Pride Mobility INFMANU1743 manuale d’uso

The Ultimate In S tyle & Performance ® E x e t e r , P A S t . Catharines, ON 1-800-800-8586 w w w .pridemobility .c om Owner ’ s Manual[...]

2 Maxima INFMANU1743/REV C/OCTOBER 2002 SAFETY GUIDELINES Copyright © 2002 Pride Mobility Products Corp. Please read and follow all instructions in this owner s manual before attempting to operate your scooter for the first time. If there is anything in this manual you do not understand, or if you require additional assistance for setup, contac[...]

Maxima 3 CONTENTS I . INTRODUCTION ......................................................................................................................... 4 I I . SAFETY ............................................................................................................................... .......... 6 III. EMI/RFI ........................[...]

4 Maxima W elcome to Pride Mobility Products Corporation (Pride). Congratulations on the purchase of your new Pride Scooter . Y ou r s cooter design combines the most advanced state-of-the-art components with modern, attractive styling. W e are cer tain tha t the des ign fea ture s and trouble-free operation of your scooter will add convenience to [...]

Maxima 5 I. INTRODUCTION Pride Owners Club As a Pride product owner , you are invited to register your product s warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed registration card or by visiting Pride s web site at www .pridemobility .com . As a registered member , each time you visit our[...]

6 Maxima II. SAFETY GENERAL WARNING! Do not operate your new scooter for the first time without completely reading and understanding this owners manual. Y our scooter is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an exten- sive variety of products to best fit the individual needs of the scooter user[...]

Maxima 7 II. SAFETY PRE-RIDE SAFETY CHECK Get to know the feel of your scooter and its capabilities. Pride recommends that you perform a safety check before each use to make sure your scooter operates smoothly and safely . For details on how to perform these necessary inspections, see XII. Care and Maintenance. Perform the following inspectio[...]

8 Maxima II. SAFETY 5˚ 6˚ 7˚ 200-250 lbs. 300-350 lbs. 150 lbs. 5˚ 6˚ 7˚ 250 lbs. 300-350 lbs. 200 lbs. 8˚ 150 lbs. 4.5˚ 4.5˚ 400 lbs. 400 lbs. FIGURE 1. MAXIMUM RECOMMENDED INCLINE FOR THE 3-WHEEL MAXIMA FIGURE 2 MAXIMUM RECOMMENDED INCLINE FOR THE 4-WHEEL MAXIMA When climbing an incline, try to keep your scooter moving. If you must stop,[...]

Maxima 9 FIGURE 4. INCREASED ST ABILITY DRIVING POSITION FIGURE 3. NORMAL DRIVING POSITION When you approach an incline, it is best to lean forward. See figures 3 and 4. This shifts the center of gravity of you and your scooter toward the front of the scooter for improved stability . WARNING! Do not exceed the incline guidelines or any other specif[...]

10 Maxima BRAKING INFORMA TION Y our scooter is equipped with two powerful brake systems: 1. Regenerative: Uses electricity to rapidly slow the vehicle when the throttle control lever returns to the center/ stop position; and 2. Disc Park Brake: Activates mechanically after regenerative braking slows the vehicle to near stop, or when power is remov[...]

Maxima 11 FREEWHEEL MODE Y our scooter is equipped with a manual freewheel lever , that when pulled up, allows the scooter to be pushed. Fo r more information about how to place your scooter into and out of freewheel mode, see V . Y our Maxima. TIRE INFLA TION If your scooter is equipped with pneumatic tires, you should check or have the air [...]

12 Maxima DOORS n Determine if the door opens toward or away from you. n Use your hand to turn the knob or push the handle or push-bar . n Drive your scooter gently and slowly forward to push the door open. Or drive your scooter gently and slowly backwards to pull the door open. ELEV A TORS Modern elevators have a door edge safety mechanism that, w[...]

Maxima 13 MO TO R VEHICLE TRANSPORT Currently , there are no standards approved for tie-down systems in a moving vehicle of any type to transport a person while seated in a scooter . Although your scooter may be equipped with a positioning belt, this belt is not designed to provide proper restraint during motor vehicle transport. Anyone traveling i[...]

