Desa LFP33PR manual

Shown with optional cabinet mantel and hearth base. Save this manual for future reference. WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury, or loss of life. — Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any[...]

2 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases. 2. Do not place propane/LP supply tank(s) inside any structure. Locate propane/ LP supply tank(s) outdoors. SAFETY INFORMA TION DANGER: Carbon monoxide [...]

3 104888 OWNER’S MANUAL O F F P I L O T O N H I L O PRODUCT IDENTIFICA TION Figure 1 - Log Base Assembly Log Set Remote Selector Switch (Optional) Piezo Ignitor Figure 2 - Fireplace Top Louvered Hood Bottom Louver Assembly Screen Assembly Top Outer Casing Firebox Support LOCAL CODES Install and use fireplace with care. Follow all local codes. In [...]

4 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR AIR FOR COMBUSTION AND VENTILA TION Today’s homes are built more energy effi- cient than ever. New materials, increased insulation, and new construction methods help reduce heat loss in homes. Home owners weather strip and caulk around windows and doors to keep the cold air out and the warm air [...]

5 104888 OWNER’S MANUAL AIR FOR COMBUSTION AND VENTILA TION Continued DETERMINING FRESH-AIR FLOW FOR FIREPLACE LOCATION Determining if You Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install fireplace plus any adjoining rooms with doorl[...]

6 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR AIR FOR COMBUSTION AND VENTILA TION Continued VENTILATION AIR Ventilation Air From Inside Building This fresh air would come from an adjoining unconfined space. When ventilating to an adjoining unconfined space, you must pro- vide two permanent openings: one within 12" of the ceiling and one [...]

7 104888 OWNER’S MANUAL INST ALLA TION Continued Note: Your Comfort Glow fireplace is designed to be used in zero clearance instal- lations. Wall or framing material can be placed directly against any exterior surface on the rear, sides, or top of your fireplace, except where standoff spacers are integrally attached. If standoff spacers are attac[...]

8 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR Figure 9 - Installing Cabinet Mantel INSTALLATION CLEARANCES WARNING: Maintain the mini- mum clearances. If you can, pro- vide greater clearances from floor, ceiling, and adjoining wall. Carefully follow the instructions below. This will ensure safe installation. Minimum Wall and Ceiling Clearance[...]

9 104888 OWNER’S MANUAL INST ALLA TION Continued Figure 11 - Inserting Fireplace Into Cabinet Mantel Figure 10 - Location of Nailing Flanges Nailing Flanges Continued Actual Framing Height 32 3 / 8 " 33" Front Width 34 5 / 16 " 35 1 / 2 " Depth 16 11 / 16 " 17 3 / 4 " 35 1 / 2 " 17 3 / 4 " 33" Figure 1[...]

10 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR Supplied Firebox Hood Must Be Used at All Times Wire-mesh Screen Firebox Noncombustible Material May Project Off this Surface above the Firebox Hood Mantel Shelf 13" 16" 19" 21" 2 1 /2 " 6" 8" 10" Note: All vertical measurements are from top of fireplace ho[...]

11 104888 OWNER’S MANUAL Figure 18 - Removing Log Base Assembly From Fireplace O F F P I L O T O N H I L O CAUTION: Do not pick up log base assembly by burners. This could damage burners. Only handle base by grates. Installation Items Needed • 5/16" hex socket wrench or nut-driver • Phillips screwdriver • sealant (resistant to propane/[...]

12 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR Manual Shutoff Valve Manual Gas Valve Propane/LP Supply Tank INST ALLA TION Continued Test Pressures Equal To or Less Than 1/2 PSIG 1. Close manual shutoff valve (see Fig- ure 20). 2. Pressurize supply piping system by ei- ther using compressed air or opening propane/LP supply tank valve. 3. Chec[...]

13 104888 OWNER’S MANUAL INST ALLA TION Continued WARNING: After installation and periodically thereafter, check to ensure that no flame comes in contact with any log. With the heater set to High, check to see if flame contact any log. If so, repo- sition logs according to the log installation instructions in this manual. Flames contacting logs w[...]

14 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR INST ALLA TION Continued OPTIONAL WIRELESS HAND- HELD REMOTE CONTROL ACCESSORY RM4 Installing Remote Receiver Unit 1. Disconnect switch wires from the con- trol valve. 2 . Remove screws and nuts attaching switchplate. Save screws and nuts to attach receiver . 3. Remove switch plate (see Figure 27[...]

15 104888 OWNER’S MANUAL INST ALLA TION Continued OPTIONAL WIRELESS HAND- HELD REMOTE CONTROL ACCESSORY GHRC and GHRCT SERIES Installing Remote Receiver Unit 1. Disconnect switch wires from the con- trol valve. 2. Remove screws attaching switchplate. 3. Remove switch plate (see Figure 32). Discard after removing. 4. Install remote receiver unit o[...]

