Follett VU155N Series инструкция обслуживания

F ollowing installation , please forw ar d this manual to the appropriat e operations per son . Installation, Oper ation and Ser vice Manual VU155N Ser ies Ice and W at er Dispenser s Order parts online www.follettice.com Ser vice number s abo v e B50000 00119602R00 801 Church Lane • PO Box D, Easton, PA 18044, USA Toll free (800) 523-9361 • (8[...]

Welcome to Follett Corporation Important cautions Specifications Installation Installing dispenser in counter Field wiring diagrams Installing optional icemaker Operation How the dispenser works Cleaning Service Dispense chute cover removal Auger motor assembly removal Gate assembly removal Auger and auger tube removal Dispenser wheel removal Wirin[...]

We lcome to F ollet t Follett ice dispensers enjoy a well-deserved reputation for excellent performance, long-term reliability and outstanding after-the-sale support. To ensure that this dispenser delivers that same degree of service, we ask that you take a moment to review this manual before beginning the installation of the dispenser. Should you [...]

Specif ications Electrical Each icemaker and dispenser require a separate circuit with with electrical disconnect within 10 ft (6m). Equipment ground required. Standard electrical – 115V, 60Hz, 1 phase. Maximum dispenser fuse – 15 amps, Maximum icemaker fuse – 20 amps each. Model Icemaker Dispenser number amperage amperage VU155N series 11.0 [...]

Dimensions and c learances Required clearances 51" (1295mm) minimum above counter for installation if dispenser will be dropped into counter 36" (915mm) minimum above counter for all units after installation for auger cleaning and servicing 12" (305mm) minimum on side opposite ice chute for service 12" (305mm) minimum on ice chu[...]

Installation Installing dispenser in counter Note: All dispensers must be supported from below with supplied 6" – 9" (153 – 229mm) adjustable leg accessory, or equivalent. Do not hang dispenser on flange. All dispensers must be installed level in both directions to ensure proper operation. 1. Check that dispenser location meets all re[...]

F ield wiring diagr ams Note: Field wiring diagrams are intended to aid electricians or technicians in understanding how equipment works. All field wiring must be installed in accordance with all local and NEC codes. LEGEND WIRENUT FIELD CONNECTIONS X EQUIPMENT GROUND B W GRN BL Y DISPENSER LEFT JUNCTION BOX RIGHT JUNCTION BOX BL Y RD W B LOWER JUN[...]

Oper ation How the dispenser w or ks Follett’s dispensers are available in automatic load configurations, fed from one or two Follett remote icemakers or manual load configurations (using ice from another source). In all models, ice is stored below the counter in the dispenser storage area. When the dispense lever or button is pushed, the dispens[...]

Recommended cleaning prior to start up Cleaning ice storage area before use 1. Refer to disassembly instructions (see Service section) and remove dispense wheel from ice storage area. 2. Remove auger, auger tube and dispense mechanism. 3. Wipe all components and ice storage area with cleaning Solution A. 4. Rinse all components and ice storage area[...]

Dispense chut e cov er r emov al 1. Remove top cover. 2. Push chute cover up vertically to slip off holding tab. 3. After clearing tab, pull chute cover forward to remove. Dispense mechanism assembl y r emov al 1. Remove top cover. 2. Remove chute cover (see above). 3. Remove auger motor assembly (see above). 4. Remove quick release pins from the i[...]

wheel motor baffle plate wheel motor mounting plate dispense wheel auger tube auger auger motor (side view) auger bearing plate stationary agitator rotating agitator Front View plain water hook-up chilled water coil Fig. 3 11[...]

Wi r ing diagr ams PL3-1 6 9 AU TO FILL 2 Red 6 Red Red Red Blk Brn Ye l Red 24V JUNCTIO N BO X ICEM AKER #2 BIN SIGNAL (24V) 5 SEC O N 18 M IN O FF Au to F ill Tim er Blu Blu 3 2 ICEM AKER #1 BIN SIGNAL (24V) 3 1 Ye l Ye l A B 9 Brn C NO Brn B 11 5 V olts 24 V olts Ye l Ye l A W ht Ye l Blk AU T OFILL Blk L1 BLK C NO G ry C NO PL3-2 PL2-1 Red Blu [...]

Symptom Ice does not dispense. • Auger motor does not run • Wheel motor does not run Ice does not dispense. • Auger motor runs • Wheel motor runs • Gate does not open Ice does not dispense. • Auger motor does not run • Wheel motor runs Ice does not dispense. • Auger motor runs • Wheel motor does not run No ice in dispenser. Possib[...]

Reference # Description Part # 1 Label, “Follett” 502438 2 Top cover (includes label) 502606 3 Drain pan 502446 4 Grille, drain pan 502450 5 Cover, electrical components 502593 6 Lid, rear access 502594 Not shown Cover, ice storage (under drain pan) 502453 7 Label, ice, dispense cover, push-button 502623 Not shown Label, ice, dispense cover, le[...]

Dispense assembly Side View (RH unit shown) Reference # Description Part # 1 Gate, dispense 502455 2 Linkage pin, gate/solenoid 502456 3 Pin, quick release, 5.53" (141mm), dispense gate 502102 4 Solenoid (includes linkage pin) 501961 5 Dispense mechanism assembly, right hand unit 502458 Not shown Dispense mechanism assembly, left hand unit 502[...]

Reference # Description Part # 1 Auger, LH unit (black, stamped with “1”) 502491 Not shown Auger, RH unit (gray, stamped with “2”) 502492 2 Plate, auger bearing 501696 Not shown Tube, auger, right hand unit 502487 Not shown Tube, auger, left hand unit 502488 3 Wheel, dispense (includes stud and rotating agitator) 501681 4 Baffle (under disp[...]

Reference # Description Part # Auger motor/drive assembly, vertical (includes all items below) 502493 1 Motor, vertical auger (includes gearbox and capacitor) 502476 2 Chain, auger drive #35, 40p 502477 3 Sprocket 35#, 22T 5/8 bore 502478 4 Sprocket 35#, 12T 5/8 bore 502479 5 Drive shaft 502480 6 Bearing, auger, upper and lower 501314 7 Cover and b[...]

Reference # Description Part # 1T ransformer, 24V 502058 2 Relay, dispense 501826 3 Relay, auto fill 501826 4 Timer, auto fill (automatic fill units) 502471 5S trip, terminal 502472 6 Tube, water dispense, stainless steel 502356 7 Bracket, water solenoid 502611 8 Fitting, outlet, 1/8 MPT x 3/8, compression 502562 9 Valve, solenoid, water 502243 10 [...]

19[...]

00119602R00 04/04 801 Church Lane • PO Box D, Easton, PA 18044, USA Toll free (800) 523-9361 • (888) 2-FOLLETT (610) 252-7301 • Fax (610) 250-0696 • www.follettice.com U L ® U L ® C[...]