Crown Equipment WB Series инструкция обслуживания

N ew Bremen, Ohio 45869 USA © 1 997 PF12462-WEB Rev . 6/06 Printed in U.S.A. This operator manual has information for all models of series WB plus some options and accessories. Some of the illustrations and information may not apply to your truck. The most important component is you.[...]

1 W arning All rights reserved under International and Pan American copyright conventions Copyright 1997 Crown Equipment Corp. Y ou could be killed or seriously injured if you are not adequately trained for lift truck operation! Do not operate this truck in your w ork place until you hav e been trained and certified by your employer . Y ou Must be [...]

Know the Hazar ds Pr otect Y ourself 3 Protect Y ourself USE Y OUR TRUCK CAREFULL Y • W atch your hands and your feet. A foot or hand caught between the truck and a fixed object will be crushed or even cut off. • Keep to the side of the truck while traveling power unit first. Make certain the truck won't hit the back of your leg or foot. D[...]

Know the Hazards T ra veling 19 T raveling W hat's in it for Y ou? 6 What's in it for Y ou? QUICK LOCA TORS In addition to the "Contents" page you can use page headings to find topics. Some pages also hav e a picture of the truck in the corner sho wing features or functions cov ered on that page. "KNOW THE HAZARDS" W a[...]

Y our W alkie Lift T ruck W ALKIE LIFT TRUCKS Y our walkie lift truck can be used to lift, move and stack loads where a counterbalanced truck is needed. It is designed for short travel distances. Y OUR LIFT TRUCK IS NOT AN AUT OMOBILE W ith a load it may weigh more than 3 automobiles. • Y ou don't steer the same. • Y ou don't brak e t[...]

Lift T ruck P arts 9 Lift T ruck P arts Load Backrest Mast Fork Control Handle Key Switch Control Arm Accessory Levers (optional) Raise/Lower Lever Tilt Lev er P ower Disconnect Battery P ower Unit Load Wheel Lift T ruck P arts 10 T wist Grip Lower Button (optional) Raise Button (optional) Horn Button Reversing Button High T ra vel Speed Switch[...]

Capacity & Load Center 1 1 Capacity & Load Center LOADS MUST BE EVENL Y DISTRIBUTED Y our truck could tip over , in any direction, if a load is shifted to the front or side of a pallet or container . WHA T IS YOUR TRUCK CAP ACITY? Capacity is the load (including pallet or container) that can be lifted to a gi ven height at a gi ven load cen[...]

Serial Number Attachment Data Truck W eight with Max. Battery Capacity with Mast Vertical Load Center Units of measure , kg/mm (lb/in) Capacity Truck T ype 600 (24) 600 (24) 685 (27) 685 (27) 4520 (178) 1225 (2700) 3910 (154) 1360 (3000) 4520 (178) 1090 (2400) 3910 (154) 1200 (2650) 2960 (6521) SIDESHIFT A1234567 E 313-D WB SERI ES CAP ACITY PLA TE[...]

P ower On & Off KEY SWITCH T urn the key clockwise. Power is ON. T urn the key counterclockwise. Power is OFF . Always turn the key off when leaving the truck. POWER DISCONNECT Push the battery connector handle down to disconnect the battery and cut all power . Always disconnect the battery any time the truck isn't working right. The key s[...]

Raise/Lower & T ilt 17 Raise/Lower & T ilt Raise/Lower lever Tilt lev er HYDRAULIC LEVER OPERA TION Move the lever away from the mast, toward the control arm, and you'll get the action shown by the symbol on the top of the knob. Move the lever toward the mast and you'll get the opposite action. The farther you move any lever from [...]

T r a veling 19 T ra veling HIGH TRA VEL SPEED For high travel speed, push the high travel speed button on the control handle and rotate the twist grip to the maximum travel speed position. TRA VEL Rotate the top of the twist grip in the direction you want to travel. The farther you rotate the grip from the neutral position, the faster the truck wi[...]

Daily Safety Check 21 Daily Safety Check CHECK Y OUR TRUCK BEFORE ST ARTING WORK Y ou must make sure your truck is safe to use. 1. Walk ar ound your truck and check it ov er . • Check to make sure the battery is charged, water level is OK and vent caps are in place. Don't use an open flame to check the battery . • See that all wheels are i[...]

Be a Safe Oper ator 23 Be a Safe Operator MAKE SURE Y OU ARE READ Y • Do not use this truck unless you are trained and certified. • Be certain you understand how your truck works and the hazards that go with it. Don't use the truck if you have any doubts. • Know the capacity of your truck. Make certain you use the correct units of measur[...]

Be a Safe Oper ator continued 25 Be a Safe Operator continued W A TCH OUT FOR OTHER PEOPLE • Slow down. Y ield or stop for pedestrians. Use your horn when you come to a crosswalk or intersection. • Be careful that you don't pin or crush someone. For example: Never drive your truck towar d anyone standing in fr ont of a fixed object. • Ne[...]

27 Battery Maintenance Battery Maintenance WHEN USING A ROLLER ST AND If you use a roller stand to install or remove a battery make sure the roller stand is the same height as the rollers in your truck's battery compartment. Also make sure the roller stand is at least as long as the battery . AFTER INST ALLING YOUR BA TTER Y • Replace the ba[...]

B attery Maintenance continued 29 Battery Maintenance continued BEFORE CHARGING Y OUR TRUCK BA TTERY • Charge the battery only in areas designated for that use. • See that the battery cells are filled to the proper le vel. Ne ver use an open flame to check the battery . • Make certain the char ger is the same voltage and amperage as your batt[...]