Blodgett B12C-B инструкция обслуживания

M ANUAL 1184743 $18.00 S AFFIRE S ERI ES S ECTIONAL R ANGE M ANUAL S ECTION SR Owner ’ s Manual Saffire Series Sectional Range WARNING Improper installation, adjus tment, alteration, service, or maintenan ce can cause property dam age, injury, or death. Read installation, operation, and mainten ance instructions thoroughly before installing or se[...]

S AFETY P RECAUTIONS S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 2 OF 72 O WNER ' S M ANUAL 1184743 SAFETY PRECAUTIONS Before installing and operating this equi pment, be sure everyone involved in its operation is fully trained and aware of precautions. Accidents a nd problems can be caused by failure to follow fundam ental rules and precautions.[...]

S AFFIRE S ERIES S ECTIONAL R ANGE I NTRODUCTION O WNE R ' S M ANUAL 1184743 P AGE 3 OF 72 I NTRODUCTION Congratulations! You have purcha sed one of the finest pieces of heavy-duty commercial cooking equi pment on the market. You will find that your new equipment, like all Blodgett Range equi pment, has been designed and manufa ctured to meet [...]

S PECIFICATIONS S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 4 OF 72 O WNER ' S M ANUAL 1184743 S PECIFICATIONS NOTICE Local codes regarding inst allation vary greatly from one area to another. The Nati onal Fire Protectio n Association, Inc. states in its NFPA 96 latest edition that local codes are the “authority having juri sdictio n” when i[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S PECIFICATIONS O WNE R ' S M ANUAL 1184743 P AGE 5 OF 72 V ENTILATION WARNING Improper ventilation can result in personal injury or d eat h. Ventilation which fails to p roperly remove flue products can cause heada ches, drowsiness, nau sea, or could result in death. All gas appliances must be installed in s[...]

S PECIFICATIONS S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 6 OF 72 O WNER ' S M ANUAL 1184743 Figure 2 Dimensions 7" (178) 2-1/2" (64) 8-1/2" (216) SIDE VIEW of MODULAR MODEL SIDE VIEW 35-3/4" (908) 32" (813) 38" (965) 41-3/4" (1060) 33-3/4" (859) 2-1/2" (64) Flue riser for “deep” depth-option ext[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S PECIFICATIONS O WNE R ' S M ANUAL 1184743 P AGE 7 OF 72 U TILITY R EQUIREMENTS AND C RATED W EIGHT GAS ELECTRICITY Model Width Base Type Top Type Natural Gas (BTU/hour) Propane (BTU/hour) 120V (amps) 208/240V (amps) Crated Weight pounds (kg) B12C-B 12" cabinet flush 35K open-burner 70,000 60,000 - - 22[...]

S PECIFICATIONS S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 8 OF 72 O WNER ' S M ANUAL 1184743 E LECTRICITY S UPPL Y Units with a standard-oven base or a convection -oven base require electric power (50Hz or 6 0Hz single-phase AC). 120V models have a 7-foot (2134 mm) p ower cord with a grounde d plug. 208/240V models have a terminal block for con[...]

S AFFIRE S ERIES S ECTIONAL R ANGE O PERATION O WNE R ' S M ANUAL 1184743 P AGE 9 OF 72 O PERATION DANGER EXPLOSION HAZARD In the event a gas odor is dete cted, shut down equipm ent at the main shut off valve. Immediately call the emergency phone number of your gas supplier. CAUTION If a pilot flame pilot should go out, the flow of gas to t he[...]

O PERATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 10 OF 72 O WNE R ' S M ANUAL 1184743 Figure 3 Operation of Open-Burner Sections Each 12"-wide section has t wo control knobs. The left knob controls the rear burner, whil e the right knob controls the front burner. Each knob can be turned to OFF or to any position in the range from LOW t[...]

S AFFIRE S ERIES S ECTIONAL R ANGE O PERATION O WNE R ' S M ANUAL 1184743 P AGE 11 OF 72 Figure 4 Operation of Unifo rm Hot-Top Section Each 12" section has one control knob, which can be turned to OFF or to any position in the range from LOW to HIGH. When the control is set to HIGH , the hot top surface will heat to about 700°F (370°C)[...]

O PERATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 12 OF 72 O WNE R ' S M ANUAL 1184743 Figure 5 Operation of Graduated Hot-Top Section Each 36"-wide section has on e control knob, which can be turned to OFF or to any position in the range from LOW to HIGH. When the control is set to HIGH, the round center section will heat to about 725?[...]

S AFFIRE S ERIES S ECTIONAL R ANGE O PERATION O WNE R ' S M ANUAL 1184743 P AGE 13 OF 72 Figure 6 Operation of Charbroiler Section Each 12" section has one control knob, which can be turned to OFF, HIGH, or LOW. Each 6"-wide burner top-grate can be turned over to provide either wide brandi ng marks, or narrower branding marks with ch[...]

O PERATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 14 OF 72 O WNE R ' S M ANUAL 1184743 Figure 7 Operation of Standard (Non-The rmostatic) Griddle Sections Each 12"-wide section has on e control knob, which can be turned to OFF, HIGH, or LOW. To start cooking, turn the appropriate control knob to HIGH. Check that the burner ignites. The [...]

S AFFIRE S ERIES S ECTIONAL R ANGE O PERATION O WNE R ' S M ANUAL 1184743 P AGE 15 OF 72 Figure 8 Operation of Thermostatic Griddle Sections Each 12"-wide section has on e control knob that can be turned to OFF, or to any temperature in the range 150°F to 400°F (66°C to 204°C). To start cooking, turn on the appropriate c ontrol knob. [...]

O PERATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 16 OF 72 O WNE R ' S M ANUAL 1184743 Figure 9 Operation of Oven Each oven has a thermostatic control that can be set in the range 150°F to 500°F (66°C t o 260°C). Convection ovens have a fan that can be set to ei ther HI speed or LO speed. For advice on using a convec tion oven, see the i[...]

S AFFIRE S ERIES S ECTIONAL R ANGE O PERATION O WNE R ' S M ANUAL 1184743 P AGE 17 OF 72 S UGGESTIONS FOR C OOKING U SING A C ONVECTION O VEN As a guide, set oven temperatures 25 to 50 degrees lowe r than called for in recipes using co nventional (non- convection) ovens. FROZEN ENTREE PRODUCTS: Punch holes in lid before he ating. Tent lid if p[...]

O PERATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 18 OF 72 O WNE R ' S M ANUAL 1184743 C ORRECTING P ROBL EMS WHEN C OOKING WITH A C ONVECTION O VEN If… then… Cakes are dark on the sides and not done in the center… lower oven temperature. Cake edges are too brown… reduce number of pans or lower oven temperature. Cakes have light oute[...]

S AFFIRE S ERIES S ECTIONAL R ANGE C LEANING & M AINTENANCE O WNE R ' S M ANUAL 1184743 P AGE 19 OF 72 C LEANING & M AINTENANCE WARNING Shut off the gas supply to the appliance before cleani ng or pe rforming maintenance on any g as appliance. The appliance may be equipped with a restraint device to lim it its movement in order to prev[...]

C LEANING & M AINTENANCE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 20 OF 72 O WNE R ' S M ANUAL 1184743 WOOL as any particles left on the surf ace will rust and further spoil the appearance of the finish. NEVER USE A WIRE BRUSH, STEEL SCOURING PADS (EXCEPT ST AINLESS), SCRAPER, FILE OR OTHER STEEL TOOLS. Surfaces which are marred collect di[...]

S AFFIRE S ERIES S ECTIONAL R ANGE I NSTALLATION O WNE R ' S M ANUAL 1184743 P AGE 21 OF 72 I NSTALLATION NOTICE These installation procedures must be followed by qualified personnel or warrant y will be void. Local codes regarding inst allation vary greatly from one area to another. The Nati onal Fire Protectio n Association, Inc. states in i[...]

I NSTALLATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 22 OF 72 O WNE R ' S M ANUAL 1184743 Figure 10 Removal of Shipping Hold-Down Brackets Shipping Hold-Down Brackets S TEP 2 A : A TTACH L EGS TO THE R ANGE A set of four legs is packed with units ordered with legs. (For units ordered with ca sters, go to Step 2b.) A threaded leg pad is faste[...]

