Desa (V)CD36TNE инструкция обслуживания

Sav e this manual for future reference. For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol-           [...]

www .desatech.com 1 16035-01E 2       -     [...]

www .desatech.com 1 16035-01E 3                    ?[...]

www .desatech.com 1 16035-01E 4              - dr en wh en th ey ar e in th e ro om             ?[...]

www .desatech.com 1 16035-01E 5 LOCAL CODES Install and use replace with care. Follow all local codes. In the absence to local codes, use the cur - rent National Fuel Gas Code ANSI Z223.1/NFP A 54* (USA) or the current CSA-B149 .1 Installati on Code (Canada). *A vailable from: American National Standards Institute, Inc. 1430 Broadway New Y ork, [...]

www .desatech.com 1 16035-01E 6 • If you plan on installing a television or enter - tain men t cen ter reces sed abov e you r re plac e, it is recommended that you maintain a minimum 18" above top of louver opening. • When locating termination cap, it is important to observe the minimum clearances shown in Figure 7, page 8. • If reces[...]

www .desatech.com 1 16035-01E 7 Figure 5 - Framing Clearances for Installation Against an Exterior Wall 36" (914 mm) 36 1 / 4 " (921 mm) Figure 6 - Framing Clearances for Corner Installation PRE-INST ALLA TION PREP ARA TION Continued FRAMING AND FINISHING Figu re 5 show s typic al framing of this replac e. Figu re 6 sho ws framin g for[...]

www .desatech.com 1 16035-01E 8 PRE-INST ALLA TION PREP ARA TION Continued Figure 9 - Rear/T op Common Dimensions Figure 8 - Side Clearances for Combustible Materials 7 5 / 8 " (194 mm) TO CENTER OF 8" TOP VENT 14 3 / 4 " (375 mm) TO NAILING FLANGES 5/8" (16 mm) 36" (914 mm) FACE DIM. 36 1 / 4 " (921 mm) FACE DIM. 15 3[...]

www .desatech.com 1 16035-01E 9 Fixed Closed Op en a bl e Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12 inches (30.5mc) minimum] B = clearance to [...]

www .desatech.com 1 16035-01E 10 VENT ING INST ALLA TION INSTRUCTIONS     -                           -  Thes e mode ls are test[...]

www .desatech.com 1 16035-01E 1 1 INST ALLA TION PLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop. Hori - zon tal inst all ati ons usin g round term ina[...]

www .desatech.com 1 16035-01E 12 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess       6.  [...]

www .desatech.com 1 16035-01E 13 Figure 16 - Installing Inner Wall Firestop VENTING INST ALLA TION INSTRUCTIONS Continued Figure 17 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screws High Wind T ermination Apply Mastic to Outside Edge of Standoff Exterior W all with Vinyl Siding 10 3 / 4[...]

www .desatech.com 1 16035-01E 14 GROUND FLOOR INST ALLA TION Recommended Applications for Rear V ent Model (V)CD36T : • Installation using cabinet surrounds • T h r o u g h t h e w a ll u s i n g ro u n d o r s q u a r e te r mi na ti on (up to 24" horizontal pipe) • Corner installation (Using one 90° elbow and a maximum of 24" of [...]

www .desatech.com 1 16035-01E 15 SNORKEL TERMINA TION INST ALLA TION Recommended Applications Models (V)CD36R and (V)CD36T : • Installations requiring vertical rise on building exterior . • Ins tall ati on using sno rkel ter mina tio n to achi eve 1 ft. above grade. VENTING INST ALLA TION INSTRUCTIONS Continued Figu re 23 - Snorkel Term inat io[...]

www .desatech.com 1 16035-01E 16 T O H VENTING INST ALLA TION INSTRUCTIONS Continued Figure 25 - Horizontal T ermination Conguration for V enting Using Three 90° Elbows (Model (V)CD36T)    TERMINA TION Note: V ertical restrictor must be installed in all vertical insta[...]

www .desatech.com 1 16035-01E 17  1. Cu t a 10 3 / 4 " squ ar e hol e in the cei ling usin g th e lo ca ti ng hol e as a ce nte r p oin t. T he o pen in g sh ou ld be fr am ed t o 10 3 / 4 " x 10 3 / 4 " (2 73 m m x 27 3 mm ) in si de dim en si on s, as sh ow [...]

