Echo PB-755T manual

Power Blower Operator's Manual MODEL: PB-755H PB-755T W ARNING R ead rules for safe operation and all instructions carefully . ECHO provides this Op- erator's Manual which must be read and understood for proper and safe operation. X7531 122402 X753002812 12/08[...]

2 CopyRight© 2008 By Echo, Incorporated All Rights Reserved. T a b l e o f C o n T e n T s Introduction ................................................................ 2 - The Operator's Manual ....................................... 2 Safety ......................................................................... 3 Manual Safety Symbols an[...]

3 P o w e r B l o w e r o P e r a t o r ' s M a n u a l s a f e T y m a n u a l s a f e T y s y m b o l s a n d I m p o r T a n T I n f o r m a T I o n Throughout this manual and on the product itself, you will nd safety alerts and helpful, informational messages preceded by symbols or key words. The following is an explanation of those sym[...]

4 Physical Condition Y our judgment and physical dexterity may not be good: • if you are tired or sick, • if you are taking medication, • if you have taken alcohol or drugs. Operate unit only if you are physically and mentally well. Eye Protection W ear eye protection that meets ANSI Z87.1 or CE requirements whenever you operate the unit. Han[...]

5 P o w e r B l o w e r o P e r a t o r ' s M a n u a l DANGER Do not operate this product indoors or in inadequately ventilated areas. Engine exhaust contains poisonous emissions and can cause serious injury or death. Read the Manuals • Provide all users of this equipment with the Operator’ s Manual and Safety Manual for instructions on S[...]

6 An Emission Control Label is located on the unit. (This is an EXAMPLE ONL Y , information on label varies by engine F AMIL Y). e q u I p m e n T C h e C k W ARNING Use only ECHO approved attachments. Serious injury may result from the use of a non-approved attachment combi - nation. ECHO, INC. will not be responsible for the failure of cutting de[...]

7 P o w e r B l o w e r o P e r a t o r ' s M a n u a l 1 2 7 8 9 10 4 3 d e s C r I p T I o n PB-755H Locate these safety decals on your unit. Make sure the decals are legible and that you understand and follow the instruc- tions on them. If a decal cannot be read, a new one can be ordered from your ECHO dealer . See P AR TS ORDERING instruct[...]

8 1. AIR CLEANER - Contains replaceable air lter element. 2. SP ARK PLUG - Provides spark to ignite fuel mixture. 3. SAFETY DECAL - Lists important safety precautions. 4. SP ARK ARRESTOR - CA T AL YTIC MUFFLER / MUFFLER - The mufer or catalytic mufer controls exhaust noise and emission. The spark arrestor screen prevents hot, glowing parti[...]

9 P o w e r B l o w e r o P e r a t o r ' s M a n u a l PB-755T Locate these safety decals on your unit. Make sure the decals are legible and that you understand and follow the instruc- tions on them. If a decal cannot be read, a new one can be ordered from your ECHO dealer . See P AR TS ORDERING instructions for specic information. P/N 890[...]

10 1. AIR CLEANER - Contains replaceable air lter element. 2. SP ARK PLUG - Provides spark to ignite fuel mixture. 3. SAFETY DECAL - Lists important safety precautions. 4. SP ARK ARRESTOR - CA T AL YTIC MUFFLER / MUFFLER - The mufer or catalytic mufer controls exhaust noise and emission. The spark arrestor screen prevents hot, glowing part[...]

11 P o w e r B l o w e r o P e r a t o r ' s M a n u a l C o n T e n T s PB-755H ___ 1 - Power Head ___ 1 - Flex Pipe ___ 1 - Pipe w/swivel ___ 1 - Straight Pipe ___ 1 - Straight Pipe ___ 1 - Operator's Manual ___ 1 - W arranty Registration Card ___ 1 - ECHO Emissions and W arranty Statement ___ 1 - Plastic Bag ___ 2 - Clamps w/screws ___[...]

12 a s s e m b l y PB-755H W ARNING Never perform maintenance or assembly procedures with engine running or serious personal injury may result. I n s T a l l b l o W e r p I p e s / s T I C k h a n d l e 1. Assemble clamps (A) onto both ends of exible pipe (B). 2. Assemble swivel pipe (C) into exible pipe (B) and tighten clamp (A). 3. Assembl[...]

13 P o w e r B l o w e r o P e r a t o r ' s M a n u a l PB-755T W ARNING Never perform maintenance or assembly procedures with engine running or serious personal injury may result. I n s T a l l b l o W e r p I p e s 1. Place guide loop (G) across elbow clamp, and turn until clips fully engage clamp band. 2. Assemble clamps (A) onto both ends[...]

14 o p e r a T I o n W ARNING Moving parts can amputate ngers or cause severe injuries. Keep hands, clothing and loose objects away from all openings. Always stop engine, disconnect spark plug, and make sure all moving parts have come to a complete stop before removing obstructions, clearing debris, or servicing unit. Blower housing may contain [...]

15 P o w e r B l o w e r o P e r a t o r ' s M a n u a l Mixing Instructions 1. Fill an approved fuel container with half of the required amount of gasoline. 2. Add the proper amount of 2-stroke oil to gasoline. 3. Close container and shake to mix oil with gasoline. 4. Add remaining gasoline, close fuel container , and remix. IMPOR T ANT Spill[...]

