Proline PLZIGL5 manual

Range Hoods For model numbers: PLZI697 / PLZW697 / PLZIGL1 / PLZIGL2 / PLZIGL5 / PLZIGL6 / PLZIGL7 / PLZIGL9 / PLZIGS1 / PLZIGS2 / PLZIKE2 / PLZWKB / PLZWKF / PLZWKL2 / PLZWKE / PLZW544 user manual pro line[...]

Dear Valued Customer, Congratulations on your recent purchase of a new PROLINE range hood! To use your hood to its maximum potential, familiarize yourself with the controls and features of your new hood. This manual will step you through the installation of your hood, and how to maintain it. Read and use this care manual thoroughly, beginning with [...]

Table of Contents 1 Saftey Notice 1 2 Diagrams 2-7 Wall Hood . . . . . . . . . . . . . . . . 2 Control Panel . . . . . . . . . . . . . . . 3 Filters . . . . . . . . . . . . . . . . 4-5 Venting . . . . . . . . . . . . . . . . 6-7 3 Installation 8-15 Preparation . . . . . . . . . . . . . . 8 Wall Hood . . . . . . . . . . . . . . 9-11 Island Hood . . [...]

Installer: Leave this guide with the homeowner. Consumer: Keep this guide for future reference. The Important Safety Notice and warnings in this manual are not meant to cover all possible problems and situations that can occur. Use common sense and caution when installing, maintaining or operating this or any other appliance. Always contact the PRO[...]

warning ♦ If you receive a damaged product, immediately contact PROLINE Customer Support. Do not install or use a damaged hood. ♦ Do not install, repair or replace any part of the range hood unless specifically recommend- ed in the literature accompanying it. ♦ Use the range hood only for its intended purpose as outlined in this manual. DO NO[...]

2 | PROLINE ranGe HooDs Wall or Island Hood A - HOOD - directs heat and smoke into the hood’s internal blower system. The blower forces heat and smoke from cooking into the chimney. B - CHIMNEY - vents air from cooking to the outside of the home. C - CONTROL PANEL - controls the hood’s various features. D - FILTER(S) - prevent grease and grime [...]

User manU al | 3 Control Panel Power: Powers ON/OFF the range hood and activate power-off delay timer. To adjust the power-off timer: ♦ Turn on the hood at any speed ♦ Press the Power-Off Delay button to enter timer mode ♦ a “3” will flash in the display ♦ Power-off to begin countdown. ♦ When the timer reaches zero, the blower will tu[...]

4 | PROLINE ranGe HooDs grease filters bafe lter To remove the aluminum filter, pull the spring loaded handle back toward the wall and down aluminum lter The baffle filter is equipped with a spring loaded handle. To remove from the hood, pull back toward the wall and down. The baffle filter can also be opened for easy cleaning. To open uns[...]

User manU al | 5 1. Remove the stainless steel or aluminum filters from the bottom of the hood. 2. Locate the existing raised support screws (A) on each side of the internal motor(s). 3. For each motor side, position charcoal filter over its support screw and rotate to lock into place. charcoal lter We recommend venting your hood directly outdoo[...]

6 | PROLINE ranGe HooDs venting options horizontal wall venting Option 1 Option 2 vertical roof venting[...]

User manU al | 7 height & venting requirements ♦ allow 28-36” between the top of your cooking surface and the bottom of hood ♦ vent vertically through the roof if possible ♦ vent through a side wall if you can- not vent directly above your range hood ♦ use 6” or 8” round (or 3-1/4 x 10” rectangular) metal ducting ♦ use as few [...]

8 | PROLINE ranGe HooDs preparation inspect range hood 1. Check contents of box: ♦ range hood ♦ wall or ceiling mounting bracket ♦ small bag of hardware ♦ chimney (only on certain models) ♦ support brackets (only on certain models) ♦ transition duct (only on certain models) 2. Test ♦ plug in and test controls, lights, fan ♦ inspect [...]

User manU al | 9 Plan where the ductwork will be located. Install proper-sized duct work, and roof or wall cap, depending on where you will be venting your hood. Recommended and most com- mon installations are shown in the venting diagrams above. Adjust your measurements to accomodate heights of ceilings, cabinets, or rangetops. wall hood installat[...]