www .desatech.com 1 16035-01E 18 VENTING INST ALLA TION INSTRUCTIONS Continued      Figures 28 and 29 show two different congura - tions for vertical termination. VERTICAL VENT INST ALLA TIONS USING MUL [...]

www .desatech.com 1 16035-01E 19 VENTING INST ALLA TION INSTRUCTIONS Continued       Figures 30 and 33 show four different congura - tions for vertical termination. VERTICAL VENT INST ALLA TIONS USING MUL T[...]

www .desatech.com 1 16035-01E 20                  P58-6 6" Section Double W all P[...]

www .desatech.com 1 16035-01E 21 FIREPLACE INST ALLA TION            Disconnect the        ?[...]

www .desatech.com 1 16035-01E 22 Blower Location Side View Figure 35 - Blower Model BK Magnetic Strips Exhaust Port Screw Green Ground Wire Spade T erminals Lower Firebox Cavity Figure 36 - Attaching Speed Control to Firebox (Millivolt Models) Speed Control Control Shaft Locknut Control Knob Switch Bracket Blower Plug-In Duplex Outlet (Located unde[...]

www .desatech.com 1 16035-01E 23 V ar ia bl e F a n Sw it c h W hi t e W hi te Bl a c k Gr e en On 11 0 / 1 1 5 V . A . C . Bl o w e r M o t o r B l a c k B l ac k Bl a ck Of f Figure 38 - Location of Wiring Diagram Decal (Model May V ary From Illustration) Wiring Diagram Decal 6" in Front of Blower FIREPLACE INST ALLA TION Continued [...]

www .desatech.com 1 16035-01E 24 1 1. Peel off the backing paper and stick the sup - plied wiring diagram decal on the rebox bot - tom approximately 12" in front of the blower (see Figure 38, page 23). WIRING DIAGRAMS        [...]

www .desatech.com 1 16035-01E 25 FIREPLACE INST ALLA TION Continued INST ALLING OPTIONAL WIRELESS      ?[...]

www .desatech.com 1 16035-01E 26 FIREPLACE INST ALLA TION Continued Figure 48 - Installing Battery Into Handset WRC HIGH AL TITUDE INST ALLA TION Y our DESA direct-vent replace has been tested and approved in the USA for elevations from 0-2000 feet (610 m) and in Canada at elevations from 0-4500 feet (1372 m). High-a ltitud e models as indicat e[...]

www .desatech.com 1 16035-01E 27 FIREPLACE INST ALLA TION Continued             -   ?[...]

www .desatech.com 1 16035-01E 28 FIREPLACE INST ALLA TION Continued Figure 51 - Connecting Flexible Gas Line to Millivolt V alve Flexible Gas Line Do NOT Kink Equipment Shutoff V alve T o Gas Supply (Natural) T o External Regulator (Propane/LP) Control V alve    [...]

www .desatech.com 1 16035-01E 29 FIREPLACE INST ALLA TION Continued   1. Open equipment shutof f valve (see Figure 52, page 28). 2. O pe n p r o p an e /L P su p p ly ta n k v a lv e f o r propane/LP fireplace or main gas va[...]

www .desatech.com 1 16035-01E 30 FIREPLACE INST ALLA TION Continued Fi gu re 57 - Removing/Replacing Glass Door Fi gu re 58 - Installing Logs T op Left Log Front Log T op Right Log Rear Log Rear Log Stand Log Mounts Burner Pan Latch UNLOCK LOCK Door Frame T ab Glass Door Panel      ?[...]

www .desatech.com 1 16035-01E 31 FIREPLACE INST ALLA TION Continued Ember Material Ember T ray Fi gu re 59 - Applying Ember Material                ?[...]

www .desatech.com 1 16035-01E 32 8. Pu sh in ga s co nt ro l kn o b al l the wa y an d ho l d. Im me dia te ly l ig ht th e p il ot by r ep ea t ed ly de - pr e ss in g th ep ie zo spa rk i gn it o r  u nt il a a me ap pe ars . Co nt i nu e to ho ld fo r ab ou t o ne (1 ) mi nu te af te r th e pi lo t is li t. Re lea se g[...]

