Husqvarna 7021P manual

Owner’s Manual / 96133000700 / 2009-01 532 42 54-61 1 1.24.08 BY Printed in U.S.A. 7021P[...]

2 W ARNING: Battery posts, terminals and related ac ces so ries contain lead and lead compounds, chemicals known to the State of Cal i for nia to cause can cer and birth defects or oth er re pro duc tive harm. W ash hands after handling. W ARNING: Engine exhaust, some of its con stit u ents, and certain vehicle com po - nents contain or emit chem i[...]

3 CONGRA TULA TIONS on your purchase of a new lawn mower . It has been designed, engineered and man u fac tured to give you the best possible dependability and performance. Should you experience any problem you cannot easily remedy , please contact your nearest authorized service center . We have competent, well-trained tech ni cians and the proper[...]

4 ASSEMBL Y Read these instructions and this man u al in its entirety before you attempt to assemble or operate your new lawn mow er . IMPORT ANT : THIS LA WN MOWER IS SHIPPED WITH OUT OIL OR GASOLINE IN THE ENGINE. Y our new lawn mower has been as sem bled at the factory with the ex cep tion of those parts left unassembled for shipping purposes. A[...]

5 KNOW YOUR LA WN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERA TING YOUR LA WN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. MEETS CPSC SAFETY REQUIREMENTS Our rotary walk-behind power lawn mowers confor[...]

6 TO CONVERT MOWER Y our lawn mower was shipped ready to be used as a mulcher . T o convert to bagging or discharging: REAR BAGGING (See Fig. 4) • Lift rear door of the lawn mower and place the grass catcher frame hooks onto the door pivot pins. • T o convert to mulching or dis charg ing operation, remove grass catch er and close rear door. FIG[...]

7 SIMPLE STEPS TO REMEMBER WHEN CONVERTING YOUR LA WN MOWER: FOR MULCHING - 1. Rear door closed. 2. Mulcher door closed. FOR REAR BAGGING - 1. Grass catcher installed. 2. Mulcher door closed. FOR SIDE DISCHARGING - 1. Rear door closed. 2. Discharge defl ector installed. CAUTION: Do not run your lawn mower with out rear door closed or ap proved gra[...]

8 MOWING TIPS CAUTION: Do not use de-thatcher blade attachments on your mower . Such at- tachments are hazardous, will damage your mower and could void your warranty . • Under certain conditions, such as very tall grass, it may be necessary to raise the height of cut to reduce pushing effort and to keep from overloading the engine and leaving clu[...]

9 Check f or Loose F asteners Clean / Inspect Grass Catcher * Check Tires Check Driv e Wheels *** Clean Lawn Mo wer **** Clean under Drive Co v er *** Check Driv e Belt / Pulle ys *** Check / Sharpen / Replace Blade Lubrication Clean and Recharge Batter y ** Check Engine Oil le vel Change Engine Oil Clean Air Filter Inspect Muffler Replace Spark Pl[...]

10 LA WN MOWER Always observe safety rules when performing main te nance. TIRES • Keep tires free of gasoline, oil, or insect control chem- i cals which can harm rubber . • Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage. BLADE CARE For best results, mower blade must be kept sharp. Re place bent or da[...]

11 AIR FIL TER (See Fig. 13) Y our engine will not run properly and may be damaged by using a dirty air fi lter. Replace the air fi lter every 100 hours of operation or every season, whichever occurs fi rst. Ser vice air cleaner more often under dusty conditions. TO CLEAN AIR FIL TER 1. Remove cover . 2. Carefully remove cartridge. 3. Clean by g[...]

12 MOWING POSITION MOWING POSITION HIGH POSITION LOW POSITION HANDLE BRACKET HAIRPIN COTTER MOUNTING PIN FIG. 15 LA WN MOWER TO ADJUST CUTTING HEIGHT See “TO ADJUST CUTTING HEIGHT” in the Operation section of this manual. REAR DEFLECTOR The rear defl ector , attached between the rear wheels of your mower , is provided to minimize the possibili[...]

13 LA WN MOWER When lawn mower is to be stored for a period of time, clean it thoroughly , remove all dirt, grease, leaves, etc. Store in a clean, dry area. 1. Clean entire lawn mower (See “CLEANING” in the Maintenance section of this manual). 2. Lubricate as shown in the Maintenance section of this manual. 3. Be sure that all nuts, bolts, scre[...]

14 Does not start 1. Dirty air fi lter . 1. Clean/replace air fi lter . 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty fuel tank and refi ll tank with fresh, clean gas oline. 4. Water in fuel. 4. Empty fuel tank and r efi ll tank with fresh, clean gas oline. 5. Spark plug wire is disconnected. 5. Connect wire to plug. 6. Bad spark p[...]

15 SER VICE NOTES[...]

16 ROT AR Y LA WN MOWER - - MODEL NUMBER 7021P (96133000700) PRODUCT NUMBER 961 33 00-07[...]

17 ROT AR Y LA WN MOWER - - MODEL NUMBER 7021P (96133000700) PRODUCT NUMBER 961 33 00-07 KEY P ART NO. NO. DESCRIPTION 1 532 40 29-49 Control Bar 2 532 19 78-08 Upper Handle (Includes Foam Grip) 3 532 17 41-10 Lower Handle 4 532 19 47-88 Rope Guide 5 532 13 20-04 Locknut, Hex 1/4-20 6 532 19 15-74 Handle Bolt 7 532 06 64-26 Wire Tie 8 874 78 05-12 [...]

RET AILER W ARRANTY POLICY & PROCEDURE MANU AL EFFECTIVE JANU AR Y 1, 2009 SECTION 1: LIMITED WARRANTY Husqvarna Professional Products, Inc (“Husqvarna”) warrants the original purchaser the Husqvarna branded product to which this warranty apply (the “Product”) that the Product shall be free from defects in material and workmanship from [...]

RET AILER W ARRANTY POLICY & PROCEDURE MANU AL EFFECTIVE JANU AR Y 1, 2009 † Refer to Section 3 for items not covered by this warranty *All consumer product use must have been limited to the owner s residence. Warranted for noncommercial, nonprofessional, noninstitutional and nonincome producing use. **HUV 2 Year or 2,000 Hour Powertrain (The[...]