Alto-Shaam 1010 manual

MN-29245 • 05/12 printed i n u . s . a . Combitherm ® Combination Oven / Steamer ES ELECTRIC COMBITOUCH® SERIES 6•10 10•10 7•14 10•18 12•20 20•20 VHes-5 VHes -10   • InstallatIon W164 N9221 Water Street • P.O. Box 450 • Menomonee Falls, Wisconsin 53052-0450 USA PHONE: 262.251.3800 • 800.558.8744 u s a / c a N a d a [...]

i Delivery .................................. 1 Unpacking ................................ 1 Safety Procedures and Precautions ............. 2 Installation Site Requirements ........................ 3 Ventilation Requirements ................... 3 Positioning on Site ........................ 4 Lifting Instructions ........................ 5 Levelin[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 1. DELIVERY This Alto-Shaam appliance has been thoroughly tested and inspected to ensure only the highest quality unit is provided. Upon receipt, check for any possible shipping damage and report it at once to the delivering carrier. See Transportation Damage and Claims section located in [...]

CAUTION Used to indicate the presence of a hazard that can or will cause minor personal injury, property damage, or a potential unsafe practice if the warning included with this symbol is ignored. CAUTION Used to indicate the presence of a hazard that can or will cause minor or moderate personal injury or property damage if the warning included wit[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 3. SITE INSTALLATION INSTALLATION DANGER IMPROPER INSTALLATION, ALTERATION, ADJUSTMENT, SERVICE, OR MAINTENANCE COULD RESULT IN SEVERE INJURY, DEATH, OR CAUSE PROPERTY DAMAGE. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING OR SERVICING THIS EQUIP[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 4. NOTE: Note dimensions required for doorways and aisles for access of the oven and pallet to the installation site. Transport the oven in an upright and level position only. Do not tilt the oven. ® SITE INSTALLATION INSTALLATION POSITIONING ON SITE Stand the oven in a level position. Us[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 5. SITE INSTALLATION INSTALLATION Lifting Ins tructions Do not lift in this area! Damage t o the components will r esult. Cent er of Gra vity Front View T op View (Fron t) Leg 24” Spacer Board Remov e banding befor e lifting. Place a spacer board(s ) 24” in length, with a minimum h eig[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 6. SITE INSTALLATION INSTALLATION POSITIONING REQUIREMENTS q In order to ensure proper ventilation, a minimum distance of at least 6-inches (152mm) must be kept from the control panels side (left) of the oven and any adjoining surfaces. NOTE: Additional clearance is needed for service acce[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 7. COMMON SPECIFICATIONS CombiGuard™ BWS Blended Water System ( iNcludEs 50 gallON taNk , 1 MEMbraNE & 3 FiltErs ) FI-28727 CombiGuard™ BWS Replacement Filter Cartridge AMS-QT FI-29316 CombiGuard™ BWS Replacement Filter Cartridge SCLX2-Q FI-29317 CombiGuard™ BWS Replacement Pre[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 8. 6•10 es 31-3/8" (796mm) 34-1/16" (864mm) 17-15/16" (456mm) 7-9/16" (191mm) WA TER DRAIN 33-1/8" (840mm) 4-15/16" (125mm) Steam Ve nt (Top) 60-9/16" (1538mm) Water Drain (Back) Tr eated Wa ter Intake (Bottom) Untreated Water Intake (Bottom) Electrical[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 9. 6•10 es i 31-3/8" (796mm) 34-1/16" (864mm) 17-15/16" (456mm) 7-9/16" (191mm) WA TER DRAIN 33-1/8" (840mm) 4-15/16" (125mm) Steam Ve nt (Top) 60-9/16" (1538mm) Water Drain (Back) Tr eated Wa ter Intake (Bottom) Untreated Water Intake (Bottom) Electric[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 10. 6•10 es iN 32-15/16" (835mm) 35-9/16" (903mm) 21-11/16" (550mm) 5-3/8" (137mm) 6-3/8" (161mm) WA TER DRAIN 33-7/8" (859mm) 35-13/16" (909mm) 2" (50mm) 41-1/16" (1042mm) Water Drain (Side Back) Steam Vent (T op) Electrical Connection (Botto[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 11. 10•10 es 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31-3/8" (796mm) 34-1/16" (865mm) 17-1[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 12. 10•10 es i 33-1/16" (840mm) 4-15/16" (125mm) 41-1/2" (1053mm) 33-15/16" (861mm) 7-9/16" (192mm) 60-9/16" (1538mm) Water Drain (Back) 30" (761mm) 2" (50mm) 49-1/8" (1247mm) 43-7/8" (1114mm) 31-3/8" (796mm) 34-1/16" (865mm) 17[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 13. 