Electrolux EHG 641 manual

instruction booklet gas hobs EHG 641 EHG 6402 EHG 6412 EHG 6832 GB[...]

2 electrolux[...]

electrolux 3 Welcome to the world of Electrolux Welcome to the world of Electrolux Welcome to the world of Electrolux Welcome to the world of Electrolux Welcome to the world of Electrolux Thank you for choosing a first class product from Electrolux, which hopefully will provide you with lots of pleasure in the future. The Electrolux ambition is to [...]

4 electrolux Contents Contents Contents Contents Contents Important Safety Information Important Safety Information Important Safety Information Important Safety Information Important Safety Information ......................................................... ......................................................... ...............................[...]

electrolux 5 Important Safety Information Important Safety Information Important Safety Information Important Safety Information Important Safety Information Y Y Y Y Y ou MUST r ou MUST r ou MUST r ou MUST r ou MUST r ead these war ead these war ead these war ead these war ead these war nings car nings car nings car nings car nings car efully befor[...]

6 electrolux z Ensure the control knobs are in the ‘OFF’ position when not in use. z When using other electrical appliances, ensure the cable does not come into contact with the hot surfaces of the cooking appliance. z Unstable or misshapen pans should not be used on the hob as unstable pans can cause an accident by tipping or spillage. z Never[...]

electrolux 7 1 . Hob T op 2 . Semi-rapid Burner 3 . Rapid Burner 4 . Auxiliary Burner 5 . T riple Crown Burner 6 . Control knob for front left burner (semi-rapid) 7 . Control knob for back left burner (semi-rapid) 8 . Control knob for back right burner (triple crown/rapid) 9 . Control knob for front right burner (auxiliary) Description of the Hob D[...]

8 electrolux INSTALLATION Any gas installation must be carried out by a registered Any gas installation must be carried out by a registered Any gas installation must be carried out by a registered Any gas installation must be carried out by a registered Any gas installation must be carried out by a registered competent person, and in accordance wit[...]

electrolux 9 Hob burners control knobs Hob burners control knobs Hob burners control knobs Hob burners control knobs Hob burners control knobs The symbols on the knobs mean that : there is no gas supply there is maximum gas supply there is minimum gas supply Lighting the burners Lighting the burners Lighting the burners Lighting the burners Lightin[...]

10 electrolux push the relevant knob down and turn it anti-clockwise until it reaches the “maximum” position. Do not keep the control knob pressed for more than 15 seconds. If the burner does not light even after 15 seconds, release the control knob, turn it the "off" position ( ) and wait for at least one minute before trying to ligh[...]

electrolux 11 Burner minimum maximum diameter diameter Triple crown 180 mm 260 mm Large (rapid) 180 mm 260 mm Medium (semi-rapid) rear 120 mm 220 mm front 120 mm 180 mm Small (auxiliary) 80 mm 160 mm As soon as a liquid starts boiling, turn down the flame so that it will barely keep the liquid simmering. Use only pans or pots with flat bottom. Use [...]

12 electrolux Before any maintenance or cleaning can be carried out, Before any maintenance or cleaning can be carried out, Before any maintenance or cleaning can be carried out, Before any maintenance or cleaning can be carried out, Before any maintenance or cleaning can be carried out, you must DISCONNECT the hob fr you must DISCONNECT the hob fr[...]

electrolux 13 T o make burners work properly , ensure that pan supports are placed in a way that the arms are centred upon the burner as shown in the picture. Pay attention when replacing the Pay attention when replacing the Pay attention when replacing the Pay attention when replacing the Pay attention when replacing the pan supports in order to a[...]

14 electrolux Something Not W Something Not W Something Not W Something Not W Something Not W orking? orking? orking? orking? orking? If the hob is not working correctly , please carry out the following checks before contacting your local Service Force Centre. SYMPTOM SYMPTOM SYMPTOM SYMPTOM SYMPTOM  There is no spark when lighting the gas.  [...]

electrolux 15 OVERALL DIMENSIONS OVERALL DIMENSIONS OVERALL DIMENSIONS OVERALL DIMENSIONS OVERALL DIMENSIONS Width: 594 mm Depth: 510 mm CUT OUT DIMENSIONS CUT OUT DIMENSIONS CUT OUT DIMENSIONS CUT OUT DIMENSIONS CUT OUT DIMENSIONS Width: 560 mm Depth: 480 mm SUPPL SUPPL SUPPL SUPPL SUPPL Y CONNECTIONS Y CONNECTIONS Y CONNECTIONS Y CONNECTIONS Y CO[...]

16 electrolux BURNER RAPID SEMI-RAPID AUXILIARY TRIPLECROWN POSITION M A X M I N M A X M I N M A X M I N M A X MI N NOMINAL THERMAL POWER kW 3 . 0 0.75 2.0 0.45 1.0 0.33 4.0 1.2 NOMINAL FLOW RATE m 3 / h 0.286 0.057 0.190 0.038 0.095 0.028 0.381 0.114 NOZZLE REFERENCE 11 9 Adjust. 9 6 Adjust. 7 0 Adjust. 14 6 Adjust. 1/100 mm NOMINAL THERMAL POWER [...]

electrolux 17 Important safety requirements Important safety requirements Important safety requirements Important safety requirements Important safety requirements This hob must be installed in accordance with the Gas Safety (Installation and Use) Regulations (Current Edition) and the IEE Wiring Regulations (Current Edition). For appliances install[...]

