Thermos 465621303 manuale d’uso

WARNING CA UTION Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary. Failure to follow all manufacturer’s instructions could result in fire or explosion which could cause property damage, personal injury or death. Grill2Go-VA-E / 36-6047-050-200 (04-02-03) Read and follow all safety state[...]

2 • Grill2Go D ANGER WARNING CA UTION FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance. FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. E[...]

Grill2Go • 3 LP (Liquefied Petroleum Gas) • For Your Safety • LP gas is highly flammable and may ignite unexpectedly when mixed with air. Is nontoxic, odorless and colorless when produced. , LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. CA UTION For residential use only. Do not use for commercial cooking[...]

4 • Grill2Go Warranty THERMOS GRILLS Consumer Warranty / P.O. Box 1240 Columbus, GA 31902-1240 Thermos warrants to the original consumer-purchaser that this product shall be free from defects in workmanship and materials under normal and reasonable use and correct assembly (If assembled by consumer-purchaser) as follows: (1) The aluminized top an[...]

Grill2Go • 5 For Your Safety .............................................................2 Safety Symbols LP (Liquefied Petroleum Gas) .................................................3 Grill Service Center Installation Safety Precautions Warranty Information Warranty ..................................................................4 Table of C[...]

6 • Grill2Go Parts List and Diagram – Grill Lid Key Qty. Description Part No. Included in Model 465621303 Qty. Description Part No. A 1 Lid 65-6047-063-204 B 2 Upper Hinge 65-6047-093-200 C 1 Handle Assembly 69-6047-057-200 D 1 Upper Latch 65-6047-096-200 E 1 Heat Shield 21-6047-082-200 F 1 T orsion Bar 65-6047-1 10-200 1 4’ Adapter Hose 4187[...]

Grill2Go • 7 Parts List and Diagram – Grill Bottom and Burner System Key Qty. Description Part No. G 1 Ignitor Wire 69-6047-332-200 H 1 Regulator Lock 69-6047-340-200 I 1 Grate 65-6047-339-200 J 1 Collector Box 21-6047-338-200 K 1 Burner 69-6047-029-200 L 1 Lower Heat Shield 21-6047-023-201 M 2 Lower Hinge 69-6047-048-200 N 1 Grill Bottom 65-60[...]

8 • Grill2Go Parts List and Diagram – Plinth and Legs Key Qty. Description Part No. BB 1 Plinth 64-6047-359-203 CC 1 Leg - Left 1 1-6047-036-201 DD 1 Leg - Right 1 1-6047-037-201 EE 1 Leg Latch 21-6047-394-200 GG 4 Leveling Blocks 1 1-6047-065-200 HH 1 Match-Light Stick 63-6047-369-200 I I 1 Square Washer 21-6047-419-200 Key Qty. Description Pa[...]

Grill2Go • 9 Assembly Your grill will require minimal assembly. The Grill2Go™ is packaged in three major components. Additional parts are stored beneath grill lid. Remove all protective packaging and product information cards before assembly. NOTE: The rubber spacers on the grill lid help to protect the non-stick cooking surface and should not [...]

10 • Grill2Go Coach bolts pass completely through holes in plinth and legs. NOTE: Use square hole, not round hole, when assembling plinth to legs. Plastic Fastener Washer NOTE: Do not fully tighten fasteners at this time. Fully unfold legs to position shown above and hand-tighten the four plastic fasteners.[...]

Grill2Go • 11 Grease container slides onto slot on left side of plinth. Cap should be open when installing. Tab on grill bottom snaps under front lip of plinth. Grill fits firmly onto plinth. Ignitor on grill bottom fits into slot in plinth. A Attach 1 lb. LP cylinder to regulator by twisting clockwise. NOTE: 1 lb. LP cylinder sold separately. B [...]

12 • Grill2Go Insert shelf rods into holes in sides of grill bottom. Shelf with valve cutout attaches to right side of grill. WARNING Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm.[...]

Grill2Go • 13 Your Grill2Go™ can be used with the legs fully extended or folded beneath the grill. To use grill on a table-top, fully loosen plastic fasteners (A), fold legs inward until they latch together (B), then hand-tighten the fasteners to secure legs in the closed position (C). A Turn Counterclockwise C Turn Clockwise B Fold right leg f[...]

14 • Grill2Go Use and Care Propane Cylinder Use (1 lb. Disposable) • • • • Use only cylinder marked “Propane Fuel”. Size should be 4” diameter , 8” height, or 3” diameter , 10” height. Save cylinder cap and reinstall when not in use. Cylinder supply system must be arranged for vapor withdrawal. Gas cylinder must be upright in [...]

