Aarrow Fires Sherborne Wood & Multifuel Stoves инструкция обслуживания

Arada Ltd The Fireworks Bridport Dorset, DT6 3BE Great Britain T el. (44) 01308 427234 Fax. (44) 01308 423441 www .aarrowfires.com Wood & Multifuel Stoves Operating & Installation Manual PLEASE RET AIN THESE INSTRUCTIONS FOR FUTURE REFERENCE Sherborne Medium Multifuel Stove Rev 2 Nov 2006 AFS1237 Sherborne[...]

Congratulations on your choice of an Aarrow Stove. More than 20 years experience has been put into the development of our Sherborne, range to ensure ultimate performance and years of trouble free enjoyment. Every detail on the stoves has been carefully engineered and designed which is why we are so confident in the reliability of our product that w[...]

INTRODUCTION Page Safety Notices 5 The Principle of the Fire 5 Check List 6 T echnical Data 7 OPERA TING INSTRUCTIONS Firebox Linings and Throat Plate Removal 8 Multifuel Grate 8 W ood Stove - W ood T ray 8 Air inlet Controls/Airwash System 8-9 Multi-Purpose Operating T ool 9 Fire Door Glass 9 Door Adjustment 10 Fuel Retainer Bars 10 Fitting the Fe[...]

W ARNING T O ALL MUL TIFUEL USERS PETROLEUM COKE SOME OF WHOSE BRAND NAMES ARE "CALCO", "PETROCOKE" OR "WONDERCO" MUST NOT BE BURNED IN THIS APPLIANCE T O USE THESE FUELS WILL INV ALIDA TE THE APPLIANCE GUARANTEE IF IN DOUBT CONT ACT THE SOLID FUEL ASSOCIA TION TELEPHONE NUMBER 0800 600 000 www .solidfuel.co.uk THE USE[...]

Sherborne Wood & Multifuel S toves 5 INTRODUCTION SAFETY A fireguard conforming to BS 8423: 2002 should be used in the presence of children and old/or infirm people. If the appliance is used with the fire door open, a spark guard conforming to BS 3248 should be fitted. Do not use aerosol sprays or any other flame near the appliance under fire. [...]

6 Sherborne Wood & Multifuel S toves CHECK LIST 1 1. Multifuel riddling kit optional accessory N/A 12. Instructions 1 10. W oodburning tray 1 optional accessory 7 Part Description & V isual Aid (not to scale) Sherborne Small Multifuel 2 1 4. Flue spigot 1 (5”) 5. Hotplate 7. Operating tool 1 8. Rear liner 2 9. Side liners 2 N/A Sherborne [...]

Sherborne Wood & Multifuel S toves 7 TECHNICAL DA T A Room Min/Max Room Heater Only Output (kW) 1.5 - 6 TECHNICAL DA T A Sherborne Small Multifuel Room Heater with Domestic Hot W ater with add in boiler type 8 Max Output to Room (kW) Max Output to W ater (kW) Height (mm) 505 W idth (mm) Depth (mm) Height to Centre of Rear Flue Depth from Back t[...]

FIREBOX LININGS & THROA T PLA TE The Sherborne range of W ood and Multifuel stoves firebox have reflective liners to the sides and rear and a specially shaped throat plate which sits on the liners. If these are not in place please refer to page 17 to install these. MUL TIFUEL GRA TE The Aarrow Multifuel grate comprises of a series of reciprocat[...]

Fig. 4b Lifting cover fr om body of stove Fig. 4c Unscrewing MUL TI - PURPOSE OPERA TING T OOL Y our Aarrow fire comes with a multi-purpose tool, which is used for riddling, setting the multifuel grate position. Use the operating tool for setting the grate in the coal burning position or the wood burning position. This lever is also used for de-ash[...]

DOOR ADJUSTMENT Once the appliance has been under fire for a period of time the fire door may appear to have moved out of alignment with relation to the door aperture. This is quite normal and due to the settling of the casing. The fire door can be re-aligned by the user as follows: •When the appliance is cold, open the fire door so that it is at[...]