S AFFIRE S ERIES S ECTIONAL R ANGE I NSTALLATION O WNE R ' S M ANUAL 1184743 P AGE 23 OF 72 S TEP 2 B : A TTACH C ASTERS TO THE R ANGE NOTICE For an appliance eq uipped with ca sters, (1) the in stallation shall b e made with a connecto r that complies with the Standard for Connectors for Movabl e Gas Appliances, ANSI Z21.69 or Connectors for [...]

I NSTALLATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 24 OF 72 O WNE R ' S M ANUAL 1184743 S TEP 2 C : M OUNT R ANGE ON C ASTER F RAME NOTICE For an appliance eq uipped with ca sters, (1) the in stallation shall b e made with a connecto r that complies with the Standard for Connectors for Movabl e Gas Appliances, ANSI Z21.69 or Connectors for[...]

S AFFIRE S ERIES S ECTIONAL R ANGE I NSTALLATION O WNE R ' S M ANUAL 1184743 P AGE 25 OF 72 NOTICE Adequate means must be provided to limit the movement of the appliance without depending on the con nector and the quick-disconnect device or its associat ed piping to limit the appliance movem ent. The restraining means sho uld be attached to a [...]

I NSTALLATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 26 OF 72 O WNE R ' S M ANUAL 1184743 S TEP 5: A TTACH F LUE R ISER AND S HELF A SSEMBLIES Install the flue riser(s) using the follo wing pro cedure (as shown in Figure 14). 1. Attach any salamander broilers a nd flue-riser-mount ed cheese melters to ap propriate sections following the inst[...]

S AFFIRE S ERIES S ECTIONAL R ANGE I NSTALLATION O WNE R ' S M ANUAL 1184743 P AGE 27 OF 72 2. Slide each flue riser down onto the brac kets projecti ng from the back of the correspondi ng section(s) of the sectional range. Secure the flue rise r to the brackets with the four provided 1/4-20x3/4 hex-head bolts, flat washers, and lockwasher s. [...]

I NSTALLATION S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 28 OF 72 O WNE R ' S M ANUAL 1184743 CAUTION ALL PIPE JOINTS AND CONNECTIONS MUST B E TESTED THOROUGHLY FOR G AS LEAKS. USE ONLY SOAPY WATER FOR TESTING ON ALL GASES. NEVER U SE AN OPEN FLAME TO CHE CK FOR GAS LEAKS. ALL CONNECTIONS MUST BE CHECKED FOR LEAKS AFTER THE AP PLIANCE HAS BEEN P[...]

