Pride Mobility SC63/SC64 manuale d’uso

REV O[...]

Copyright © 2008 Pride Mobility Products Corp. INFMANU2427/Rev H/April 2008 SAFETY GUIDELINES NOTE: This owner ’ s manual is compiled from the latest specifications and product information avail- able at the time of publication. W e reserve the right to make changes as they become necessary . Any changes to our products may cause slight variatio[...]

3 www .pridemobility .com Revo CONTENTS I. INTRODUCTION ......................................................................................................................... 4 I I . SAFETY ......................................................................................................................................... 5 III. Y OUR SCOO T[...]

4 www .pr idemobility .com Revo I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The product you have purchased combines state-of the-art components with safety , comfort, and styling in mind. W e are confident the design features will provide you with the conveniences you expect during your daily activities. Understan[...]

5 www .pridemobility .com Revo II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the scooter to identify warnings, mandatory actions, and prohibited actions. It is very important for you to read and understand them completely . Maximum seating weight. Pinch/Crush points cr eated during assembly . Cor rosiv e chemicals contained in bat[...]

6 www .pr idemobility .com Revo II. SAFETY Front-to-rear plug orientation. Do not remove anti-tip wheels. Av oid exposure to rain, snow , ice, salt, or standing wa ter whenev er possible . Maintain and store in a clean and dr y condition. Remo val of g rounding pr ong can cr eate electrical hazard. If necessar y , proper ly install an approved 3-pr[...]

7 www .pridemobility .com Revo Wear safety goggles. Contains Lead. Keep your hands away from the tires when driving. Be aware that loose fitting clothing can become caught in drive tires. II. SAFETY Explosive conditions exist! Do not allow unsuper vised children to play near the scooter while the batteries are charging. Batter y charger for indoor [...]

8 www .pr idemobility .com Revo Do not lift the mobility vehicle while seated in it. Do not lift the mobility vehicle while seated in it. II. SAFETY[...]

9 www .pridemobility .com Revo II. SAFETY GENERAL Y our scooter is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an exten- sive variety of products to best fit the individual needs of the scooter user . Please be aware that the final selection and purchasing decision regarding the type of scooter to be us[...]

10 www .pr idemobility .com Revo II. SAFETY Perform the following inspections prior to using your scooter: ! Check for proper tire inflation. Maintain but do not exceed the psi/bar/kPa air pressure rating indicated on each tire if equipped with pneumatic tires. ! Check all electrical connections. Make sure they are tight and not corroded. ! Check a[...]

11 www .pridemobility .com Revo II. SAFETY When climbing an incline, try to keep your scooter moving. If you must stop, start up again slowly , and then accelerate cautiously . When driving down an incline, do so by setting the speed adjustment dial to the slowest setting and driving in the forward direction only . If your scooter starts to move do[...]

12 www .pr idemobility .com Revo II. SAFETY CORNERING INFORMA TION Excessively high cornering speeds can create the possibility of tipping. Factors which affect the possibility of tipping include, but are not limited to, cornering speed, steering angle (how sharply you are turning), uneven road surfaces, inclined road surfaces, riding from an area [...]

13 www .pridemobility .com Revo II. SAFETY OUTDOOR DRIVING SURF A CES Y our scooter is designed to provide optimum stability under normal driving conditions—dry , level surfaces com- posed of concrete, blacktop, or asphalt. However , Pride recognizes that there will be times when you will encoun- ter other surface types. For this reason, your sco[...]

14 www .pr idemobility .com Revo II. SAFETY FREEWHEEL MODE Y our scooter is equipped with a manual freewheel lever that, when engaged, allows the scooter to be pushed. For more information about how to place your scooter into and out of freewheel mode, see III . “Y our Scooter .” WARNING! When your scooter is in freewheel mode, the braking syst[...]

15 www .pridemobility .com Revo II. SAFETY ELEV A T ORS Modern elevators have a door edge safety mechanism that, when pushed, reopens the door(s). ! If you are in the doorway of an elevator when the door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contact the scooter and the door will reopen. ! Use care that poc[...]

16 www .pr idemobility .com Revo II. SAFETY GETTING ONT O AND OFF OF Y OUR SCOO TER Getting onto and off of your scooter requires a good sense of balance. Please observe the following safety tips when getting onto and off of your scooter: ! Remove the key from the key switch. ! Ensure that your scooter is not in freewheel mode. See III. “Y our Sc[...]

17 www .pridemobility .com Revo II. SAFETY PRESCRIPTION DR UGS/PHYSICAL LIMIT A TIONS The scoo ter user must exercise care and common sense when operating his/her scooter . This includes awareness of safety issues when taking prescribed or over-the-counter drugs or when the user has specific physical limitations. WARNING! Consult your physician if [...]