16 s T a r T I n G C o l d e n G I n e • Recoil starter: Use short pulls - only 1/2-2/3 of rope length for start - ing. Do not allow the rope to snap back in. Always hold the unit rmly . PB-755H 1. Thr ottle Lever Move throttle lever (A) to IDLE DETENT position. PB-755T 1. Thr ottle Lever/Stop Switch Move throttle lever (A) forward to idle pos[...]

17 P o w e r B l o w e r o P e r a t o r ' s M a n u a l s T a r T I n G W a r m e n G I n e PB-755H 1. Thr ottle Lever Move throttle lever (A) to IDLE DETENT position. PB-755T 1. Thr ottle Lever/Stop Switch Move throttle lever (A) forward to idle position. Slide stop switch (B) forward to run position. PB-755H, PB-755T 2. Recoil Starter Pull [...]

18 W ARNING Always wear safety glasses, hearing protection, a face lter mask and take all safety precautions or serious personal injury may result. Do not point the blower pipe in the direction of people or pets. Read the Safety Section on pages 4 - 6 carefully . IMPOR T ANT T o avoid engine damage due to over-revving, do not block blower pipe o[...]

19 P o w e r B l o w e r o P e r a t o r ' s M a n u a l Y our ECHO blower is designed to provide many hours of trouble free service. Regular scheduled maintenance will help your blower achieve that goal. If you are unsure or are not equipped with the necessary tools, you may want to take your unit to an ECHO Service Dealer for maintenance. T [...]

20 a I r f I l T e r Level 1. T ools r equired: 25 - 50mm (1 - 2 in.) cleaning brush Parts r equir ed: T une Up Kit NOTE Always brush dirt and debris away from air cleaner area prior to cleaning air lter . 1. Brush dirt off air cleaner area. Keep dirt away from engine and air intake grid. 2. Remove air lter cover . Brush dirt from inside cove[...]

21 P o w e r B l o w e r o P e r a t o r ' s M a n u a l f u e l f I l T e r Level 1. T ools r equired: 200 - 250 mm (8 - 10 in.) length of wire with one end bent into a hook, clean rag, funnel, and an approved fuel container Parts r equir ed: Repower TM T une Up Kit DANGER Fuel is VER Y ammable. Use extreme ca re when mixing, storing or ha[...]

22 C o o l I n G s y s T e m Level 2. T ools r equired: 25 - 50mm (1 - 2 in.) cleaning brush, Cross Head Screwdriver Parts Requir ed: None, if you are careful. IMPOR T ANT T o maintain proper engine operating temperatures, cooling air must pass freely through the cylinder n area. This ow of air carries com - bustion heat away from the engine.[...]

23 P o w e r B l o w e r o P e r a t o r ' s M a n u a l e X h a u s T s y s T e m Spark Arrestor Screen Level 2. T ools r equired: Cross Head Screwdriver Parts Requir ed: Spark arrestor screen, Gaskets W ARNING Do not perform maintenance on engine or mufer until engine and mufer are completely cool, otherwise serious personal injury may[...]

24 Exhaust Port Cleaning Level 2 T ools r equired: W ood or plastic scraper, Cross Head Screwdriver , 4 & 5mm Hex W rench Parts Requir ed: As needed: Mufer gasket 1. Remove spark plug lead from spark plug, and remove engine cover (5 screws). 2. Place piston at top dead center . Remove mufer (A) and mufer gasket (B ). 3. Use a wood or p[...]

25 P o w e r B l o w e r o P e r a t o r ' s M a n u a l C a r b u r e T o r a d J u s T m e n T Engine Break-In New engines must be operated a minimum duration of two tanks of fuel break-in before carburetor adjustments can be made. During the break- in period your engine performance will increase and exhaust emissions will stabilize. Idle sp[...]

26 T r o u b l e s h o o T I n G DANGER Fuel vapors are extremely ammable and may cause re and/or explosion. Never test for ignition spark by ground- ing spark plug near cylinder plug hole, otherwise serious personal injury may result. T R A H C G N I T O O H S E L B U O R T m e l b o r Pk c e h Cs u t a t Se s u a Cy d e m e R - s k n a r c [...]

27 P o w e r B l o w e r o P e r a t o r ' s M a n u a l DANGER Do not store in enclosure where fuel fumes may ac- cumulate or reach an open ame or spark. 2. Place the stop switch in the "STOP" position. 3. Remove accumulation of grease, oil, dirt and debris from exterior of unit. 4. Perform all periodic lubrication and services t[...]

28 s p e C I f I C a T I o n s MODEL ---------------------------------------------------- PB-755H, PB-755T Length ------------------------------------------------------ 375 mm (14.8 in.) W idth -------------------------------------------------------- 485 mm (19 in.) Height ------------------------------------------------------- 527 mm (20.8 in.) W [...]

29 P o w e r B l o w e r o P e r a t o r ' s M a n u a l n o T e s[...]

30 n o T e s[...]

31 P o w e r B l o w e r o P e r a t o r ' s M a n u a l n o T e s[...]

DEALER? Call 1-800-432-ECHO 1-800-432-3246 or www .echo-usa.com CONSUMER PRODUCT SUPPORT 1-800-673-1558 8:30 - 4:30 Mon - Fri C.S.T . ECHO, INCORPORA TED 400 O a k w O O d R O a d L a k e Z u R i c h , iL 60047 www .echo-usa.com s e r V I C I n G I n f o r m a T I o n p a r T s / s e r I a l n u m b e r Genuine ECHO Parts and ECHO REPOWER™ Parts [...]