S AFFIRE S ERIES S ECTIONAL R ANGE I NSTALLATION O WNE R ' S M ANUAL 1184743 P AGE 29 OF 72 4. Light all pilots (see the appropriate Operation section elsewhere in this manual). Start with the section(s) furthest from the gas supply connection(s) to purge air from the gas lines. Check all pilot s for correct flame height. 5. Turn on the burner[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 30 OF 72 O WNE R ' S M ANUAL 1184743 S ERVICE WARNING ADJUSTMENTS AND SERVICE WORK MAY BE PERFORME D ONLY BY A QUALIFIED TECHNICIAN WHO IS EXPERIENCED IN, AND KNOWLEDGEABLE WITH, TH E OPERATION OF COMMERCIAL COOKING EQUIPMENT. TO ASSURE YOUR CONFIDENCE, CONT ACT YOUR AUTHORIZED SERVICE AGENCY F[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 31 OF 72 T ROUBLESHOOTING B URNER S AND P ILOTS The following table lists the possible cau ses of burner and pilot related problems that may occur. Problem Look for - None of the burners and pilots will turn on – Main gas supply to unit is OFF. All burners produce [...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 32 OF 72 O WNE R ' S M ANUAL 1184743 Figure 15 Adjustment of Charbroiler, Standard-Griddle, and Uniform Hot-Top Burners and Pilots The burner valves are not adjustabl e. The burner orifice is of the fixe d type, sized for the type of gas and the op erating alti tude. To adjust the burner air-ga[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 33 OF 72 Figure 16 Adjustment of Graduated Ho t-Top Pilot and Burner The burner valves are not adjustabl e. The burner orifice is of the fixe d type, sized for the type of gas and the op erating alti tude. To adjust the burner air-gas mixtur e, loosen the screw that [...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 34 OF 72 O WNE R ' S M ANUAL 1184743 Figure 17 Adjustment of 35K and 45K Open-Top Burners and Pilots The burner valves are not adjustabl e. The burner orifice is of the fixe d type, sized for the type of gas and the op erating alti tude. To adjust the burner air-gas mixtur e, loosen the screw t[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 35 OF 72 Figure 18 Adjustment of Thermostat ic-Griddle Thermostat Each 12"-wide section of a thermostatic gr id dle has a control knob that oper ates a sn ap-action thermostatic valve. Each valve is adjusted at the factory. If the griddle surface temperature is [...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 36 OF 72 O WNE R ' S M ANUAL 1184743 Figure 19 Adjustment of Thermostatic -Griddle Burners and Pilot The thermostatic burner valve is adjustabl e (see page 35). The burner orific e is of the fixed type, sized for the type of gas a nd the operating altitude. To adju st the burner ai r-gas mixtur[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 37 OF 72 T ROUBLESHOOTING O VEN CAUTION Proper and efficient op eration of oven is d ependent on corr e ct installation and function of components. Always verify that components are in place and functioni ng as intended. The following table lists the possible cau ses[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 38 OF 72 O WNE R ' S M ANUAL 1184743 Hot BLOWER RUNS INTERMITTENTLY Check that the vents at each end of the motor are not obstructed. Check that the motor is not against a wall. Go to the junction box on the back of the range and remove the cover. Place a DVM or ammeter on the black wire #1. Ch[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 39 OF 72 Figure 20 Adjustment of Oven Thermostat The oven thermostat is carefully cal ibrated at the factory so that the dial setting ma tches the actual oven temperature. Field recalibration is seldom necess ary, and should not be resorted to unless considerable coo[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 40 OF 72 O WNE R ' S M ANUAL 1184743 Figure 21 Adjustment of Oven Pilot and Burner The burner orifice is of the fixed t ype, sized for the type of gas and the operating altitude. T o adjust the burner air-gas mix ture, loosen the screw that secures the air shutter on the mi xer face and rotate [...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 41 OF 72 Figure 22 Wiring Diagram for 120 Volt Oven Bases[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 42 OF 72 O WNE R ' S M ANUAL 1184743 P ARTS The following tables and figures list serviceabl e parts. For parts not listed, contact a Blodgett Range Authorized Parts Distributor or a Blodgett Range Autho rized Service Agency. Index of Parts Diagrams Page Number Description 42 F r o n t - R a i [...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 43 OF 72 Figure 24 Leg and Caster Parts 4 5 1 2 3 Key Part Number Qty Descriptio n 1 1172650 4 LEG PAD (3/4 X 10 HOLE) 2 1146500 1 6 1/4 LOCK WASHER 3 1146201 1 6 1/4 X 30 X 3/4 HEX HEAD 4 1174260 1 LEG PACKAGE (set of four legs, not incl uding bolts, leg pads, or lo[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 44 OF 72 O WNE R ' S M ANUAL 1184743 35K-Open-Burner External and Structural Parts See drawing on following page. Quantity* Key Part Number 12" 24" 36" Description 1 1183978 1 - - TRAY ASSEMBLY, 12" CRUMB 1183974 - 1 - TRAY ASSEMBLY, 24" CRUMB 1183972 - - 1 TRAY ASSEMBL[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 45 OF 72 Figure 25 1 2 3 4 5 10 9 6 4 11 12 13 4 14 15 16 17 18 Flush 35K-Open-Burner Models Step-Up 35K-Open- Burner Models 36"-Wide Models Shown 7 8 35K-Open-Burner External and Structural Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 46 OF 72 O WNE R ' S M ANUAL 1184743 35K-Open-Burner Gas Train Parts See drawing on following page. Quantity* Key Part Number 12" 24" 36" Description 1 1183923 1 - - MANIFOLD W/A, 2 BURNER OPEN TOP 1183922 - 1 - MANIFOLD W/A, 4 BURNER OPEN TOP 1183593 - - 1 MANIFOLD W/A, 6 