Grill2Go • 15 Propane Cylinder Use (20 lb. Refillable) The 20 lb. LP tank used with your grill must meet the following requirements: • • • Use only tanks equipped with this type of valve. Tank must be upright in use. LP Tank Filling • • must be purged • NEVER • LP Tank Exchange Exchange for OPD safety feature equipped tank as descri[...]

16 • Grill2Go Leak Testing (20 lb. Refillable) IMPORT ANT! For your safety • • • • Use mild soap and water. Do not use household cleaning agents. (A) Leak test must be repeated each time LP tank is exchanged or refilled. Do not smoke during leak test. Do not use an open flame to check for gas leaks. Grill must be leak checked outdoors in [...]

Grill2Go • 17 Connecting The Adapter Hose To The LP Tank (continued) 5. Hold hose end, insert nipple (A) into LP tank valve. Hand tighten coupling nut, (B) so as not to cross thread the connection. holding connector in a straight line with LP tank valve Position coupling nut and hose-end as shown for proper connection to LP tank valve. Nipple mus[...]

18 • Grill2Go WARNING • Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, close LP tank valve and call LP gas supplier or your fire department! immediately Leak Testing Valves, Hoses and Regulator Turn grill control knob to off. Correct before proceedi[...]

Grill2Go • 19 For Safe Use Of Your Grill: • • • • • • • Operate grill with 1 lb. cylinder in correct position as shown in . • Always remove 1 lb. cylinder from grill when transporting. • Operate grill with 20 lb. cylinder in correct position as show in . • Always remove 20 lb. cylinder from grill when transporting. Do not leav[...]

20 • Grill2Go Safety Tips s s s s s s s s The use of alcohol, prescription or nonprescription drugs may impair the consumer ’s ability to properly assemble or safely operate the appliance. When grill is not in use, disconnect 1 lb. cylinder or turn off 20 lb. cylinder . Never move grill while in operation or still hot. Allow the appliance to co[...]

Grill2Go • 21 Ignitor Check Regulator/Valve must be in “Off” position. Ignitor Lighting Remove cooking grid. Press ignitor button rapidly . “Click” should be heard and spark seen each time between burner and electrode. Replace cooking grid. See T roubleshooting if no click or spark. 1. Push regulator/valve counterclockwise to “PUSH T O [...]

22 • Grill2Go Match Lighting 1. Push Regulator/V alve in and turn counterclockwise to LIGHTING POSITION. 2. Attach match to match lighting stick, light match. 3. Insert match lighting stick into vent hole at rear of grill. WARNING If burner does not light within 5 seconds, turn knob to OFF, wait 5 minutes, try again. Burner Flame Check Before You[...]

Grill2Go • 23 General Grill Cleaning Do not apply a caustic grill/oven cleaner to painted surfaces. Plastic Side Shelves: • Non-Stick Cooking Surface: • Grease Bottle: • Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a stro[...]

24 • Grill2Go CA UTION Clean burner prior to use after storing, at the beginning of grilling season or after a period of one month not being used. Spiders and insects like to build nests in burner tubes (especially during colder months). These nests can cause fires in burner tubes or under grill. Typical spider webs inside burner. Cleaning the Bu[...]

Grill2Go • 25 Food Safety Clean: Separate: Cook: Chill: How to Tell if Meat is Grilled Thoroughly • • • • • Food safety is an important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: W ash hands, utensils, and surfaces with hot soapy water before and after handli[...]

26 • Grill2Go Troubleshooting Problem Burner will not light using ignitor. Burner will not match light. Flames blow out. Flashback (fire in burner tube) Possible Cause Electrode and burner are wet. Electrode cracked or broken, "sparks at crack". Wire is loose or disconnected. Wire is shorting (sparking) between ignitor and electrode. Ba[...]

Grill2Go • 27 Recreational Vehicles THERMOS GRILLS has approved use of the Grill2Go™ with specific recreational vehicles subject to the following provisions: • The is to be directly connected to an additional 20 lb. or 30 lb. DOT/TC LP tank mounted on the RV . The cannot be attached to any part of the gas system of the RV except directly to t[...]

® A Division of W.C. Bradley Company P .O. Box 1240 Columbus, GA 31902–1240 Certified Grill Parts And Accessories®, Char-Broil and Design®, Char-Broil (Gas Grill Briquettes)®, Char-Diamonds®, Cooking Zone and Design®, Diamond Flame®, Executive Chef®, Faststart®, Flare Fighter®, FlavorMaster®, Gas Grill Silouette and Design®, H2O Smoke[...]