Desa VML27PR manual

Also Design-Cer tified As A V ented Decorative Appliance Patent Pending O F F P I L O T O N L O FLAME-MAX ® Multi-Sided Log Design VML27NR VML27PR Remote Control Ready Model WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal in- jury, or loss of life. — Do not stor[...]

111115-01D 2 For more information, visit www.desatech.com For more information, visit www.desatech.com Due to high temperatures, the appliance should be located out of traffic and away from furniture and draperies. Do not place clothing or other flammable material on or near the appliance. Never place any objects on the heater. Heater base assembly[...]

111115-01D 3 3 For more information, visit www.desatech.com For more information, visit www.desatech.com PRODUCT IDENTIFICA TION LOCAL CODES Install and use heater with care. Follow all local codes. In the absence of local codes, use the latest edition of The National Fuel Gas Code, ANSI Z223.1/NFPA 54 *. *Available from: American National Standard[...]

111115-01D 4 For more information, visit www.desatech.com For more information, visit www.desatech.com PROVIDING ADEQUATE VENTILATION The following are excerpts from National Fuel Gas Code, ANSI Z223.1/NFPA 54, Section 5.3, Air for Combustion and Ventilation. All spaces in homes fall into one of the three following ventilation classifications: 1. U[...]

111115-01D 5 5 For more information, visit www.desatech.com For more information, visit www.desatech.com c. caulking or sealants are applied to areas such as joints around windo w and door frames, between sole plates and floors, between wall-ceiling joints, between wall panels, at penetrations f or plumbing, electrical, and gas lines, and at other [...]

111115-01D 6 For more information, visit www.desatech.com For more information, visit www.desatech.com INST ALLA TION WARNING: A qualified service person must in- stall heater. Follow all local codes. WARNING: Before installing in a solid fuel burn- ing fireplace, the chimney flue and firebox must be cleaned of soot, creosote, ashes and loose paint[...]

111115-01D 7 7 For more information, visit www.desatech.com For more information, visit www.desatech.com INSTALLATION AND CLEARANCES (Vent-Free Operation Only) WARNING: Maintain the minimum clearances. If you can, provide greater clearances from floor, ceil- ing, and adjoining wall. WARNING: Never install the heater • in a bedroom or bathroom unl[...]

111115-01D 8 For more information, visit www.desatech.com For more information, visit www.desatech.com MANTEL CLEARANCES In addition to meeting noncombustible material clearances, you must also meet required clearances between fireplace openings and mantel shelf on each side of the fireplace. If you do not meet the clearances listed below, you will[...]

111115-01D 9 9 For more information, visit www.desatech.com For more information, visit www.desatech.com Area of Various Standard Round Flues Diameter (ins.) Area (sq. ins.) 5" 20 sq. inches 6" 29 sq. inches 7" 39 sq. inches 8" 51 sq. inches INST ALLA TION Continued FLOOR CLEARANCES A. If installing appliance on the floor level,[...]

111115-01D 10 For more information, visit www.desatech.com For more information, visit www.desatech.com 8. Remove heater base from fireplace. If installing optional con- trol accessories, do so at this time. Follow all directions pro- vided with accessory . See Installing Optional Remote Contr ol Accessories, below . 9. Drill holes at marked locati[...]

111115-01D 11 11 For more information, visit www.desatech.com For more information, visit www.desatech.com CONNECTING TO GAS SUPPLY WARNING: A qualified service person must con- nect heater to gas supply. Follow all local codes. WARNING: Never connect propane/LP heater di- rectly to the propane/LP supply. This heater requires an external regulator [...]

111115-01D 12 For more information, visit www.desatech.com For more information, visit www.desatech.com WARNING: Test all gas piping and connections, inter nal and external to unit, for leaks after installing or servicing. Correct all leaks at once. CHECKING GAS CONNECTIONS Pressure Testing Gas Supply Piping System Test Pressures In Excess Of 1/2 P[...]

111115-01D 13 13 For more information, visit www.desatech.com For more information, visit www.desatech.com Figure 2 2 - Checking Gas Joints for Propane/LP Gas Control Valve Location Propane/LP Supply Tank Equipment Shutoff Valve Figure 2 1 - Checking Gas Joints for Natural Gas Gas Meter Equipment Shutoff Valve Control Valve Location INST ALLA TION [...]

