United States Stove 5510 manual

USSC 1 1 1 2 2 3 3 4 4 A A B B TOLERANCES EXCEPT AS NOTED HOLES ` .005" DECIMAL .XX = 0.03 XXX = 0.010 ANGULAR ` 2 ~ DESCRIPTION FINISH REFERENCE SCALE DWN BY DATE SIZE REV TITLE NUMBER UN ITED STAT ES ST OVE CO MPA NY ESTABLISHED 1869 KING PELLET STOVE 5510 A B 5510 ASSEMBLY 1 OF 1 SHEET REVISION HISTORY REV DESCRIPTION DATE BY A 8/18/2008 Ki[...]

2 USSC T ABLE OF CONTENTS .............................................................................................. 2 SAFETY PRECAUTIONS ........................................................................................... 3 SPECIFICA TIONS ..................................................................................................[...]

USSC 3 Safety Precautions IMP OR T ANT :  Read  this  ent ire  manu al before  ins tal ling an d o pe ra ti ng  th is  pr od uc t.   Fa i lu re  to  do  so  ma y result in property damage, bodily injury , or even death.  Properinstallationofthis stove[...]

4 USSC Specications HeatOutput 1 48,000BTU/hr . Heating Capacity 2 800-2,000sq.ft. Fuel Burn Rate 3 2.0-6.0lbs./hr . BurnT ime(lowestsetting) 60hrs. HopperCapacity 150lbs.  Height 34 in. Width 26 in. Depth 25 in. Weight 250lbs.[...]

USSC 5 INST ALLA TION OPTIONS                  [...]

6 USSC Installation CLEARANCES Y our King stove has been tested and listed for installation in  residential, mobile home, and alcove applications in accordancewiththeclearancesgiveninFIGURES3-5andT ABLE1. NOTE: Distance “C” on the left-hand side of your King sto[...]

USSC 7 Installation VENTING REQUIREMENTS   ?[...]

8 USSC Installation VENT TERMINA TION CLEARANCES: A) Minimum4-footclearancebeloworbesideanydoororwindowthatopens. B) Minimum1-footclearanceaboveanydoororwindowthatopens. C) Minimum3-footclearancefromanyadjacentbuilding. D) Minimum7-footclearancefrom?[...]

USSC 9 Installation THROUGH THE W ALL INST ALLA TION (RECOMMENDEDINST ALLA TION) T o vent the unit through the wall, connect the pipe adapter tothe exhaustmotoradapter . Ifthe exhaustadapter isat least 18-inches above ground level, a straight section of [...]

10 USSC Installation OUTSIDE AIR SUPPL Y (optional) Dependingonyourlocationandhomeconstruction,outsideairmaybenecessaryforoptimalperformance. Metal pipe (solid or exible) must be used for the outside air installation.  PVC pipe is NOT approved?[...]

USSC 1 1 How your stove works Y our King stoveutilizesa inclinedaugerfuelfeedsystemthatisoperated byamicroprocessorcontrolleddigitalcircuit board.  The digitalcircuit boardallows theinclined augerfuel feedsystem torun ina timer-based,non-c[...]

12 USSC Control Panel Overview ON/OFF Pressing the“ON” button on thecontrol panel will beginthe start-up sequence forthe heater .  Fuelwill begin to feed throughtheaugerfeedsystemthenigniteafterapprox.5minutes. Pressing the “OFF” button?[...]

USSC 13 UNIT PREP ARA TION After care fully unpac king and readi ng the instruc tions for inst alling your  stove, you will need to perform the followin g steps: Attachtheincludedspringhandletothedoorhandlebyscrewingitoninarespectivelocation. Attac[...]

14 USSC SHUT DOWN PROCEDURE Pressthe “OFF” buttononthecontrolpad toputthestovein shutdownmode. Atthistime,the redlightabove thepad willilluminate.Oncethis isdone,theaugerwill stopfeedingpellets,but thedistributionblowerande[...]

USSC 15 Maintenance Operation DAIL Y OPERA TION             ?[...]

16 USSC INTERIOR CHAMBERS Periodicallyremove andclean theburnpot andthe area insidethe burnpothousing. In particularit is advisableto clean out the holes in the burnpot to remove any build up that may prevent air from moving through [...]

USSC 17 Trouble Shooting                     ?[...]

18 USSC Error Code Err1 Err2 Err3 Err4 Err5 Err6 Err7 Err8 Error Descrption Thehighlimittemperaturesensor hastripped. Stoveranoutoffuelduringnormal operation. The stove was unable to reach the  RoomFan Ontemperature withinthe startuptime. The power failed while?[...]

USSC 19 Parts Diagram 11 3 2 1 5 6 4 7 9 8 10 12 ViewingDoorDetail[...]

20 USSC PARTS LIST      1 69524 Door Assembly 1 2 891372 HingePad,Threaded 2 N/S 83045A  W asher ,3/8” 2 N/S 83274 3/8-16LockNut 2 3 25080 DoorLatch 1 4 891395 AshPanBed 1 N/S 83508 5/16-18[...]

USSC 21 Wiring Diagram GRAY BLACK[...]

22 USSC Notes[...]

USSC 23 Notes[...]

24 USSC THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPENDABLE SER- VICE FROM YOUR KING OR ASHLEY, AND ENABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFERENCE. WHEN WRITING, ALWAYS GIVE THE FULL MODEL NUMBER WHICH IS ON THE NAMEPLATE ATTACHED TO THE HEATER. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOW[...]