18 electrolux Installation Installation Installation Installation Installation A) End of shaft with nut B) Washer C) Elbow IMPOR IMPOR IMPOR IMPOR IMPOR T T T T T ANT ANT ANT ANT ANT This hob must be installed by a competent person to the This hob must be installed by a competent person to the This hob must be installed by a competent person to the[...]

electrolux 19 It is important to install the elbow corr It is important to install the elbow corr It is important to install the elbow corr It is important to install the elbow corr It is important to install the elbow corr ectly ectly ectly ectly ectly , with the shoulder , with the shoulder , with the shoulder , with the shoulder , with the shoul[...]

20 electrolux 6 0 0 M IN . Location Location Location Location Location The hob may be located in a kitchen, a kitchen/diner or bed sitting room, but not in a bathroom, shower room or garage. Ensure that there is a minimum distance of 55 mm between the rear cut out edge and the wall. A minimum distance of 100 mm must be left between the side edges [...]

electrolux 21 Seal Seal Seal Seal Seal Fitting the Hob into the W orktop Carry out the building in of the hob as follows: 1 . place the seals supplied with the hob on the front edge of the cut out. Then, p lace them at 1 1 mm from the side edges and a t 10 mm from the rear edge, as shown in th e diagram, taking care that the seals meet without over[...]

22 electrolux ON/OFF SWITCH FLEX OUTLET 2 B B B B B uilding over a kitchen unit with uilding over a kitchen unit with uilding over a kitchen unit with uilding over a kitchen unit with uilding over a kitchen unit with door door door door door Proper arrangements must be taken in designing the furniture unit, in order to avoid any contact with the bo[...]

electrolux 23 Electrical Connections Electrical Connections Electrical Connections Electrical Connections Electrical Connections Any electrical work required to install this hob should be Any electrical work required to install this hob should be Any electrical work required to install this hob should be Any electrical work required to install this[...]

24 electrolux Permanent Connection Permanent Connection Permanent Connection Permanent Connection Permanent Connection In the case of a permanent connection, it is necessary that you install a double pole switch between the hob and the electricity supply (mains), with a minimum gap of 3 mm between the switch contacts and of a type suitable for the [...]

electrolux 25 Wiring diagram Wiring diagram Wiring diagram Wiring diagram Wiring diagram[...]

26 electrolux Fault Finding Fault Finding Fault Finding Fault Finding Fault Finding Preliminary Electrical Systems Check Preliminary Electrical Systems Check Preliminary Electrical Systems Check Preliminary Electrical Systems Check Preliminary Electrical Systems Check START START START START START Isolate appliance and carry out: A: A: A: A: A: Ear[...]

electrolux 27 A. EARTH CONTINUITY CHECK A. EARTH CONTINUITY CHECK A. EARTH CONTINUITY CHECK A. EARTH CONTINUITY CHECK A. EARTH CONTINUITY CHECK Appliance must be electrically disconnected - meter set on W (Ohms) x 1 scale and adjust zero if necessary . — T est leads from any appliance earth point to earth pin on plug. Resistance should be less th[...]

28 electrolux Check gas supply at burner Ignition System / Gas Ignition Ignition System / Gas Ignition Ignition System / Gas Ignition Ignition System / Gas Ignition Ignition System / Gas Ignition YES YES YES YES YES Check plug top fuse and replace if necessary Check polarity and earth continuity of supply point Check earth continuity of appliance I[...]

electrolux 29 Commissioning Commissioning Commissioning Commissioning Commissioning When the hob has been fully installed it will be necessary to check the minimum flame setting. T o do this, follow the procedure below . 1) T ur n the gas tap to the MAX position and ignite. 2) Set the gas tap to the MIN flame position then turn the control knob fro[...]

30 electrolux Conversion from Natural Gas to LPG Conversion from Natural Gas to LPG Conversion from Natural Gas to LPG Conversion from Natural Gas to LPG Conversion from Natural Gas to LPG IMPOR IMPOR IMPOR IMPOR IMPOR T T T T T ANT ANT ANT ANT ANT The replacement/conversion from natural gas to LPG should only The replacement/conversion from natura[...]

electrolux 31 Standard Guarantee Conditions We, Electrolux, undertake that if within 12 months of the date of the purchase this Electrolux appliance or any part thereof is proved to be defective by reason only of faulty workmanship or materials, we will, at our option repair or replace the same FREE OF CHARGE for labour , materials or carriage on c[...]

32 electrolux Customer Care Customer Care Customer Care Customer Care Customer Care For general enquiries concerning your Electrolux appliance, or for further information on Electrolux products please contact our Customer Care Department by letter or telephone at the address below or visit our website at www www www www www .electr .electr .electr [...]

electrolux 33 This appliance is guaranteed by Electrolux in each of the countries listed at the back of this user manual, for the period specified in the appliance guarantee or otherwise by law. If you move from one of these countries to another of the countries listed below the appliance guarantee will move with you subject to the following qualif[...]

34 electrolux[...]

electrolux 35[...]

35693-1702 10/07 R.A www .electrolux.co.uk[...]