19-1/2" (495mm) 12-5/16" (312mm) 9-9/16" ( 242m m) 35-7/8" (910mm) 33-7/8" (860mm) 33" (837mm) 2" (50mm) 35-11/16" (905mm) 25" (635mm) 7-9/16" (191mm) 5" (126mm) Water Drain (Rear) Steam Vent (T op) 21-15/16" (557mm) 41-1/16&q[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 14. 7•14 es TO P VIEW FRONT VIEW SIDE VIEW A rial MT Condensed Light 8 pt 43-3/4" (1111mm) 8-1/2" (216mm) 26-1/2" (672mm) 6-1/4" (159mm) 35-7/16" (899mm) Grease Collection Pump (option) Grease Collection Pump (option) Wa ter Drain 44-7/16 " (1128mm) 70-15/16[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 15. 7•14 es i TO P VIEW FRONT VIEW SIDE VIEW A rial MT Condensed Light 8 pt 43-3/4" (1111mm) 8-1/2" (216mm) 26-1/2" (672mm) 6-1/4" (159mm) 35-7/16" (899mm) Grease Collection Pump (option) Grease Collection Pump (option) Wa ter Drain 44-7/16 " (1128mm) 70-15/[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 16. 30" (760mm) 22-3/8" (568mm) 15-1/2" (393mm) 12-3/4" (323mm) Electrical Connection (Bottom) 2" (50mm) 46-7/8" (1190mm) 43-7/8" (1114mm) 41-15/16" (1064mm) 40-1/8" (1019mm) 25-5/8" (650mm) 8-11/16" (219mm) 6-1/4" (158mm) Water D[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 17. 10•18 es i WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS TWO (2) COLD W A TER INLETS - DRINKING QUALITY ONE (1) TREA TED W A TER INLET : 3/4" NPT* ONE (1) UNTREA TED W A TER INLET : 3/4" NPT* LI NE PR ES SU RE : 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" CO[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 18. 46-3/4" (1186mm) 44-3/4" (1136mm) 40-15/16" (1039mm) 1-13/16" (46mm) 48" (1218mm) 45-5/16" (1151mm) 33-1/2" (851mm) 2-1/16" (52mm) Water Drain (Bottom) 51-15/16" (1319mm) 2" (50mm) 76-15/16" (1954mm) 8-15/16" (226mm) 7-11/16&q[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 19. 12•20 es i WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS TWO (2) COLD W A TER INLETS - DRINKING QUALITY ONE (1) TREA TED W A TER INLET : 3/4" NPT* ONE (1) UNTREA TED W A TER INLET : 3/4" NPT* LI NE PR ES SU RE : 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" CO[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 20. 40-15/16" (1039mm) 1-13/16" (46mm) 46-3/4" (1186mm) 44-3/4" (1136mm) 4-3/4" (120mm) 2" (50mm) 51-15/16" (1319mm) Water Drain (Back) Steam Vents (T op) 76-15/16" (1954mm) 8-15/16" (226mm) 67-3/8" (1710mm) 76-1/4" (1936mm) 12-15/16&q[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 21. 20•20 es i WATER REQUIREMENTS WATER QUALITY MINIMUM STANDARDS TWO (2) COLD W A TER INLETS - DRINKING QUALITY ONE (1) TREA TED W A TER INLET : 3/4" NPT* ONE (1) UNTREA TED W A TER INLET : 3/4" NPT* LI NE PR ES SU RE : 30 to 90 psi 2.8 to 6.2 bar W A TER DRAIN: 1-1/2" CO[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 22. ELECTRICAL CONNECTION INSTALLATION DANGER ENSURE POWER SOURCE MATCHES VOLTAGE IDENTIFIED ON APPLIANCE RATING TAG. DANGER To avoid electrical shock, this appliance MUST be adequately grounded in accordance with local electrical codes or, in the absence of local codes, with the current e[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 23. ELECTRICAL CONNECTION INSTALLATION DANGER ELECTRICAL CONNECTIONS MUST BE MADE BY A QUALIFIED SERVICE TECHNICIAN IN ACCORDANCE WITH APPLICABLE ELECTRICAL CODES. FINAL ASM, TOUCH SCREEN COMBICLEAN 5011685 Terminal Block Ground Electrical Connection DANGER To avoid electrical shock, this [...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 24. MOBILE EQUIPMENT RESTRAINT INSTALLATION Any appliance that is not furnished with a power supply cord but includes a set of casters must be installed with a tether. Adequate means must be provided to limit the movement of this appliance without depending on or transmitting stress to the[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 25. INSTALLATION WATER QUALITY REQUIREMENT WARNING TO PREVENT WATER PIPES OR HOSES FROM BURSTING, INCOMING WATER SUPPLY SHOULD BE TURNED OFF WHEN THE APPLIANCE IS NOT IN USE. WARNING WATER SUPPLY MUST BE OPEN WHEN CLEANING PROGRAM IS ACTIVATED. VERIFY WATER SUPPLY BEFORE STARTING CLEANING [...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 26. INSTALLATION WATER CONNECTIONS WATER SUPPLY & INSTALLATION WATER REQUIREMENTS TWO (2) COLD WATER INLETS - DRINKING QUALITY ONE (1) TREATED WATER INLET: 3/4" NPT* ONE (1) UNTREATED WATER INLET: 3/4" NPT* LINE PRESSURE: 30 to 90 psi 2.8 to 6.2 bar * Can manifold off of one [...