16 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR O F F P I L O T O N L O I H AUTO ON OFF LIGHTING INSTRUCTIONS WARNING: You must operate this fireplace with the fireplace screen in place. Make sure fire- place screen is installed before running fireplace. NOTICE: During initial operation of new fireplace, burning logs will give off a paper-burn[...]

17 104888 OWNER’S MANUAL O F F P I L O T O N L O I H ON OFF REMOTE Figure 39 - Setting the Selector Switch, Control Knob, and Flame Adjustment Knob for Remote Operation Selector Switch in Remote Position(Optional Remote Control) Control Knob in On Position Flame Adjustment Knob Locate the blower switch by opening lower louver on fireplace. Blower[...]

18 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR Figure 40 - Correct Pilot Flame Pattern Pilot Burner Thermocouple Figure 41 - Incorrect Pilot Flame Pattern Check pilot flame pattern and burner flame patterns often. PILOT FLAME PATTERN Figure 40 shows a correct pilot flame pat- tern. Figure 41 shows an incorrect pilot flame pattern. The incorre[...]

19 104888 OWNER’S MANUAL TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Only a qualified service person should service and repair heater. CAUTION: Never use a wire, needle, or similar object to clean ODS/pilot. This can damage ODS/ pilot unit. POSSIBLE CAUSE 1. Ignitor electrode not connected to igni- tor cable 2. Ignitor[...]

20 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Moisture/condensation noticed on windows Heater produces a whistling noise when burner is lit White powder residue forming within[...]

21 104888 OWNER’S MANUAL TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. • If you cannot re[...]

22 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR SPECIFICA TIONS LFP33PR Remote Ready Btu (Variable) 20,000/33,000 Type Gas Propane Only Ignition Piezo Pressure Manifold 8.0" W.C. Inlet Gas Pressure (in. of water) Maximum 14" Minimum* 11" Shipping Weight 30 lbs. (24")/32 lbs. (30")/34 lbs. (36”) * For input adjustment[...]

23 104888 OWNER’S MANUAL REPLACEMENT PA R T S Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealers of this product. If they can’t supply original replacement part(s), call DESA International’s Technical Service Department at 1-800[...]

24 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR CABINET MANTEL ACCESSORY WITH FIREPLACE PERIMETER BRASS TRIM GMC11F Series - Walnut Finished Hardwood Veneer GMC12U Series - Unfinished Hardwood Veneer, Ready to Stain or Paint GMC13F Series - Medium Stained Oak Veneer Mantel features moldings, fluted sides, and medallion. Shown with optional bas[...]

25 104888 OWNER’S MANUAL MANUAL SHUTOFF VALVE GA5010 For all models. Manual shutoff valve with 1/8" NPT tap. Fits 1/2" NPT pipe. DUPLEX OUTLET KIT GA3555 (Not Shown) Use for built-in installations when hard wir- ing a blower. HAND-HELD REMOTE CONTROL - RM4 For remote control operation. Installation and limited operation instructions inc[...]

26 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR ILLUSTRA TED PA R T S BREAKDOWN REMOTE READY MODEL LFP33PR 20 O F F P I L O T O N H I L O 11 15 29 10 9 7 6 5 1 2 4 3 8 12 7 17 16 28 18 19 24 14 13 19 23 22 26 27 25 21[...]

27 104888 OWNER’S MANUAL P ARTS LIST REMOTE READY MODEL LFP33PR This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 23 of this manual. KEY NO. PART NUMBER DESCRIPTION QTY. 1 104937-01 Log #1, Middle 1 2 104938-01 Log #2, Back 1 3 104936-01 Log #3, Front 1[...]

28 104888 UNVENTED PROP ANE/LP GAS FIREPLACE LFP33PR 1 2 3 4 15 10 11 9 18 6 17 12 16 16 16 7 8 16 16 5 14 16 13 13 13 ILLUSTRA TED PA R T S BREAKDOWN FIREPLACE LFP33PR[...]

29 104888 OWNER’S MANUAL P ARTS LIST FIREPLACE LFP33PR This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 23 of this manual. KEY NO. PART NUMBER DESCRIPTION QTY. 1 101357-01 Top Outer Casing 1 2 103207-01 Outer Casing 1 3 102758-02CK Right Front Side 1 4[...]

LIMITED WARRANTY COMFORT GLOW VENT-FREE PROPANE/LP GAS FIREPLACE DESA International warrants this product to be free from defects in materials and components for two (2) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. To make a clai[...]