111115-01D 14 For more information, visit www.desatech.com For more information, visit www.desatech.com OPERA TING HEA TER FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing prop- erty damage, personal injury or loss of life. A. This appliance has a pilot which must [...]

111115-01D 15 15 For more information, visit www.desatech.com For more information, visit www.desatech.com O F F P I L O T O N L O I H 1. STOP! Read the safety inf or mation, column 2 on pag e 14. 2. Make sure equipment shutoff v alve is fully open. 3. Remove control cov er log (see Figure 28). 4. Press in and turn contr ol knob clockwise to the OF[...]

111115-01D 16 For more information, visit www.desatech.com For more information, visit www.desatech.com ON OFF REMOTE O F F P I L O T O N L O I H Selector Switch in REMOTE Position (Optional Hand-Held Remote Control) Control Knob in On Position Flame Adjustment Knob Piezo Ignitor OPERA TING HEA TER Continued TO TURN OFF GAS TO APPLIANCE Shutting Of[...]

111115-01D 17 17 For more information, visit www.desatech.com For more information, visit www.desatech.com OPERA TING HEA TER Continued Figure 34 - Correct Pilot Flame Pattern (Propane/LP Pilot Shown) Pilot Burner Thermocouple INSPECTING BURNERS Check pilot flame pattern and burner flame patterns often. PILOT FLAME PATTERN Figure 34 shows a correct[...]

111115-01D 18 For more information, visit www.desatech.com For more information, visit www.desatech.com CLEANING AND MAINTENANCE WARNING: Turn off heater and let cool before cleaning. CAUTION: You must keep control areas, burner, and circulating air passageways of heater clean. In- spect these areas of heater before each use. Have heater inspected [...]

111115-01D 19 19 For more information, visit www.desatech.com For more information, visit www.desatech.com TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. CAUTION: Never use a wire, needle, or similar object to clean ODS/pilot. This can damage ODS/ pilot unit.[...]

111115-01D 20 For more information, visit www.desatech.com For more information, visit www.desatech.com OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Moisture/condensation noticed on windows Heater produces a whistling noise whe[...]

111115-01D 21 21 For more information, visit www.desatech.com For more information, visit www.desatech.com TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a ne[...]

111115-01D 22 For more information, visit www.desatech.com For more information, visit www.desatech.com ILLUSTRA TED P AR TS BREAKDOWN MODELS VML27PR VML27NR 1 2 27-5 3 4 23 18 17 5 6 12 11 7 7 20 8 8 7 7 13 14 15 19 27-1 27-3 27-4 7 26 27-2 7 16 7 8 8 25 8 9 9 21 22 10 (NG Only) 24 (NG Only) O F F P I L O T O N H I L O O F F P I L O T O N H I L O [...]

111115-01D 23 23 For more information, visit www.desatech.com For more information, visit www.desatech.com P ARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 24 of this manual. Parts List Models VML27PR and VML27NR KEY PART NUMBER NO. VML27PR VML2[...]

111115-01D 24 For more information, visit www.desatech.com For more information, visit www.desatech.com SER VICE HINTS When Gas Pressure Is Too Low • pilot will not stay lit • burners will have delayed ignition • heater will not produce specified heat • propane/LP gas supply may be low You may feel your gas pressure is too low. If so, conta[...]

111115-01D 25 25 For more information, visit www.desatech.com For more information, visit www.desatech.com 1. Where will the product be used? ❍ Living/F amily Room ❍ Office/W arehouse ❍ Utility Shed/Outbuilding ❍ Garage ❍ Bedroom ❍ Bathroom ❍ Other 2. If y ou bought this product yourself , did you plan to purchase this type of product[...]

111115-01D 26 For more information, visit www.desatech.com For more information, visit www.desatech.com 2701 Industrial Drive P.O. Box 90004 Bowling Green, KY 42102-9004 Postage Required T APE T APE[...]

111115-01D 27 27 For more information, visit www.desatech.com For more information, visit www.desatech.com ACCESSORIES ACCESSORIES Purchase these heater accessories from your local dealer. If they can not supply these accessories, call DESA Heating Products at 1-866-672-6040 for referral information. You can also write to the address listed on the [...]

111115-01D 28 For more information, visit www.desatech.com For more information, visit www.desatech.com KEEP THIS WARRANTY W ARRANTY INFORMA TION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard wri[...]