FUEL TYPES W ood- Any type of wood is suitable provided it is well seasoned and has a moisture content below 20%. This usually implies that the timber has been suitably stored to allow moisture to evaporate for at least nine months in the case of soft woods, and at least eighteen months in the case of hard wood. W e recommend that for general burni[...]

ENSURE THA T YOU HA VE READ & UNDERSTOOD THESE INSTRUCTIONS BEFORE LIGHTING THE FIRE. AL W A YS WEAR SUIT ABLE PROTECTIVE FIRE GLOVES WHEN REFUELLING YOUR STOVE. SOLID FUEL BURNING •Set the grate to ‘coal’ position. •Ensure that the ash pan is in position and the fire doors are closed. •Set the air wash to one quarter open position. ?[...]

• Check for flue or chimney blockage, and clean if required. Seek expert advice fr om your HET AS r egistered installer . Do not attempt to re-light the fir e until the cause of the fume emission has been identified and corr ected. ASH REMOV AL - W ood burner only Ash will drop through the holes and to the slides of the specially designed wood tr[...]

Remove the firebricks lining and throat plate, inspect all gasketing on doors, glass etc., and re-order any items that may need replacing, from your Aarrow dealer . W ith a wire brush clean inside the appliance paying particular attention to the small inlet holes of the air wash on the inside, above the fire door and to the door . Sweep the chimney[...]

Sherborne Wood & Multifuel S toves 15 ACCESSORIES ACCESSORIES WOOD BURNING TRA YS T o turn your multifuel stove into a dedicated woodburner . As shown in Fig. 10a below MUL TIFUEL UPGRADE KIT A vailable for the wood burning range to enable you to burn solid fuel in your Sherborne woodburning stove. (See Fig. 10b) ADD IN BOILERS See page 24 for [...]

16 Sherborne Wood & Multifuel S toves INST ALLA TION GENERAL PRECAUTIONS Note - All installations must conform to the appropriate building regulations. The Building Regulations for England and W ales 2000 ref Approved Document J 2002 edition (issued by the DTLR). The Building Standards (Scotland) (Consolidation) Regulations. Detailed recommenda[...]

Sherborne Wood & Multifuel S toves 17 INST ALLA TION FIREBOX LINER P ANELS The Sherborne W ood and Multifuel stoves use reflective liners to the sides and back. The throat plate sits on top of the side and rear panels. These should come fitted to your fire, if however they are not proceed as follows to fit them. •Remove the front fuel bars. ?[...]

MUL TIFUEL GRA TE GRA TE The grates in the Sherborne Multifuel units comprise a series of reciprocating cast iron bars seated on a pivoted "comb". All bars in the grate are identical, but every other bar is turned through 180 degrees, with the ends of the bars marked "H" sit- ting on the high sections of the comb, and the ends m[...]

INTERCHANGEABLE CANOPIES The canopy versions for the Sherborne range are slab top stoves to which a low or high canopy can be fitted after installation and ar e interchangeable. These are fitted as follows: •T o fit the interchangeable canopy (Fig 10c): •Remove the front clamps. •T ilt the canopy as shown in stage 1. •Engage the rear clips [...]

20 Sherborne Wood & Multifuel S toves INST ALLA TION FITTING THE FLUE OUTLET AND HOT PLA TE The flue outlet spigot is found inside the appliance. The hot plate (blanking plate) is supplied fitted to the top opening and is removed by turning clockwise (as is the flue outlet). Smear a very thin layer of fire cement on the faces of the flue outlet[...]

Due to the gradual introduction of European Chimney Standards chimneys will be specified according to their performance designation as defined in BS EN 1443 that covers the General Requirements for chimneys. The minimum performance designation required for use with solid fuel burning stoves is T450 N2 S D3. The flue and chimney installation must be[...]

22 Sherborne Wood & Multifuel S toves INST ALLA TION[...]

Sherborne Wood & Multifuel S toves 23 INST ALLA TION P LAN V IEW OF REGISTER PLA TE AND CLEARANCES FOR NON INSULA TED FLUES T YPICAL M ET AL I NSULA TED C HIMNEY S YSTEM T O BE INST ALLED TO THE CHIMNEY MANUF ACTURERS INSTRUCTIONS IN COMPLIANCE WITH BUILDING REGULA TIONS AND BS7566 P TS 1-4 A is minimum clearance for non-insulated flue = 1.5 x [...]

