Husqvarna TS200FR manual

O WNER’S MANU AL 169689 Re v . 2 4.11.03 TR Printed in U .S.A. 8 H.P . 30" (76,2 cm) SLEEVE HITCH TILLER A TT A CHMENT MODEL NUMBER TS200FR 02480 TS 20[...]

2 SAFETY R ULES Safe Operation Practices f or Tiller Attachments. TRAINING • Read the operating and service instruction manual care fully . Be thoroughly familiar with the controls and the proper use of the equipment. Know how to stop the unit and disengage the controls quickly . • Nev er allo w children to operate the equipment. Nev er allow a[...]

3 GASOLINE CAP ACITY : 1 GALLON (3,6L) UNLEADED REG U LAR OIL : SAE30W (ABO VE 32°F/0°C) (CAP ACITY : 24 OZ. [0.7L]) 5W-30 (BELO W 32°F/0°C) TRANSMISSION OIL : SAE 30W (CAP ACITY : 40 OZ. [1,2L]) SP ARK PLUG : CHAMPION (GAP: .030" [0.76MM]) RJ19LM PRODUCT SPECIFICA TIONS CUST OMER RESPONSIBILITIES • Read and obser v e the saf ety rules. [...]

4 ASSEMBL Y When R.H., (Right Hand) or L.H. (Left Hand) are used, it means from a position behind the steering wheel as If you were seated on the tractor seat and f acing f orw ard. NO TE: Remov e mo wer dec k from tractor bef ore mounting tiller attachment. • Remov e tiller and bag of par ts from car ton. Place tiller on le vel g round so that t[...]

5 OPERA TION FIG. 3 IMPORT ANT : READ THE “R ULES FOR SAFE OP ER A TION” CAREFULL Y BEFORE OPERA TING Y OUR TILLER A TT ACHMENT . HO W T O USE Y OUR TILLER ST OPPING (See Fig. 3) TINES • Mov e tine clutch le v er to “DISENGA GED” position. ENGINE • Mov e engine throttle le v er to “ST OP” position. • Ne ver use chok e to stop engi[...]

6 OPERA TION NO TE: If at a high altitude (Abov e 3000 f eet) or in cold temperatures (below 32°F), the carb uretor fuel mixture ma y need to be adjusted f or best engine perf or mance. See “T O ADJUST CARBURET OR” in the Ser vice and Ad just ments section of this manual. TILLING The most effi cient tillage is obtained when tiller engine is o[...]

7 CUST OMER RESPONSIBILITIES GENERAL RECOMMEND A TIONS The warr anty on this attachment does not cov er items that hav e been subjected to operator ab use or negligence . T o receive full v alue from the w arranty , operator must main tain unit as instructed in this manual. Some adjustments will need to be made periodically to properly maintain you[...]

8 CUST OMER RESPONSIBILITIES T O CHANGE ENGINE OIL (See Figs. 6 and 7) Deter mine temperature r ange e xpected bef ore oil change. All oil must meet API service classifi cation SF or SG. • Be sure tiller engine is le vel. • Oil will drain more freely when warm. • Catch oil in a suitable container . • Remov e drain plug. • Tip tiller f or[...]

9 CUST OMER RESPONSIBILITIES COOLING SYSTEM (See Fig. 9) Y our engine is air cooled. For proper engine perf ormance and long lif e keep y our engine clean. • Clean air screen frequently using a stiff bristled brush. • Remov e b lower housing and clean as necessary . • K eep cylinder fi ns free of dir t and chaff . MUFFLER Do not operate till[...]

10 SER VICE AND ADJUSTMENTS CA UTION: Disconnect spark plug wires from spark plug and place wire where it cannot come into contact with plug. TILLER T O ADJUST GA UGE WHEELS See “T O ADJUST TILLING DEPTH” in Oper ation section of this manual. T O ADJUST BEL T (See Fig. 10) The clutch is a belt-tightener type. Belt should be just tight enough to[...]

11 SER VICE AND ADJUSTMENTS IDLE RPM ADJUSTMENT - • With engine at idle speed, tur n the idle adjust screw slowly countercloc kwise until the engine begins to f alter . • Then raise the engine speed by turning the idle ad- just screw cloc kwise until the engine holds a smooth con stant speed. A CCELERA TION TEST - • Mov e throttle control le [...]

12 Immediately prepare your tiller f or stor age at the end of the season or if the unit will not be used f or 30 da ys or more. CA UTION: Never store the tiller with gasoline in the tank inside a build ing where fumes may reac h an open fl ame or spark. Allow the engine to cool before storing in an y en clo sure. TILLER • Clean entire tiller (S[...]

13 Will not star t 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly . 2. See “T O ST ART ENGINE” in Operation section. 3. Engine fl ooded. 3. W ait se veral min utes bef ore attempting to star t. 4. Dir ty air cleaner . 4. Replace air cleaner car tridge. 5. W ater in fuel. 5. Drain fuel tank and carburetor , and refi ll [...]

14 REP AIR P AR TS 8 HP TILLER A TT A CHMENT - - MODEL NUMBER TS200FR ENGINE AND TINES[...]

15 KEY P ART DESCRIPTION NO . NO . REP AIR P AR TS 8 HP TILLER A TT A CHMENT - - MODEL NUMBER TS200FR ENGINE AND TINES KEY P ART DESCRIPTION NO . NO . 1 124533X Control Throttle 2 6924J Brac k et, Throttle Control 3 677A860 Hitch Y ok e Assembly 4 4379H Grip , Handle 5 677A855 Hitch Channel Assembly 6 6922R Plate , Adapter 7 - - - - - - - Engine 8 [...]

16 REP AIR P AR TS 8 HP TILLER A TT A CHMENT - - MODEL NUMBER TS200FR TRANSMISSION AND GA UGE WHEELS[...]

17 REP AIR P AR TS 8 HP TILLER A TT A CHMENT - - MODEL NUMBER TS200FR TRANSMISSION AND GA UGE WHEELS 1 634A562 T ransmission 2 9135R Retainer Spr ing 3 4929H Dr illed P an Head Riv et 3/8 x 1-3/4 4 634A61 Gauge Wheel Slee v e and Brac kets 5 634A559 Gauge Wheel Adjusting Shaft and Brac ket 6 169374 Wheel 7 4898H Shoulder Bolt 9 73560600 Locknut 3/8[...]

02480[...]