BURNER[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 47 OF 72 Figure 26 3 4 1 2 5 6 7 8 9 10 3 4 1 2 8 10 11 13 12 12 5 7 Flush 35K-Open-Burner Models Step-Up 35K-Open-Burner Models 36"-Wide Models Shown 35K-Open-Burner Gas Train Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 48 OF 72 O WNE R ' S M ANUAL 1184743 45K-Open-Burner Parts See drawing on following page. Key Part Number Qty Description 1 1184689 4 KNOB 2 1184415 1 VALVE PANEL, 36A/D-XX (oven base) 1184407 1 VALVE PANEL, 36C -XX (cabinet base) 1184406 1 VALVE PANEL, 36N-XX (modular-countertop base) 3 118397[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 49 OF 72 Figure 27 11 16 10 3 1 2 4 5 6 7 8 9 12 13 14 17 18 15 4 45K-Open-Burner Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 50 OF 72 O WNE R ' S M ANUAL 1184743 Charbroiler External and Structural Parts See drawing on following page. Quantity* Key Part Number 24" 36" 48" Description 1 1184689 2 3 4 KNOB 2 1184519 1 - - VALVE PANEL, 24C-CC, SS 1184521 1 - - VALVE PANEL, 24N-CC, SS 1183641 - 1 - VALVE P[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 51 OF 72 Figure 28 4 5 1 2 6 7 8 9 11 12 15 16 13 14 17 18 3 10 Charbroiler External and Structural Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 52 OF 72 O WNE R ' S M ANUAL 1184743 Figure 29 Charbroiler and Standard-Griddle Gas Train Parts 4 1 3 5 6 8 9 12 15 16 13 14 2 10 11 7 Pilot Parts for Standard-Griddle Models 36"-Wide Model Shown Pilot Parts for Charbroiler Models Quantity* Key Part Number 12" 24" 36" 48&quo[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 53 OF 72 Figure 30 Gas Connection Parts 3 4 1 2 5 6 7 2 2 Key Part Number Qty Description 1 1147005 1 1" PIPE CAP 2 1146905 2 1" 90 DEGREE ELBOW 3 1163489 1 REAR GAS STUB 4 1184777 1 STRAP, 1-1/4" PIPE 5 1146808 1 1" PIPE NIPPLE 6 1174747 1 TAIL P[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 54 OF 72 O WNE R ' S M ANUAL 1184743 Griddle External a nd Structural Parts See drawing on following page. Quantity* Key Part Number 12" 24" 36" 48" Description 1 1184689 1 2 3 4 KNOB 2 1073497 1 2 3 4 KNOB ASM, VALVE 3 1184653 1 - - - VALVE PANEL, 12C-G, SS 1184657 1 - - - [...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 55 OF 72 Figure 31 3 4 1 2 5 7 8 9 7 10 13 14 12 11 6 Griddle External a nd Structural Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 56 OF 72 O WNE R ' S M ANUAL 1184743 Thermostatic Griddl e Gas Train Parts See drawing on following page. Quantity* Key Part Number 24" 36" 48" Description 1 1183919 1 - - MANIFOLD W/A, 24, CHAR/GRI SECT 1183675 - 1 - MANIFOLD W/A, 36, CHAR/GRI SECT 1183921 - - 1 MANIFOLD W/A, 48[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 57 OF 72 Figure 32 3 4 1 2 5 6 7 8 9 10 13 11 12 14 15 16 18 17 19 22 20 21 Thermostatic Griddl e Gas Train Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 58 OF 72 O WNE R ' S M ANUAL 1184743 Uniform Hot-Top Parts See drawing on following page. Quantity* Key Part Number 12" 24" 36" Description 1 1184689 1 2 3 KNOB 2 1184737 1 - - VALVE PANEL, 12C-H, SS 1184739 1 - - VALVE PANEL, 12N-H, SS 1184933 - 1 - VALVE PANEL, 24C-HH, SS 11847[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 59 OF 72 Figure 33 14 18 13 3 4 1 2 5 6 7 8 9 10 12 3 11 15 16 17 19 21 20 Uniform Hot-Top Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 60 OF 72 O WNE R ' S M ANUAL 1184743 Graduated-Hot-Top Parts See drawing on following page. Key Part Number Qty Description 1 1184689 1 KNOB 2 1184617 1 VALVE PANEL, 36A/D-GRAD, SS (oven base) 1184618 1 VALVE PANEL, 36C-GRAD, SS (cabinet base) 1184619 1 VALVE PANEL, 36N-GRAD, SS (modular-counte[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 61 OF 72 Figure 34 1 2 4 3 6 6 19 7 9 10 11 12 15 16 13 14 17 18 5 8 Graduated-Hot-Top Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 62 OF 72 O WNE R ' S M ANUAL 1184743 Oven Base Parts See drawing on following page. Key Part Number Qty Description 1 1180776 1 OVEN BOTTOMFLAME 2 1180528 2 RACK_GUIDE CO BASE 3 6660 8 CLIP, RACK SUPPORT * 1173545 1 OVEN RACK (for standard oven) 1179920 1 OVEN RACK (for convection oven) 4 1177[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 63 OF 72 Figure 35 7 3 24 1 2 18 16 20 21 22 23 13 12 15 14 6 8 9 17 10 25 19 4 5 11 Oven Base Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 64 OF 72 O WNE R ' S M ANUAL 1184743 Figure 36 Convection Oven Blower Parts 3 4 1 2 5 6 7 Key Part Number Qty Description 1 1180834 1 OVEN BAFFLE CO 2 1177581 1 BLOWER WHEEL ASSEMBLY 3 1177452 1 MOTOR, 1/3 HP, 115 VOLT 4 1180821 1 POCKET W/A, BLOWER, 500 SERIES 5 1181747 1 SHIELD, RT BLOWER, 50[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 65 OF 72 Figure 37 Modular-Countertop Base Parts 3 4 1 2 Key Part Number Qty Description 1 1183863 1 BASE. 12 COUNTERTOP 1183859 1 BASE. 24 COUNTERTOP 1183523 1 BASE. 36 COUNTERTOP 1185418 1 BASE. 48 COUNTERTOP 2 1183861 2 STIFFENER, 12 BASE 1183858 2 STIFFENER, 24 B[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 66 OF 72 O WNE R ' S M ANUAL 1184743 Cabinet-Base Parts See drawing on following page. Quantity* Key Part Number 12" 24" 36" 48" Description 1 1184954 1 - - - CABINET LINING ASM, 12" LT FT 1184952 - 1 - 2 CABINET LINING ASM, 24" LT FT 1183598 - - 1 - CABINET LINING[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 67 OF 72 Figure 38 3 4 1 2 5 6 7 Cabinet-Base Parts See parts list on previous page.[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 68 OF 72 O WNE R ' S M ANUAL 1184743 Flue Riser Parts See drawing on following page. For continuous flue risers spanning multi ple sect ions, or sloped enclosures, contact Blodg ett Range. Key Part Number Qty Description 1 1183617 1 FLUE BOX ASSEMBLY, 36" (for models with an oven base) 2 1[...]

