Culligan Drinking Water System manual

C ul ligan W ater T ower™ Dr inking W ate r S yst e m O w ner s Guide[...]

C ulligan W ater T ower™ CW T35ST .3.0 NOTICE: This system is intended for use on potable water supplies or disinfected water containing cysts. Do not use where water is microbiologically unsafe or with water of unknown quality without adequate disinfection before or after the system. Systems certified for cyst reduction may be used on disinfecte[...]

T able o f Contents Safety/W arnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2 S ystem Speci fications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 Introduction About Y our S ystem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5 S ystem Component Description .[...]

System Sp ecificat ions S ystem Flow Sequences . . . . . . . . . . . . . . . . . .S ediment Fi l ter , Activated Carbon Fi l ter , R everse Osmosis Membrane, Stor age T ank, P olishing Fi lter , Dispensing F aucet. S ediment Fi l ter . . . . . . . . . . . . . . . . . . . . . . . . . Spun P olypropylene T ype Carbon Fi l ter . . . . . . . . . . . . [...]

Introduction Thank y ou for choosing a Cul l igan W ater T ower™ drinking water system. Y our new system is designed to bring you years of healthful, del iciously crystal-clear Cul l igan ® water . With its special f aucet instal led on y our sink, i t’ s like getting bot t led water str aight f r om your kitchen tap . With the Cul l igan W at[...]

Polishing Filter The Cul l igan Water T ower™ drinking water system includes a second activated carbon fi l ter in the mani f old as added assur ance that y our w ater wi l l be crystal clear . Culligan ® Smartap ® Water Quality Monitor and Faucet The special drinking water faucet mounts con venient ly on y our kitchen sink. A simple twist of t[...]

T able 1 1 A pr essure regulator is r ecommended for f eed water pr essures ex ceeding 80 psig (552 kP a) 2 S ee the T echnical Manual for all appl ications where TDS exceeds 1000 ppm (1000 mg/L) to cal - culate ef f ective module pressure. A booster pump is strongly r ecommended. 3 The reverse osmosis membrane fi l ter used in this system ma y be [...]

I nstal lation This Owner ’ s Guide pr o vides visual assembly ref erence only (Figur e 2). Since special ized ski l ls ar e r equired in the assembly of the drinking water system, we r ecommend that y ou contact your local independently operated Cul l igan ® dealer to complete this installation. Component Location Product Water Faucet F aucet m[...]

Ser v ic ing y o ur sy st em Service Schedule When properly maintained, your Cul l igan W ater T ower™ drinking water system wi l l give you y ears of dependable service. This reverse osmosis system contains a replaceable tr eatment component, criti - cal for the ef f ectiv e reduction of total dissolved solids. The product w ater should be teste[...]

If you wish to service your system, the fi l ters ar e a vai lable f r om your Cul l igan dealer . T o locate y our nearest Cul l igan dealer , call (800) 285-5442, or visit our website at www .cull igan.com. S ee the P arts List at the end of this section for replacement numbers. Cartridge Conditioning The activated carbon, r ev erse osmosis, and [...]

Note: Use hand pump to avoid damaging tank. Verify product water faucet is open before pro - ceeding. Use caution when working with/inside enclosure. Wiring therein connects monitor com - ponents. If wires, circuit board, or connections are damaged and/or wetted, monitor will not function. Item callouts refer to Figure 5 unless otherwise noted. 4. [...]

Figure 5 12. Place a smal l amount of O-ring lubricant on surf ace of fi l ter housing O-ring. Install O-ring into housing. T O SANITIZE THE SYSTEM: Complete Steps 13-33. T O INST ALL FIL TERS: Complete Steps 20-33. CAUTION: Wear safety glasses while performing this procedure. CA UT I ON : Re a d “ W AR N IN GS ” i nf o rm a ti on o n b l ea ch[...]

Note: Tighten filter housings by hand only. Do not use tools as they will over-tighten and dam - age housings. 15. Slowly open source w ater supply valve. 16. Close product w ater faucet as soon as water begins to flow f r om spout. 17 . W ait 5 minutes, then close source w ater supply valve. 18. W ait 25 minutes, then open product w ater faucet. L[...]

T O RE-SET MONIT OR or T O CHANGE BA TTER Y : P erf orm Steps 24-27 Ref er to Figure 6 for component location. Use caution when working inside enclosure. Wiring therein connects monitor components. If wires, circuit board, or connections are damaged and/or wetted, moni tor wi l l not function. Connect battery to moni tor after system has been in pr[...]

30. Open product w ater faucet. Let w ater flow until all air has been expelled f r om the system. 31. Close product w ater faucet. W ait 30 minutes, check connections f or leaks, and correct if neces - sary . I cemaker/Extra point of use: Check lines f or leaks. 32. Allow stor age tank to fi l l o vernight. DO NOT USE FIRST FULL STORAGE TANK OF WA[...]

T ro ublesho oting G uide Water Volume and Quality Symptom Condition Action No pr oduct w ater W ater supply is turned OFF T urn water ON Not enough Low w ater pr essure Check source w ater line pressur e pr oduct w ater I nlet water supply v alve is blocked Clear r estriction Stor age tank valve is closed Open storage tank valv e Stor age tank is [...]

Smartap ® Quality Monitor Status Indications and Common Solutions 17 Leakage Symptom Probable Cause Solution Leak at fi tting T ubing not pushed completely Push tube into fi t ting past into fi tting O-ring seal Def ective tube Cut damaged area f r om tube or r eplace tube T ubing mak es too tight a bend R un the tubing to r educe the bend near fi[...]

P ar ts List 18 Item Description Part No. 1 Culligan Faucet, Chrome body/spout 11403430 Culligan Faucet, White body/spout 11403431 Culligan Faucet, Almond body/spout 11403433 Culligan Faucet, Black body/spout 11403434 Culligan Faucet, Satin body/spout 11403436 Culligan Faucet, Black body/Polished spout 11403439 2 Battery, 9-volt alkaline 31300001 4[...]

Ser v ice L og Culligan Water Tower™ Service Log Model S erial No . Date Instal led F or S ervice Cal l Cul l igan at: 19 ( ) - Cartridge(s) Changed Activ ated Activ ated Date Sediment Pre-Carbon RO P ost-Carbon Serviced Filter Filter Membrane Filter Sanitized[...]

A r se nic F act Shee t Arsenic (abbreviated As) is found naturally in some well water . Arsenic in water has no color , taste or odor . It must be measured by a lab test. Publ ic water uti li ties must ha v e their w ater tested for arsenic. Y ou can get the r esults f r om your water uti l ity . If you ha v e your own well, you can ha v e the w a[...]

C alifor nia Cert ificat e 21[...]

22 C ul ligan L ifetime L imited W arranty Culligan Lifetime Limited Warranty CULLIGAN W A TER T OWER™ CWT -35 MODEL SERIES Y ou ha v e just purchased one of the finest drinking water systems made. As an expression of our confidence in Cul l igan International Company products, y our drinking water system is warr anted to the original end-user , [...]

LET CHANGE BY APRVD DCO DA TE A REVISED PER DCO TPD BL 1254 8/21/00 B UPDA TE AR T LR JB 7091 04/26/04 C 8 UPDA TE AR T PH/LR JS 8215 08/09/05 Materials & Description: Good Water Machine Owners Guide P/N 01882203 Size: 11” x 17” Booklet folded to 8.5” x 11” Color: Black; 2 Sided Stock: 20# White Other: Saddle Stitch (2 Staples) Booklet [...]