www .desatech.com 1 16035-01E 33 OPERA TING FIREPLACE Continued Figu re 62 - On/Off Hand-Held Remote Control Unit HRC100 Control Button Indicator Light   pr ess both buttons on hand-held remote control until light stops ashing. Hand- heldr emotecontrol isnowlocked.If ther eis?[...]

www .desatech.com 1 16035-01E 34 OPERA TING FIREPLACE Continued OPERA TING OPTIONAL GWMT1 - W ALL MOUNTED THERMOST A T W ARNING: Do not con-        ?[...]

www .desatech.com 1 16035-01E 35 OPERA TING FIREPLACE Continued 6. W ait ve (5)minutes toclear outany gas. Then smell for .  gas, including near the oor . If you smell gas, STOP! Follow “B” in the safety infor - mation above. If you don’t smell gas go to the next step. 7. T urn eq[...]

www .desatech.com 1 16035-01E 36 Figure 68 - T ypical Flame Pattern OPERA TING FIREPLACE Continued Note for BKT Only: If you a r e usin g B KT blower with optional thermostat (wall mounted orremote control)for the replace,your re - place and blower will not turn on and off at the same time. The replace may?[...]

www .desatech.com 1 16035-01E 37 C L EA NI NG A N D M A IN TE N A N CE               ?[...]

www .desatech.com 1 16035-01E 38 LOGS • If you remove logs for cleaning, refer to Install- ing Logs , Lava Rock and Glowi ng Ember s , page 30, to properly replace logs. • Use a vacuum cleaner to remove any carbon buildup on logs. • Replace log(s) if broken. See Replacement Parts on page 44. • Replace ember material periodically as needed. [...]

www .desatech.com 1 16035-01E 39  When ignitor button is pressed, there is spark at pilot but no ignition Pilot lights but ame goes out when control knob is released Burner does not light after pilot is lit Delayed ignition burner REMEDY 1. Turn on gas supply or open equipment shutoff valve 2. T ur[...]

www .desatech.com 1 16035-01E 40 TROUBLESHOO TING Continued  Burner backring during com - bustion Slight smoke or odor during initial operation Heater produces a whistling noise when burner is lit Glass soots Fir epla ce produ ces a c lick ing /tic k - ing noise just after burners are lit or shut o[...]

www .desatech.com 1 16035-01E 41 TROUBLESHOO TING Continued         [...]

www .desatech.com 1 16035-01E 42 TROUBLESHOO TING        ?[...]

www .desatech.com 1 16035-01E 43 TROUBLESHOO TING Continued         [...]

www .desatech.com 1 16035-01E 44 REPLACEMENT P ARTS Note : Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . P ARTS UNDER W ARRANTY Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA ’ s Customer Service Department at 1-866-67[...]

www .desatech.com 1 16035-01E 45 ACCESSORIES NOTE: All accessories may        Pu rc ha se th es e re pl ace acc ess orie s fro m you r loc al reta ile r . If they can not supply these acces sori es, call DESA ’ s Sa les D epa[...]

www .desatech.com 1 16035-01E 46 ILL USTRA TED P ARTS BREAKDOWN     [...]

www .desatech.com 1 16035-01E 47 P ARTS LIST      Thi[...]

www .desatech.com 1 16035-01E 48 ILL USTRA TED P ARTS BREAKDOWN     [...]

www .desatech.com 1 16035-01E 49 P ARTS LIST      This list co[...]

www .desatech.com 1 16035-01E 50 ILL USTRA TED P ARTS BREAKDOWN     8 5 9 1 1 30 16 28 18 17 29 15 12 13 26 19 20 23 22 10 14 27 4 [...]

www .desatech.com 1 16035-01E 51        1 1 16719-01 Gas V alve Wire Harness (MV/PV) • • • • 1 2 1 16719-02 Gas V alve Wire Harness (MV) • • • • 1 3 1 16719-03 Gas V alve Wire Harness (PV) • • • • 1 4 1 16316-01 Ignition Module Bracket •[...]

2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 16035-01 Rev . E 1 1/05 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notic[...]