Bakers Pride C011-G1 инструкция обслуживания

BAKERS BAKERS PRIDE PRIDE INST ALLA TION AND OPERA TING INSTRUCTIONS G AS CONVECTION O VEN Model: CO1 1 -G INTENDED FOR OTHER THAN HOUSEHOLD USE RET AIN THIS MANUAL FOR FUTURE REFERENCE OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES A T ALL TIMES IMPORT ANT INSTRUCTIONS After the gas supply has been connected to your unit, it is extremely important to che[...]

I. INST ALLA TION INSTRUCTIONS SECTION ITEM P AGE A Receiving B Set-Up Mounting C Installation with Casters (Optional) D Location and Minimum Clearances E Gas Connection F Electrical Connection G Flue Connections-V entilation H Burner Operation I System Check - Rotary Control II. OPERA TING INSTRUCTIONS 1 General Instructions 2 System Operation Seq[...]

3 observe the clearances detailed in Section D (Location). Provide adequate ventilation and make up air in accordance with local codes. Servicing your oven is done through the front control panel and right side access cover . Assure that these areas are kept unobstructed for easy access. For a single unit: (1) T ilt Oven over onto left hand side, a[...]

E. GAS CONNECTIONS: The ovens should not be installed on the same gas line with space heaters, boilers or other gas equipment with high intermittent demand. The installation of this oven must conform with the latest local codes or Nationa/Fuel Gas Code. ANSI Z223.1, Natural Gas Installation Code. CAN/CGA-BJ49.1. or the Propane Installation Code. CA[...]

installation and thence to an independent earth connection in compliance with EN 60335-1 and/or local codes. The electric motor , all the related switches, interior lights and the timer/buzzer , are all connected through the 6ft (1829 mm) power supply cord located at the rear of the oven. The supply cord must be plugged into a properly grounded thr[...]

II. OPERA TING INSTRUCTIONS 1. GENERAL INSTRUCTIONS: (a) This equipment has an Electronic T emperature Control and Electronic Hot Surface Direct Ignition System. (b) Due to the increased efficiency of this oven, the temperature of standard recipes may be reduced 50°F (30°C). (c) Always load each shelf evenly . Space pans away from each other and [...]

(5) Load the oven with product to be cooked. (6) T urn the timer knob to the desired bake time and timer will start counting down. (7) When timer reaches zero, a buzzer will sound. (8) T urn the T imer knob to '0' position to reset. (9) T urn the thermostat knob to the desired hold temperature. (10) Remove the product from the oven when d[...]

4. SERVICING: NOTE: This appliance must be serviced by an authorized service agent. a) Power supply to the unit must be disconnected before any service is performed. b) Most of the service on the unit can be performed from the front and/or control panel side. c) For proper servicing, access to the Control Panel side of the unit will be required. d)[...]

WHEEL PULLER BOL T 3/8”-HEX BLOWER WHEEL MOTOR SET SCREW (2) ASSEMBL Y OF LEGS (SHOWN WITH OPEN RACK ST AND) 30” CONVECTION OVEN LEGS TOP LEFT ANGLE TOP RIGHT ANGLE 1/2” FLA TW ASHER (4 CORNERS ONL Y) 1/2”-13 x 1” HEX HEAD BOL T (12 REQUIRED) 5/16” FLA TW ASHER (4 REQUIRED) 5/16”-18 HEX NUT (4 REQUIRED) OPEN RACK SHELF RACK SUPPORT 3/[...]

6. CO1 1-G ELECTRICAL SCHEMA TIC (ROT AR Y CONTROL) Flame Sensor Ignitor Gas Control therm. ignitor valve ground sensor l1 4 3 2 1 P4 P3 P2 P1 120V AC SSAC X 0 - O 0...60' X 0...60' O 0 - 5 4 2 1 NOTO 3 7 6 COM HI LO GC-20 NO COM L2 L1 NO NC ooox ooxo oxoo oxxo 24V 120V BUZZER TIMER M450 1 2 4 S Fan Rotary Switch (Off, Low , High, Cool Do[...]

timer M450 flame rod combination control VR 8205 4 3 2 1 P4 P3 P2 P1 light switch COM NO L2 L1 NC NO C flame sensor ground valve hot thermostat L1-24vac ignitor 3 4 5 6 2 1 7 steam switch steam timer potentiometer blk yel red blu solenoid valve FF PILOT IN 120v 24v ignitor 120V AC 1 2 3 4 S Rotary Switch Door Switch Pilot Light (Thermostat) Pilot L[...]

12 V A LV E W A TE R S O L EN O I D B LU R E D Y E L B LK A 1 H 1 H 2 A 2 B R N A 1 B LU 2 9 B LU 3 1 B LU H 2 B R N H 1 B R N P O T E N T IO M E T ER S T EA M T IM E R S T E A M S WI T C H 7 1 2 6 5 4 3 B U T T C O N N E C TO R S T E A M O P T IO N A B D 2 BL U R E D Pu r p le T2 BL U BL U N C N O 1 20 V L ig ht s 1 20 V 2 Sp e e d M oto r VR 8 6 [...]

CO11-G F ull Size Gas Convection Oven 30 Pine Street • New R ochelle • New Y ork • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www .bakerspride.com fax US & Canada web address B AKE R S P RI D E 13 9. P ARTS LISTS & EXPLODED VIEWS Figure B Burners / V alve / Door Chain / Legs OUT OUT IN IN IN IN Safety V alve Legs &am[...]

CO11-G F ull Size Gas Convection Oven 30 Pine Street • New R ochelle • New Y ork • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www .bakerspride.com fax US & Canada web address B AKE R S P RI D E 14 95 94 Figure A Exterior / Interior / Controls / Doors 1 2 3 4 5 6 8 10 1 1 12 13 14 15 17 18 19 20 23 24 25 26 27 28 29 30 31[...]

CO11-G F ull Size Gas Convection Oven 30 Pine Street • New R ochelle • New Y ork • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www .bakerspride.com fax US & Canada web address B AKE R S P RI D E 15 Exterior / Interior / Controls / Doors Item Part # Description Item Part # Description Conversion Kit (Natural to LP) Convers[...]

16 WHA T IS COVERED This warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated and maintained in accordance with National and[...]