Cal Flame LTR20081044 инструкция обслуживания

L TR20081044, Rev . A 4/21/08[...]

W ARNING If the information in this manual is not fol- lowed exactly , a re or explosion may re - sult causing property damage, personal injury or loss of life. Do not store or use gasoline or other am - mable vapors and liquids in the vicinity of this or any other appliance. This appliance is for OUTDOOR USE ONL Y . Safety Instructions .....[...]

Cal Flame 2008 Owner ’s Manual Page 1 L TR20081044, Rev . A Safety Instructions Read all instructions before you operate your grill. Placement and Location C • al Flame™ grills are designed for outdoor use only . Never locate this appliance in an enclosed room, • under a sealed overhead structure, or in any type of enclosed area such as a g[...]

Page 2 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Safety Instructions Never use the grill or side burner in windy conditions. • If used in a consistently windy area a windbreak will be required. Always adhere to the specied clear - ances listed in this manual. Never line the grill or side burners with aluminum • foil. Do not inst[...]

Cal Flame 2008 Owner ’s Manual Page 3 L TR20081044, Rev . A Installation / Assembly Installation / Assembly Most cities and counties require permits for exterior con - struction and electrical circuits. In addition, some com- munities have codes requiring residential barriers such as fencing and/or self-closing gates on property to pre - vent uns[...]

Page 4 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Installation / Assembly As a safety precaution, remember to always leak test your grill outdoors in a well-ventilated area. Never smoke or permit sources of ignition in the area while doing a leak test. Do not use a ame, such as a lighted match to test for leaks. Use a solution of soa[...]

Cal Flame 2008 Owner ’s Manual Page 5 L TR20081044, Rev . A Installation / Assembly The grill unit must be used with the gas pressure regula - tor . The regulator will control and maintain a uniform gas pressure in the manifold. The burner orices have been sized for the gas pressure delivered by the regulator . W ARNING: Attempting to operate [...]

Page 6 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Installation / Assembly Remove the transformer and the metal screws from the plastic bag. 1. Place the grill on a sturdy surface and tilt it back to show the underside of the grill. 2. Using the metal screws, attach the transformer to the left side of the grill near the internal electric[...]

Cal Flame 2008 Owner ’s Manual Page 7 L TR20081044, Rev . A Installation / Assembly Installing the Rotisserie Attach the two brackets to the sides of the grill, one on each side, using two screws as shown below . Slide the rotis motor on one of the brackets as shown be - low . The rotis motor will work on either side of the grill. Remove the meta[...]

Page 8 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Installation / Assembly Installing Side Burners Assemble a 9.5 mm pipe nipple to the 9.5 mm pipe tee using T eon tape or pipe sealant. Use only sealant that 1. is approved for use on LP gas. Install the pipe tee assembly to the grill intake pipe. T ighten assembly and align the branch[...]

Cal Flame 2008 Owner ’s Manual Page 9 L TR20081044, Rev . A Operating Y our Barbecue Light Switch Grill Grill Grill Grill Infrared Burner BBQ07874CPE - 4 Burner Grill Light Switch Grill Grill Grill Grill Grill Infrared Burner BBQ07875CPE - 5 Burner Grill Infrared Burner Grill Knob Operation Low Off High W arning NEVER cover the entire cooking or [...]

Page 10 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Operating Y our Barbecue Each time you light the grill, check the following: Inspect the hose before using the grill. If there is • excessive abrasion or wear , or if the hose is cut, it must be replaced prior to using the grill. If you need a replacement hose, contact your Cal Flame [...]

Cal Flame 2008 Owner ’s Manual Page 1 1 L TR20081044, Rev . A Operating Y our Barbecue Basic Grill Operation Before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is pres - ent. Check the connection with a soap and water solu - tion after attaching the hose. Make sure there is gas in the t[...]

Page 12 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Operating Y our Barbecue Cooking with a Convection Grill A convection grill has an internal fan that circulates heated air evenly throughout the grilling area when the hood is closed. Cooking in this way distributes heat more efciently so you no longer have to be concerned with “ho[...]

Cal Flame 2008 Owner ’s Manual Page 13 L TR20081044, Rev . A Cleaning and Maintenance Cleaning and Maintenance Clean internal parts of the grill regularly as determined by the amount of use and foods cooked. The entire grill should be cleaned at least once a year . In addition, keep the area around your grill clear and free from combustible mater[...]

Page 14 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Cleaning and Maintenance Light Bulb Replacement W ARNING: Never attempt to replace a light bulb when the grill is in use. Serious burns will result. W ARNING: Never touch halogen bulbs with your bare ngers. Use a tissue or a small piece of paper to handle bulbs. Oils from your hands [...]

Cal Flame 2008 Owner ’s Manual Page 15 L TR20081044, Rev . A Appendix Appendix T roubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perform a leak test following the procedure described in this manual. Problem Burner does not ignite Solution Use the following procedure with the gure below . C[...]

Page 16 Cal Flame 2008 Owner ’s Manual L TR20081044, Rev . A Appendix Problem: Plugged orice Solution: Unplug the orice as follows: Remove cooking grills, ame tamer and grease tray . • Remove burners from the bottom of the rebox by pulling the cotter pin from beneath the burner • peg using a standard screwdriver or needle nose pli[...]

Cal Flame 2008 Owner ’s Manual Page 17 L TR20081044, Rev . A Appendix Disconnect or shut off the gas line connect to the 1. grill. W ait until the burners cool down. Open the hood and remove the grate and ame 2. tamer on top of the burner you want to replace. Through the access door underneath the grill, nd 3. the round stud and locking pin[...]

Location of Serial Number Plate The serial number of your Cal Flame grill is located on the back and is visible when the hood is down as shown at right. Grill Specications Electrical supply: 220V AC / 50 Hz Country of destination BE, CY , CZ, EE, FR, GR, IE, IT , L V , L T , LU, PT , RO, SK, ES, CH, BG A T , HU, SK, CH, DE Gas category I3+ (28-3[...]