18 www .pr idemobility .com Revo II. SAFETY WARNING! The addition of accessories or components to the electrically-powered mobility vehicle can increase the susceptibility of the vehicle to EMI. Do not modify your scooter in any way not authorized by Pride. WARNING! The electricall y-po wered mobility vehic le itself can disturb the perfor mance of[...]

19 www .pridemobility .com Revo III. YOUR SCOO TER TILLER CONSOLE The tiller console houses all of the controls needed to drive your scooter , including the speed adjustment dial, key switch, status LED, throttle control lever , battery condition meter , running lights switch, and horn buttons. See figure 4. PROHIBITED! Do not expose the tiller con[...]

20 www .pr idemobility .com Revo III. YOUR SCOO TER Horn Buttons These buttons activate a warning horn. Y our scooter must be turned on for the horn to be operational. Do not hesitate to use the warning horn when doing so may prevent accident or injury . Status LED The status LED will alert you to electrical problems that may occur with the scooter[...]

21 www .pridemobility .com Revo Battery Packs The scooter is equipped with two easy-to-remove battery packs. The packs contain the charger power cord receptacle, the main circuit breaker (reset button), and the batteries. The batteries store electrical energy that powers your scooter . See IV . “Batteries and Charging.” Charger P ower Cor d Rec[...]

22 www .pr idemobility .com Revo PROHIBITED! Ne v er use an extension cord to plug in your batter y charger . Plug the charger directly into a properly wired standard electrical outlet. PROHIBITED! Removal of the grounding prong can create an electrical hazard. If necessar y , proper ly install an a ppro v ed 3-pronged adapter to an electrical outl[...]

23 www .pridemobility .com Revo Figure 8. Charger Power Cord Receptacle I V. B A TTERIES AND CHARGING T o charge the batteries with the battery packs installed on the scooter: 1. Position the rear of your scooter close to a standard electrical outlet. 2. Remove the key from the key switch. 3. Make sure that the manual freewheel lever is in the driv[...]

24 www .pr idemobility .com Revo I V . B A TTERIES AND CHARGING How does the charger work? When your scooter ’ s battery voltage is low the charger works harder , sending more electrical current to the batteries to bring up their charge. As the voltage approaches full charge, the char ger sends less and less electrical current to the batteries. W[...]

25 www .pridemobility .com Revo I V . B A TTERIES AND CHARGING ! Always fully char ge your scooter ’ s batteries prior to daily use. ! Maintain but do not exceed the psi/bar/kPa air pressure rating indicated on each tire for pneumatic tires. ! Plan your route ahead to avoid as many hills, cracked, broken, or soft surfaces as possible. ! Limit you[...]

26 www .pr idemobility .com Revo I V . B A TTERIES AND CHARGING Figure 9. Battery Replacement BA TTER Y TERMINAL BA TTER Y TERMINAL BA TTER Y PA CK CO VER BA TTER Y CABLE BA TTER Y CABLE NOTE: If you encounter a damaged or cracked battery , immediately enclose it in a plastic bag. Contact your local waste disposal agency and/or your authorized Prid[...]

27 www .pridemobility .com Revo What about public transportation? If you intend to use public transportation with your scooter , you must contact the transportation provider in ad- vance to determine their specific requirements. I V . B A TTERIES AND CHARGING Follow these steps to properly break in your scooter ’ s new batteries for maximum effic[...]

28 www .pr idemobility .com Revo V . OPERA TION BEFORE GETTING ONT O Y OUR SCOO TER ! Have you fully char ged the batteries? See IV . “Batteries and Charging.” ! Is the manual freewheel lever in the drive (rearward) position? Never leave the manual freewheel lever pushed forward unless you are manually pushing your scooter. ! Is the tiller lock[...]

29 www .pridemobility .com Revo V . OPERA TION GETTING OFF OF Y OUR S CO O T ER 1. Bring your scooter to a complete stop. 2. Power down your scooter and remove the key from the key switch. 3. Disengage the seat rotation lever and rotate the seat until you are facing toward the side of your scooter. 4. Make certain that the seat is fixed securely in[...]

30 www .pr idemobility .com Revo VI. COMFORT ADJUSTMENTS TILLER ANGLE ADJUSTMENT Y our scooter is equipped with an adjustable pivoting tiller . 1. While supporting the tiller , t urn the tiller adjustment knob counterclockwise to loosen the tiller . See figure 1 0 . 2. Move the tiller to a comfortable position. 3. Turn the tiller angle adjustment k[...]

31 www .pridemobility .com Revo VI. COMFORT ADJUSTMENTS SEA T HEIGHT ADJUSTMENT The seat can be repositioned to one of three different heights. See figure 12. 1. Remove the seat from your scooter . See VII. “Disassembly and As- sembly .” 2 . Use the attached ring to pull and remove the detent pin from the lower seat post. 3. Raise or lower the [...]