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 27. INSTALLATION WATER VALVE WATER DRAINAGE shut - off valve shown i n the off position NOTE: THE SHUT-OFF VALVE MUST BE IN THE OPEN POSITION WHEN THE OVEN IS BEING USED. The oven must discharge through an indirect waste pipe by means of an air gap. The drain fitting is supplied with a 1-1[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 28. GREASE COLLECTION HOOK-UP ( I F EQUIPPED WITH THIS FEATURE ) • Grease Collection Hose Assembly is attached to the oven in the back. • Place Grease Collection Containers inside the tray of the Mobile Grease Collection Cart. Roll into place next to the oven. • Remove cap from conta[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 29. INSTALLATION COMBITOUCH® CHECKLIST Use this list as a nal check of oven installation conformance. Damage directly attributed to improper set up, installation, or cleaning can invalidate warranty claims. CLEARANCES: Left: 6" (152mm) — Service access of 18" (457mm) recomm[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 30. INSTALLATION cONTINUed ON NexT pAge ERROR CODES This section is provided for the assistance of qualified technicians only and is not intended for use by untrained or unauthorized service personnel. If your Alto-Shaam ® unit is not operating properly , check the following before callin[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 31. INSTALLATION cONTINUed ON NexT pAge ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E13 Boiler Temperature High Boiler temperature overheats — Scale build up inside steam generator. — Scale build up on water level probe. — B4 Probe connection [...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 32. INSTALLATION ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E34 Steam Generator Drain Pump Fault Water level in steam generator does not drop during cleaning program — Scale build up inside the steam generator drain pump. — Scale build up insid[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 33. INSTALLATION ERROR CODES Error Code Error Call Out in Display Description of Error Possible Cause E57 No Rinse Water During rinse no water fl ow is detected through solenoid valve — Water supply is shut off. — Low water pressure. — Check wiring to all components mentioned below.[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 34. INSTALLATION Type of Error Indication Release of Error Undervoltage LED fl ashing sequence, with 1 fl ash per period. Voltage of intermediate circuit is less than 250V Overvoltage LED fl ashing sequence, with 2 fl ashes per period. Voltage of intermediate circuit exceeds 445V Exces[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 35. INSTALLATION ERROR CODES When the oven malfunctions, an error code will appear in the display . PRESS THE ST AR T ICON TO ACKNOWLEDGE THE ERROR. The icons that begin to flash repr esent operational modes that are still usable. When the oven fault is corrected, the Combitherm will r etu[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 36. INSTALLATION VENTLESS HOOD OPTION The Ventless Hood option is factory installed directly on the top of the Alto-Shaam Combitherm oven. The hood is designed to vent clean air back into the kitchen, filtering vapors and grease. A high-power fan draws steam and fumes into the hood intake [...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 37. INSTALLATION VENTLESS HOOD OPTION TOP LEVEL ASSY, VHES-5 HOOD FOR COMBI 5010692 TOP EXHAUST VENT 2 6 1 4 3 5 7 1 Ventless Hood Power Knob 2 Emergency Latch Release: This release is to be used ONLY if the timed latch mechanism is not working or in the event of a power outage. Repeated u[...]

COMBITOUCH® ES SERIES • ELECTRIC INSTALLATION MANUAL • 38. ORIGINAL EQUIPMENT LIMITED WARRANTY Alto-Shaam, Inc. warrants to the original purchaser that any original part that is found to be defective in material or workmanship will, at Alto-Shaam’s option, subject to provisions hereinafter stated, be replaced with a new or rebuilt part. The [...]

TRANSPORTATION DAMAGE AND CLAIMS All Alto-Shaam equipment is sold F.O.B. shipping point, and when accepted by the carrier, such shipments become the property of the consignee. Should damage occur in shipment, it is a matter between the carrier and the consignee. In such cases, the carrier is assumed to be responsible for the safe delivery of the me[...]