24 Sherborne Wood & Multifuel S toves INST ALLA TION ADD IN BOILERS Sherborne W ood and Multifuel stoves offer the option of a slab boiler , which occupies the position of the rear firebox liner panels. Fitting: •Remove the fuel retainers, rear firebox liner panels and throat plate. •Knock out the blanking discs in the back plate correspond[...]

Sherborne Wood & Multifuel S toves 25 INST ALLA TION Primary flow and return pipes should be 28mm diameter . The cylinder should be installed at a higher level than the appliance, and as close to it as possible (the higher the cylinder the faster the circulation). The flow and return pipes should not be longer than 20ft each. Pipe runs should r[...]

26 Sherborne Wood & Multifuel S toves INST ALLA TION CHECKLIST Hearths, Fir eplaces, Flues and chimneys This checklist is to ensure hearths, fireplaces, flues and chimneys are satisfactory , and to show what you have done to comply with the requirements of The Building Regulations 2000 Approved Document J 2002. 1. Building address, where work h[...]

Sherborne Wood & Multifuel S toves 27 P AR TS LIST 1. Fuel Retainers AFS1 192 AFS1 192 AFS1191 AFS1019 AFS1019 AFS1020 N/A AFS001 N/A AFS009 AFS009 AFS009 AFS008 AFS008 AFS008 AFS058 AFS058 AFS051 AFS010 AFS010 AFS010 2. Throat Plate 3. Grate Bar Set 4. Hot Plate 5. Operating T ool 6. Ashpan 7. Flue Spigot Part Description V isual Aid (not to s[...]

28 Sherborne Wood & Multifuel S toves P AR TS LIST 8. Liner Set AFS1 156 AFS1 156 AFS1 163 AFS1058 AFS1058 AFS1 164 AFS1 157 AFS1 157 AFS1 165 AFS1009 AFS1009 AFS1095 AFS1010 AFS1010 AFS1010 AFS047 AFS047 AFS047 AFS1233 AFS1233 AFS1233 9. Side Liner 10. Back Liner Set 11 . Glass Replacement Kit Complete with Gasket 12. Glass Clips 13. Hinge kit[...]

Sherborne Wood & Multifuel S toves 29 P AR TS LIST 16. Fire Door Rope Kit Complete with Door Rope Glue. AFS1021 AFS1021 AFS1021 AFS1021 L/H AFS1234 R/H AFS1235 L/H AFS1234 R/H AFS1235 L/H AFS1238 R/H AFS1239 L/H AFS1238 R/H AFS1239 AFS1237 AFS1237 AFS1237 AFS1236 AFS1236 AFS1236 AFS1236 AFS1 197 SHBSW BTRA Y AFS1 198 SHBMW BTRA Y N/A SHBM MGRA [...]

Guarantee Once again we would like to thank you for buying a Sherborne fire. When you buy an Aarrow Fire, you are not only buying a first class appliance - you are buying a commitment from us to look after you and your appliance for as long as you want. The Sherborne Stoves come with a Lifetime Guarantee against splitting or cracking of the main bo[...]

Should you have any questions about your Sherborne W ood or Multifuel Stove that is not covered in this manual please contact your Aarrow retailer . Please keep all repair receipts safely . Please ensure you have this manual available when an engineer visits as they will complete the service record chart. Sherborne Wood & Multifuel S toves 31 S[...]

FINAL F ACTOR Y CHECK LIST BK046 QUALITY FINISH PA R T S FLUE OUTLET HOT PLA TE FUEL RET AINERS X2 GRA TE BARS / WOOD TRA Y FIREBOX LININGS THROA T PLA TE AIR W ASH DOOR CA TCH ASH P AN OPERA TING TOOL OPERA TING INSTRUCTIONS Model.................................. Serial No............................. I’ve checked it and it’ s O.K. Assembled [...]