U-Line 2115R manual

Use and Car e Guide 2115R 2175R Refrigerat or Models: 2115R, 2175R ULIN_016357_30090.fm Page 1 Wednes d ay, February 7, 2007 12:40 PM[...]

2 2115R, 2175R Congratulation s on your purchase of a U-Line refrigeration prod uct. A pioneer in t he field fo r more than 40 years, U-Line Corporation is the world’ s numbe r one manufac turer of buil t -in, under -co unter , specialty refrige ration and i ce making products. U-Li ne dedicates 100 % of its research a nd deve lopm ent to these p[...]

2115R, 2175R 3 Introduction ...... ........... ........... ........... ................. ............ ........... ................. ........... ....... .... .........2 Warranty Registra tion ............... ............ ........... ................. ........... ........... ........... ...............2 Please Rec ord Your Model Information .........[...]

4 2115R, 2175R This page intentionally left blank[...]

2115R, 2175R 5 IMPORT ANT IMPORT ANT PLEASE READ all instructions completely before attempting to install, operate, or serv ice your unit. • Pro per installation procedur es must be followed if this unit is being initially installed, or is moved to a ne w lo cati on afte r bein g in serv ice . An INST ALLA TION GUIDE for your unit, pr oviding com[...]

6 2115R, 2175R Échelon Refrigerator Models 2115R, 2 175R Exclusive Featur es of Échelon • Model 2115R is a 3.3 cu ft (93 L) capacit y unit; M odel 2175R is a 5.7 cu ft (16 1 L) capacity u nit. • Both models qu alify for U.S. Government ENERGY ST AR program. • An electronic contro l panel with digital display allows you to display the in ter[...]

2115R, 2175R 7 Figure 2 IMPORT ANT IMPORT ANT Proper air flow (Figure 2) is required for your unit to operate at its highest efficiently . A grille, located in the base of the unit, must not be blocked at any time, or your unit will not perform as expected. Initial Startup All U-Line units are sh ipped with controls that are preset. No initial adju[...]

8 2115R, 2175R Interior Lighting The LIGHT icon (Figure 3, 5) on the con trol panel is used to control an additional lighting fu nction. The blackout/ Sabbath mode (not Star K certifie d) will turn the interior light and di s play (Figur e 3, 3) off fo r a preset 36-hour period. T o access th e blackou t/Sabbat h mode (no t Star K certified): 1. T [...]

2115R, 2175R 9 Normal Oper ating Sounds All models in corporate rigid foa m insulated cabi nets to provide hig h thermal efficien cy and m aximum soun d reduction for its interna l working compone nts. In spite of this technolo gy , your model ma y make sou nds that are unfami liar . Normal o peratin g sounds may b e more n oticeab le because of th[...]

10 2115R, 2175R General Cleaning Exterior Cleani ng (As Required) Black and White Models : • Surfaces may be cleaned with a mild dete rgent and warm water solution. Do not use solvent-based or abrasive cleaners. Use a so ft sponge and rinse with clean water . Wipe with a soft, clean to wel to prevent water spotting. Stainless Steel M odels: • S[...]

2115R, 2175R 11 T o de frost: 1. T urn unit off. 2. Remove all products from the interior and prop the door in an open position (2 in. (5 c m) minimum). 3. Allow the frost t o completely melt natural ly . Clean the interior and all removed components using a mild non- abrasive detergent and warm water solution applied with a soft sponge or non-abra[...]

12 2115R, 2175R Door Alignment Check and Adjustment IMPORT ANT IMPORT ANT When pr operly aligned: • The door will not be flush with the top of the cabinet. The top edge of the door will be 1/8 in. (3.175 mm) below the cabinet top. • The door gasket will be firmly in contact with the perimeter of the cabinet and not pinched on the hinge side of [...]

2115R, 2175R 13 Door Reversal Fig ure 16 Black a nd white units m ay be left- or rig ht-hand openin g. Stainless steel unit doors cann ot be reversed. T he doors are easily reversed by moving the hinge hardware to the opposite side. The top hinge hardware will b e used o n the bottom of the other side and the bottom hinge hardware will be u sed on [...]

14 2115R, 2175R 5. Remove the two do or closer inserts (Figure 20, 1) from the existing bottom hinge and install as shown on the new bottom hinge (Fi gur e 19, 1) . 6. Remove existing bottom hinge (three screws) and remount on oppos ite side TOP . Remove hinge screw pin. 7. Remove the plastic hole plug from the top of the door to allow the pivot pi[...]

2115R, 2175R 15 Glass Shelf Removal /Installati on Remove the shelves as follows: Fig ure 23 1. Pull shel f out ab out 6" (Fig ur e 23 , 1) until back of shelf clears the “hump ” on the right ha nd side. 2. T ilt right hand edge of shelf up (Figur e 23, 2) . 3. Remove shelf from unit by pulling out (Figure 23, 3) . Insert the shelves as fo[...]

16 2115R, 2175R Before Calling for Service If your U-Line produc t appears to be malfu nctioning, read through the OPERA TION section of this guid e to ensure that the functio n of all controls are c learly understood. If the malfunction persists, the TROUBLESHOOTING GUIDE in this guide will a ssist you in quickly id entifying comm on problems, and[...]

2115R, 2175R 17 T roubleshooting Guide DANGER ELECTROCUTION HA ZARD Never attempt to repair or perform maintenance on the unit until the main electrical power has bee n disconnected. NOTE: Recommended tempe rature setting is 38°F . T roubleshooting - What to check when pr oblems occur: PROBLE M POSSIBL E CAUSE REMEDY Unit does not operate and elec[...]

18 2115R, 2175R Electronic Contr ol Quick Guide NOTE: 38°F is an exam ple; the displa y will vary with actua l set-point. IMPORT ANT Factory recommende d set-point is 38°F for refrigerators and beverage centers, and 50°F for wine coolers. All M ode ls T ask T ouch T ouch Dis play Comme nt T urn ON/OFF Hold 10 secon ds Release when °F flashes. o[...]

2115R, 2175R 19 U-Line Cor poratio n Limi ted Warranty U-Line Corpo ration warrants each U-Line product to be free from defects in ma terials and workmanship for a pe riod of one year from the date of purchas e; and warrants the sealed system (consisting of the compressor , the condenser , the evaporator , the hot gas bypa ss valve, the dryer and t[...]

For General Inquiries: P .O. Box 245 040 Milwa ukee, W isconsin 53224-95 40 U.S.A. Phone (80 0) 779-2 547 F A X (414) 354-5696 www .U-Line.com For Service and Parts Assist anc e: Phone (80 0) 779-2 547 (414) 354-030 0 F A X (414) 354-5696 Ema il: OnLine Servi ce@U- Line .com www . U-LineS ervice. com E-mai l: OnlinePa rts@u-line.com For more than f[...]