10 | PROLINE ranGe HooDs step 3 wall hood installation Hang hood and connect step 2 Install ceiling bracket ♦ Place the chimney bracket against the ceiling ♦ Find the center point of the bracket and mark it ♦ Line the bracket center point with the center point on the wall ♦ Mark the locations of bracket holes on wall ♦ Drill holes into th[...]

User manU al | 11 wall hood installation step 5 Install grease filter step 4 Install chimney ♦ Take off protective laminate coating ♦ Place the chimney on top of range hood base ♦ Make sure the chimney is facing the correct direction (the vertical vent should be on the top) ♦ Secure the lower portion of the chimney to the base of the hood ?[...]

12 | PROLINE ranGe HooDs island hood installation step 1 step 2 step 3 ♦ place brackets vertically inside the 4 corners of the ceiling bracket ♦ extend the brackets to the appropri- ate length. (the bottom of the hood should be 28”-36” above the cooktop) ♦ screw all support brackets to the ceil- ing mounting bracket Mark ceiling ♦ find [...]

User manU al | 13 step 4 step 5 step 6 island hood installation Install Chimney ♦ slide inner chimney sleeve over support brackets, covering the ceiling bracket ♦ screw into place at the top of ceiling bracket ♦ slide outer chimney sleeve to the bottom portion of the chimney ♦ adjust until the bottom chimney sleeve comes a few inches from t[...]

14 | PROLINE ranGe HooDs hood insert installation step 1 Mark the leveling point of the hood. Position two mounting screws on the wall leaving 1/8” space between the wall and your hood. If you are installing under a cabinet, the hood should be flush with the front of the cabinet. Make sure you mount the hood on wall studs or lumbars for secure pl[...]

User manU al | 15 hood insert installation step 4 step 5 step 6 Align hood-mounting bracket to the screws on the wall and hook hood into place. Additional mount- ing fasteners may be used to further secure your hood. Use 6” or 8” round steel pipe to connect the exhaust on the hood to the ductwork above. Use silver tape or duct tape to make all [...]

16 | PROLINE ranGe HooDs Care & Cleaning warning ♦ Never put your hand into the area housing the fan while the fan is operating ♦ Turn off power to the hood before cleaning ♦ Make sure your cooktop and hood are cool before cleaning ♦ Use only the types of cleaning solutions mentioned in this manual ♦ Completely dry the filter(s) immed[...]

User manU al | 17 17 | PROLINE ranGe HooDs replacing the light bulb ♦ Make sure the range hood is unplugged or turn OFF breaker ♦ Place a flat-head screwdriver between light cover and housing to remove cover ♦ Gently pull defective bulb straight out and discard ♦ Wear a cotton glove or use a cloth to handle the replacement bulb (DO NOT hand[...]

18 | troubleshooting NOTHING WORKS (Control Panel not lit, Blower not working) Solution 1: Turn on power at circuit breaker panel or fuse box. Check for tripped breaker or blown fuse. Solution 2: Make sure hood main power switch is on. LIGHTS NOT TURNING ON Solution 1: see “nothing works” Solution 2: Swap out lights to determine if bulbs are de[...]

User manU al | 19 Warranty All PROLINE range hoods come with a Two Year Warranty on Parts, and a One Year Warranty on Labor. Who is Covered: Only the original purchaser for residential products purchased in the continental United States (limited warranty in Canada, Hawaii, and Alaska). Two Year Warranty - Parts & Labor For two years from the da[...]

20 | PROLINE ranGe HooDs Returns 1. You must report damage directly to PROLINE within 7 days to receive a full refund. 2. Send a photo showing the damage. We need this before we can approve your damage claim. 3. Once your claim is approved, we will arrange for a damage pickup. 4. A new replacement hood will be sent to you after the damaged hood has[...]

return claims not accepted if: ♦ Hood has been installed ♦ Hood has been custom cut or otherwise altered ♦ Damage is reported after 7 days ♦ Original packaging or parts are missing exchanges 1. You must request an exchange directly to PROLINE within 14 days. 2. Notify us of your reason for the exchange. Provide a photo if your hood is damag[...]

PRO LINE Range Hoods 1750 S 500 W Salt Lake City, UT 84115 • 1-877-901-5530 • www.prolinerangehoods.com[...]