32 www .pr idemobility .com Revo VII. DISASSEMBL Y AND ASSEMBL Y Figure 15. Battery Pack Removal/Installation Figure 16. Front-T o-Rear Harness LEFT BA TTER Y P ACK LOCK LEFT BA TTER Y P A CK # Figure 14. Tiller Lock Knob SHOWN IN UNLOCKED POSITION Figure 13. Scooter Components REAR SECTION FRONT SECTION BA TTER Y PACKS SEA T NOTE: When DISASSEMBLI[...]

33 www .pridemobility .com Revo T oggle Latch Release 1. Push in the toggle latch release button while pulling back the toggle latch. See figures 17 and 17A. 2. Secure the toggle latch buckle over the top of the toggle latch. See figure 17B. 3. Grab the hand grip on the tiller , loosen the tiller adjustment knob, and gently lower the tiller down to[...]

34 www .pr idemobility .com Revo ASSEMBL Y 1 . Position the front and rear sections of your scooter. See figure 19. 2. Align the locking brackets of the front section with the corresponding pegs on the front of the rear section. 3 . Holding the seat post, slowly pivot the rear section forward until the locking brackets are fully connected onto the [...]

35 www .pridemobility .com Revo VIII. BASIC TROUBLESHOO TING Any electromechanical device occasionally requires some troubleshooting. However , most of the problems that may arise can usually be solved with a bit of thought and common sense. Many of these problems occur because the batteries are not fully charged or because the batteries are worn d[...]

36 www .pr idemobility .com Revo What if the main circuit breaker repeatedly trips? ! If the main circuit breaker repeatedly trips, see your authorized Pride Provider for service. ! Charge the batteries more frequently . See IV . “Batteries and Charging.” ! If the problem continues, have both batteries load tested by your authorized Pride Provi[...]

37 www .pridemobility .com Revo IX. CARE AND MAINTENANCE Y our scooter requires a minimal amount of care and maintenance. If you do not feel confident in your ability to perform the maintenance listed below , you may schedule inspection and maintenance at your authorized Pride Provider . The following areas require periodic inspection and/or care a[...]

38 www .pr idemobility .com Revo IX. CARE AND MAINTENANCE WIRING HARNESSES ! Regularly check all wiring connections. ! Regularly check all wiring insulation, including the charger power cord, for wear or damage. ! Have your authorized Pride Provider repair or replace any damaged connector , connection, or insulation that you find before using your [...]

39 www .pridemobility .com Revo LIGHT BULB REPLA CEMENT The scooter ’ s light bulbs are easily replaceable. Do not use regular automotive-type 12-volt light bulbs; your scooter is equipped with a 24-volt electrical system. Replacement light bulbs can be purchased from your authorized Pride Provider . NOTE: Use only 24-volt light bulbs. 1 . Remove[...]

40 www .pr idemobility .com Revo THREE-YEAR LIMITED WARRANTY For three (3) years from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of charge, any of the following parts found upon examination by an authorized representative of Pride to be defective in material and/or workmanship: S tructural Fram[...]

41 www .pridemobility .com Revo X. WARRANTY ! Circumstances beyond the control of Pride ! Labor , service calls, shipping, and other charges incurred for repair of the product, unless specifically autho- rized, IN ADV ANCE, by Pride Mobility Products Corporation ! Repairs and/or modifications made to any part without specific consent from Pride Exc[...]

42 www .pr idemobility .com Revo T urning Radius (82 cm - 87 cm) 32.25 in.- 34.25 in. 12 in. (30.5 cm) 17-19 in. (43-48 cm) 2.25 in. (6 cm) 3-wheel 43.25 in. (110 cm) 4-wheel 44.75 in. (114 cm) 3-wheel 38 in. (96.5 cm) 4-wheel 50 in. (127 cm) 21.5 in. (55 cm) 16 in. (41 cm) 17 in. (43 cm) 17.24 in. (44 cm) Figure 21. Scooter Dimensions APPENDIX I -[...]

43 www .pridemobility .com Revo APPENDIX I - SPECIFICA TIONS Model Numbers 3-wheel: SC63; 4-wheel: SC64 Available Colors Revo Red, Revo Blue Overall Length 2 3-wheel: 43.25 in. (1 10 cm) 4-wheel: 44.75 in. (1 14 cm) Overall Width 2 21.5 in. (55 cm) T otal W eight Including Battery Packs 3-wheel: 168.5 lbs. (76 kg) 4-wheel: 187 lbs. (85 kg) T otal W[...]

44 www .pr idemobility .com Revo NO TES[...]

45 www .pridemobility .com Revo NO TES[...]

46 www .pr idemobility .com Revo NO TES[...]

*INFMANU2427*[...]