S AFFIRE S ERIES S ECTIONAL R ANGE S ERVICE O WNE R ' S M ANUAL 1184743 P AGE 69 OF 72 Flue Riser Parts (continued) Key Part Number Qty Description 5 1183831 1 SHIELD, 24" X 12" WALL AZ 1184793 1 SHIELD, 24" X 12" WALL SS 1183833 1 SHIELD, 24" X 24" WALL AZ 1184794 1 SHIELD, 24" X 24" WALL SS 1183853 1 S[...]

S ERVICE S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 70 OF 72 O WNE R ' S M ANUAL 1184743 Side Panel and Battery-Assembly Parts Part Number Description 1183547 TRIM, SIDE (if side is not adjacent to another section of a battery) 1183563 TRIM, SIDE (if side is adjacent to an open-burner section of a battery) 1183564 TRIM, SIDE (if side is adjacent[...]

S AFFIRE S ERIES S ECTIONAL R ANGE O WNE R ' S M ANUAL 1184743 P AGE 71 OF 72 Notes:[...]

S AFFIRE S ERIES S ECTIONAL R ANGE P AGE 72 OF 72 O WNE R ' S M ANUAL 1184743 SAFFIRE SERIES SECTIONAL RANGE A product with the Blodgett Ran ge name incorp orates the best in durability and l ow maintenance. We all recognize, however, that replacement parts and occasio nal profe ssional service may be nece ssary to extend the useful life of th[...]