBLESHOOTING POINTS Does not start 1. Dirty air fi lter . 1. Clean/replace air fi lter . 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty fuel tank and refi ll tank with fresh, clean gas oline. 4. Water in fuel. 4. Empty fuel tank and r efi ll tank with fresh, clean gas oline. 5. Spark plug wire is disconnected. 5. Connect wire [...]

17 ROT AR Y LA WN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14 GEAR CASE ASSEMBL Y - - P ART NUMBER 532 18 82-94 KEY P ART NO. NO. DESCRIPTION 1 532 18 75-30 Case, Lower 2 532 19 12-45 Case, Upper 3 532 18 75-32 Gear , 24 T eeth 4 532 19 12-46 Shaft, Worm 5 532 18 35-05 Wireform 6 532 18 35-06 Bearing, Ball 7 532 18 35[...]

18 ROT AR Y LA WN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14[...]

19 ROT AR Y LA WN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14 1 532 19 05-82 Handle, Grassbag, Rear 2 532 06 53-22 Hairpin Cotter 3 532 18 34-83 Rod, Rear Handle, Grassbag 4 532 40 16-84 Grassbag 5 532 18 85-06 Frame, Grassbag 6 812 00 00-14 E-Ring 7 532 19 05-81 Door , Grassbag 8 532 18 34-79 Rod, Pivot 9 872 14 04-0[...]

20 ROT AR Y LA WN MOWER - - MODEL NUMBER 70R21HV (96143001400) - PRODUCT NUMBER 961 43 00-14[...]

21 1 532 19 70-12 Drive Control Assembly , Complete (Includes Drive Cable) 6 532 18 16-98 Screw , T orx Head #8-5/8 7 532 40 07-23 Bracket, Mounting, Drive Control 8 532 18 62-97 Cap, Drive Control, Bottom 10 532 19 05-65 Cover Assembly , Drive 1 1 532 19 41-88 Screw 12 812 00 00-12 Ring, Retaining 13 532 19 41-86 Screw 14 532 18 71-20 Bearing / Ax[...]

22 S E C T I ON 1: L I MIT E D W A R R A N T Y Husqvarna Forest & Garden Compan y (“Husqvarna”) warrants Husqvarna product to the origin al pur- chaser to be free from defects in material and workmanship fr om th e d ate of purchase for th e “Warranty Period” of the product as s et forth below: Lifetime Warranty: All tiller tines agains[...]