Enviro Mini A manual

PELLET ST OVE Mini A SHERWOOD INDUSTRIES IS AN ENVIRONMENT ALL Y RESPONSIBLE COMP ANY . THIS MANUAL IS PRINTED ON RECYCLED P APER. PLEA SE KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE O WNER ’S MANU AL 50-1927 PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLATION AND USE OF THIS PELLET BURNING ROOM HEATER. FAILURE TO FOLLOW THESE INSTRUCTIONS COULD [...]

T able of Contents 2 Introduction............................................................... ....................................3 Rating Label Location...........................................................................3 P ellet Quality .......................................................................................3 Important Sa[...]

3 Introduction * This manual is designed for the home owner in conjunction with the technical manual. * R ATING L ABEL L OCATION : The rating label is located on the back of the ash pan co ver . P ELLET Q UALITY : Pellet quality is important, please read the following: Your enviro pellet stove has been designed to burn wood pellets only. Do not use[...]

4 Introduction I MPORTANT S AFETY D ATA : Please read this entire Owner’s Manual before installing or operating your ENVIRO Pellet Stove. Failure to follow these instructions may result in property damage, bodily injury or even death. Contact your local building or fire official to obtain a permi t and any information on installation restrictions[...]

5 Introduction of ashes should be on a non-combustible floor on the ground, wel l away from all combustible materials pending final disposal. If the ashes are disposed of by burial in soil or otherwise locally dispensed, they should be retained in the closed container until all cinders hav e been thoroughly cooled. ELECTRICAL: The use of a surge pr[...]

15 1 / 4 " (386 mm) 19" (483 mm) 17 1 / 2 " (444 mm) 19 1 / 2 " (496 mm) 17 7 / 8 " (455 mm) 34 1 / 8 " (868 mm) 19 3 / 4 " (503 mm) 24 7 / 8 " (632 mm) ROOMAIR FANON/OFF ON/OFF FEEDRATE TRIM COMBUSTION BLOWERTRIM HEATLEVEL AUTO/OFF HIGH/LOW MANUAL AUGER MODE 6 Specifications D IMENSIONS AND S PECIFICATIONS :[...]

7 Oper a ting Instructions C ONTROL B OARD F UNCTIONS : 1. AUGER LIGHT: This green light will flash in conjunction with the auger pulse. 2. MODE LIGHT: Responsible for signaling the state of the control board. When the light is flashing the stove is in an automatic start mode or the thermostat has control of the unit. When the light is solid, the H[...]

8 Figure 3: Thermostat Switch in MANUAL position. Figure 4: Thermostat Switch in HIGH/LOW position. ROOM AIR FAN ON/OFF ON/OFF FEED RATE TRIM COMBUSTION BLOWER TRIM HEAT LEVEL AUTO/OFF HIGH/LOW MANUAL AUGER C-11625 MODE ROOM AIR FAN ON/OFF ON/OFF FEED RATE TRIM COMBUSTION BLOWER TRIM HEAT LEVEL AUTO/OFF HIGH/LOW MANUAL AUGER C-11625 MODE 1 2 3 4 5 [...]

9 Figure 6: Slider/Damper Adjustment Knob. Figure 7: Efficient Flame. Oper a ting Instructions S LIDER /D AMPER S ET -U P : THE SLIDER / DAMPER MUST BE SET AT TIME OF INSTALLATION. This is used to regulate the airflow through the pellet stove. If , after long periods of burning, the fire builds up and overflows the burn pot or there is a build up o[...]

10 2-3 Days / Weekly Semi-annually or 2 T ons of Fuel Burn Pot and Liner Exhaust V ent Heat Exchanger T ubes Air Intake Ash Pan Blower Mechanisms Door Glass Heat Exchanger T ubes Inside Firebox Behind Firebox Liners & Covers Ash Pan and Door Gaskets All Hinges Door Latch Post Season Clean-up R outine Cleaning and Maintenance The following list [...]

EXHAUST PASSAGES (semi-annually) T o prevent build up of fly -ash all the exhaust passages must be cleaned and vacuumed. R outine Cleaning and Maintenance If the glass has build up that can not be removed with only the cloth, clean the glass using paper towel and a gas appliance glass cleaner , this ma y be purchased through most dealers. If a gas [...]

R outine Cleaning and Maintenance Remo val of the firebox backing. • Open the door by lifting the handle, remove the burn pot and burn pot liner . • Lubricate all screws with penetrating oil. • Remov e the four (4) screws that hold the side panels in place. • With the tip of a flat screwdriver , gently lift up the side panels and remove the[...]

13 W arr anty Sherwood Industries Ltd. is the manufacturer of the Enviro line of heating products. At Sherwood Industries, our commitment to the highest lev el of quality and customer service is the most important thing we do. Each Enviro stove is buil t on a tradition of using only the finest materials and is backed by our Exclusive Lifetime Limit[...]

W arr anty 14 Exclusions and Limitations: 1. This W arranty does not co ver tarnish, discoloration or wear on the plating or paint. 2. This W arranty ex cludes wear and tear or breakage caused by cleaning, moving or service on log set. 3. A qualified installer must install this stove or fireplace. This Limited W arranty cov ers defects in materials[...]

17 . Damage to plated surfaces caused by fingerprints, scr atches, melted items, or other external scores and residues left on the plated surfaces fr om the use of abrasive cleaners or polishes is not cov ered in this warr anty . 18. The Limited W arranty does not co ver tarnish, discoloration or wear on the plated surf aces. 19. The paint on the M[...]

16 NAME OF OWNER: _________________________________________ ADDRESS: _________________________________________ _________________________________________ _________________________________________ PHONE:___________________________________ NAME OF DEALER: _________________________________________ ADDRESS: _________________________________________ ____[...]