United States Stove 58242 manual

USSC 1 Please read this entire manual before installation and use of this appliance. Failure to follow these instructions could result in property damage, bodily injury, or even death. Contact your local building or re ofcials about restrictions and installation inspection requirements in your area. Save these instructions.    Owner?[...]

2 USSC T ABLE OF CONTENTS .............................................................................................. 2 SAFETY PRECAUTIONS ........................................................................................... 3 SPECIFICA TIONS ..................................................................................................[...]

USSC 3 Safety Precautions IMP OR T ANT :  Read  this  ent ire  manu al before  ins tal ling an d op er at ing  th is p ro du ct.   Fa ilu re  to  do s o m ay result in property damage, bodily injury , or even death.  Properinstallationofthis stoveis?[...]

4 USSC Specications InputRating 38,500BTU/hr HeatOutput 1 30,000BTU/hr . Efciency 78% Heating Capacity 2 850sq.ft. Fuel Burn Rate 3 3.5lbs./hr .±5% BurnT ime(lowestsetting) 1 1-1/2hrs.±5% HopperCapacity 40lbs. Heating Specications Height 33-1/2in. Width 18-1/4in. Depth 19-1/4[...]

USSC 5 INST ALLA TION OPTIONS Read this entire manual before you install and use your pellet stove. Failure to follow instructions may result in property damage, bodily injury , or even death! (See specic installation details for clearances and other installation requirements) A  Freestanding Unit —Placed on a non-combustible ?[...]

6 USSC Installation CLEARANCES Y our Forester stove has been tested and listed for installation in residential, mobile home, and alcove applications in accordancewiththeclearancesgiveninFIGURES3-4andT ABLE1. NOTE: Distance “D” on the left-hand side of your Fores[...]

USSC 7 Installation VENTING REQUIREMENTS Install vent at clearances specied by the vent manufacturer . Do not connect the pellet vent to a vent serving any other appliance or stove. Do not install a ue damper in the exhaust venting system of this unit. Thefollowinginstallationguidelines mustbefollowedtoensure confor[...]

8 USSC Installation VENT TERMINA TION CLEARANCES: A) Minimum4-footclearancebeloworbesideanydoororwindowthatopens. B) Minimum1-footclearanceaboveanydoororwindowthatopens. C) Minimum3-footclearancefromanyadjacentbuilding. D) Minimum7-footclearancefrom?[...]

USSC 9 THROUGH THE W ALL INST ALLA TION (RECOMMENDEDINST ALLA TION) T o vent the unit through the wall, connect the pipe adapter tothe exhaustmotoradapter . Iftheexhaust adapteris at least 18-inches above ground level, a straight section of pelletvent[...]

10 USSC Installation OUTSIDE AIR SUPPL Y (optional,unlessinstallinginamobilehome) Dependingonyourlocationandhomeconstruction,outsideairmaybenecessaryforoptimalperformance. Metal pipe (solid or exible) must be used for the outside air installatio[...]

USSC 1 1 How your stove works Y our Forester stove utilizes a vertical auger fuel feed system that is operated by a microprocessor controlled digital circuit board. Thedigital circuitboard allows thevertical augerfuel feed systemto runin a ti[...]

12 USSC SHUT DOWN PROCEDURE Press the  button on the control pad to put the stove in shut down mode.  Once this is done, the auger will stop feedingpellets,butthedistributionblowerandexhaustblowerwillcontinuetooperate.Whenthein[...]

USSC 13 Maintenance Operation DAIL Y OPERA TION  The hopper and stove top will be hot during operation; therefore, you should always use some type of hand protection when refueling your stove.  Never place your hand near the auger while the stove is in operation. In the event of a power outage , the stove WILL NOT?[...]

14 USSC INTERIOR CHAMBERS Periodicallyremove andclean theburnpot andthe area insidethe burnpothousing. In particularit is advisableto clean outtheholesintheburnpottoremoveanybuildupthatmaypreventairfrommovingthroughtheburnpot?[...]

USSC 15 Trouble Shooting Disconnect the power cord before performing any maintenance! NOTE: Pressing the OFF button does not disconnect all power to the electrical components of the stove. Never try to repair or replace any part of the stove unless instructions for doing so are given in this manual. All other work should be done by a trained techni[...]

16 USSC Parts Diagram[...]

USSC 17 PARTS LIST Item Part No. Title Qty . 1 891603 DoorFrame Assy .(5824-05-01-00) 1  A  891604 DoorFrameWldmt(5824-05-00) 1  B 891605 NylonShim(5824-08-01) 1  C 891606 DoorHndleWldmt(5824-05-02-00) 1  D 88139 GlassGasket(5824-09-00) 1  E 881[...]

18 USSC Wiring Diagram[...]

USSC 19 Notes[...]

20 USSC THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPENDABLE SERVICE FROM YOUR FORESTER, AND ENABLE YOU TO ORDER REPAIR PARTS COR- RECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFERENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING IN[...]