RedMax EB6200 manual

The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. WARNING OWNER / OPERA T OR MANUAL BACKP ACK BLOWER 2750-93111 (903) EB6200  Thank you for purchasing a RedMax product. Before using our blower, please read this manual carefully to understand the pro[...]

Read this manual carefully to understand all safety precautions, controls, proper operation and maintenance of your RedMax blower . Failure to do so could result in serious injury . Instructions labeled as shown at left, concern critical steps or procedures which must be followed in order to prevent accidents which could lead to serious bodily inju[...]

CONTENTS SAFETY PRECAUTIONS · · · · · · · · · · · · · · · · · · · · · · · · · · · · · 2 OPERA T OR USE OF BLOWER WORKING CONDITION A VOID NOISE PROBLEM A VOID CHANCES OF DAMAGE P ARTS LOCA TION & SPECIFICA TIONS · · · · · · · · · · · · · · · · · 5 ASSEMBL Y · · · · · · · · · · · · · · [...]

• Read this Blower Owner/Operator Manual carefully. Be sure you understand how to operate this unit properly before you use it. Failure to do so could result in serious injury. • Be sure to keep this manual handy so that you may refer to it later whenever any questions arise. Also note that you are requested to contact the dealer from whom you [...]

• Never use the blower without the screen for the air intake of the blower. Before each use, check that the screen is attached in place and is free from any damage. • Never remove debris from the intake screen while the engine is running. Contact with rotating blower fan may result in a serious personal injury. • Do not allow children to use [...]

• Keep operation area clear of all persons, particularly small children and pets. Injury may result from flying debris. • Avoid using the blower where stable footing and balance are not assured. • Never to touch the spark plug or plug cord while the engine is in operation. Doing so may result in being subjected to an electrical shock. • Nev[...]

Parts Location & Specifications Assembly ■ BLOWER TUBES 1.Connect the blower and swivel joint with flexible hose. Clamp both ends of the flexible hose securely with the hardware supplied with the unit. 2.Align the protrusion and the groove provided on the tube ends and twist the tube until connection is locked up. MODEL EB6200 Dimensions ( L [...]

• Gasoline is very flammable. Avoid smoking or bringing any flame or sparks near fuel. Make sure to stop the engine and allow it cool before refueling the unit. Select outdoor bare ground for fueling and move at least 3m(10ft) away from the fueling stop before starting the engine. Or it could lead to a fire. ■ FUEL MIX Follow the instructions b[...]

■ CONTROL ARM 1.Hold the upper end of the control arm in hand and, while pulling it away from the unit, rotate arm forward (anti-clockwise as the arrow direction) until it clicks. To fold the arm, reverse the order. ■ STARTING ENGINE • Avoid operating the blower with the flexible tube and swivel joint disconnected. That will reduce the coolin[...]

■ FUEL FILTER • A clogged fuel filter may cause poor acceleration of the engine. Check periodically to see if the filter is clogged with dirt. The filter can be taken out of the fueling port using a small wire hook. Disconnect the filter assembly from the fuel pipe and unhook the retainer to disassemble it. Clean the components with gasoline. ?[...]

■ MUFFLER Pay close attention to the precautions below. Or it could cause an accident or a fire. • Inspect periodically, the muffler for loose fasteners, any damage or corrosion. If any sign of exhaust leakage is found, do not use the blower and have it repaired immediately. • Note that failing to do so may result in the engine catching on fi[...]

■ SHOULDER STRAP • If the shoulder strap is damaged it may break during use, thus causing the product to fall and resulting in personal injury. Follow the instructions below to replace the shoulder strap. • Pass the top end of the strap through the hanger, making the FLAPPED SIDE OUTSIDE. • Pull the end of the strap through the ring, on the[...]

Parts List NOTE : 1. Use KOMATSU ZENOAH genuine parts as specified in the parts list for repair and/or replacement. 2. KOMATSU ZENOAH does not warrant the machines, which have been damaged by the use of any parts other than those specified by the company. 3. When placing parts orders for repair and/or replacement, check if the model name and the se[...]

Parts List : EB6200 Fig.1 CARBURETOR COMPONENTS ❲ 12 ❳ Carburetor Ass’y P/NO. 2750-81000[...]

Fig.1 CARBURETOR COMPONENTS Key# Part Number Description Q'ty 1 1850-81450 Body ass’y 1 2 3306-81380 Screen 1 3 3356-81310 Valve 1 4 1850-81270 Spring 1 5 1850-81220 Screw 1 6 3310-81250 Pin 1 7 3310-81230 Lever 1 8 1850-81490 Body 1 9 1850-81520 Cover 1 10 1751-81510 Pump 1 11 5500-81160 Washer 1 12 1881-81140 Swivel 1 13 1751-81130 Ring 1 [...]

Parts List : EB6200 Fig.2 ENGINE GROUP ❲ 14 ❳[...]

EB6200 Fig.2 ENGINE GROUP Key# Part Number Description Q'ty 1 2750-12110 Cylinder 1 2 2750-12210 Gasket, base 1 3 2750-12130 Bolt 4 4 1484-13160 Insulator 1 5 2750-13130 Gasket 1 6 1460-13132 Gasket 1 7 0263-90535 Screw 2 8 2750-12510 Cover 1 9 2750-12520 Bolt 2 10 2756-15100 Muffler ass’y 1 11 1421-15120 Arrester 1 12 2750-15210 Gasket 1 13[...]

Fig.3 BLOWER GROUP ❲ 16 ❳ Parts List : EB6200[...]

EB6200 Fig.3 BLOWER GROUP Key# Part Number Description Q'ty 1 2750-31110 Volute case 1 2 2750-31210 Volute cover 1 3 2750-31150 Screw 9 4 3490-11150 Elbow 1 5 07000-02095 O-Ring 1 6 2750-31420 Screw 2 7 3310-53331 Nut 2 8 2750-31310 Cover lnlet 1 9 2750-31150 Screw 3 10 1140-72231 Clamp 1 11 3407-16120 Screw 1 12 2750-31290 Tube 1 13 2750-3151[...]

THE CALIFORNIA AIR RESOURCES BOARD AND KOMATSU ZENOAH Co. ARE PLEASED TO EXPLAIN THE EMISSION CONTROL SYSTEM WARRANTY ON YOUR 1995 AND LATER LAWN AND GARDEN EQUIPMENT ENGINE. IN CALIFORNIA, NEW UTILITY AND LAWN AND GARDEN EQUIPMENT ENGINES MUST BE DESIGNED, BUILT AND EQUIPPED TO MEET THE STATE'S STRINGENT ANTI-SMOG STANDARDS. KOMATSU ZENOAH Co[...]

EMISSION-RELATED PARTS, FOR TWO (2) YEARS FROM THE DATE OF ORIGINAL DELIVERY OF THE MODEL EB6200 UNIT, KOMATSU ZENOAH AMERICA INC. (THE COMPANY), THROUGH ANY RedMax DEALER, WILL REPAIR OR REPLACE, FREE OF CHARGE, FOR THE ORIGINAL AND EACH SUBSEQUENT PURCHASER, ANY PART OR PARTS FOUND TO BE DEFECTIVE IN MATERIAL AND/OR WORKMANSHIP. EMISSION-RELATED [...]

KOMA TSU ZENOAH AMERICA INC. 1505 Pavilion Place Suite A Norcross, Georgia 30093 [...]