14 Maxima REACHING AND BENDING A void reaching or bending while driving your scooter . When reaching, bending, or leaning while seated on your scooter , it i s important to maintain a stable center of gravity and keep the scooter from tipping. Pride recommends that the scooter user determine his/her personal limitations and practice bending and rea[...]

Maxima 15 EMI/RFI WARNINGS Laboratory tests performed by the Food and Drug Administration (FDA) have shown that radio waves can cause unintended motion of electric scooters. Radio waves are a form of electromagnetic energy (EM). When electro- magnetic energy adversely affects the operation of an electrical device, that adverse effect is called Elec[...]

16 Maxima What is the FDA doing about the problem? The FDA has written to electric scooter manufacturers and requested that those manufacturers test their new models of scooters to be certain that they provide a reasonable degree of resistance against EMI/RFI. The FDA has stated that all newly manufactured models of electric scooters should have a [...]

Maxima 17 24 " 54" 43 " 20 " 16" 24"- 28 " 47 " 48 " 4 Wheel T urning Radius 4 Wheel Length 3 Wheel Length 3 Wheel T urning Radius 4.5 " " 8 "- 12 18.5" " 1 42 " 46 " - 22.5 " 18.5 " - FIGURE 5. MAXIMA DIMENSIONS IV . SPECIFICA TIONS[...]

18 Maxima Model Numbers SC-400HD (3-w heel), SC-440HD ( 4-wheel) Length 47 i n . (3-wheel ), 48 i n. (4-wheel ) Width 24 in. Tires Pneum atic: fron t : 4 in. x 9 in . rear: 4 in. x 10 in. Weight Capacity 400 lbs. maximum Battery Type (Batteries not included) Two 12V , 32 AH, U-1 type, SLA (sealed lead-acid) Horsepower 1.4 h p ( peak) Charger Onb oa[...]

Maxima 19 Y our Maxima is a motorized electric scooter designed to enhance your personal mobility . Y our Maxima is an indoor/outdoor scooter that was designed to travel primarily on smooth surfaces such as sidewalks, roads, parking lots, floors, and driveways. For easy transportation or storage, you can disassemble your Maxima into five (5) compon[...]

20 Maxima K ey Switch n Fully insert the key into the key switch to power up (turn on) your Maxima. n Pull the key out to power down (turn off) your Maxima. Speed Adjustment Dial This dial allows you to preselect and limit your Maxima s top speed. n The image of the tortoise represents the slowest speed setting. n The image of the hare represent[...]

Maxima 21 REAR SECTION The onboard battery char ger , the charger power cord, the batteries, the electronic controller assembly , the main circuit breaker , the manual freewheel lever , and the motor/transaxle assembly are located beneath the shroud on the rear section of your Maxima. See figures 8 and 9. Refer to IX. Disassembly and Assembly[...]

22 Maxima Main Cir cuit Brea ker When the voltage in your Maxima s batteries becomes low or your Maxima is heavily strained because of exces- sive loads or steep inclines, the main circuit breaker may trip to protect your Maxima s motor and electronics from damage. n The main circuit breaker (reset button) is mounted on the electronic control[...]

Maxima 23 Y our Maxima is equipped with two long-lasting, 12-volt, deep-cycle batteries that are sealed and maintenance free. They are recharged by an onboard 3-amp charging system designed for ease of use and convenience. n Char ge your Maxima s batteries prior to using it for the first time. n Keep your batteries fully charged to keep your Max[...]

24 Maxima BA TTERIES AND CHARGING-FREQUENTL Y ASKED QUESTIONS (F AQS) How does the charger work? When your Maxima s battery voltage is low , the char ger works harder and sends more electrical current to the batteries to bring up their char ge. As the voltage of the batteries approaches a full charge, the charger sends less and less electrical c[...]

Maxima 25 How can I get maximum range or distance per charge? Rarely will you have ideal driving conditions: smooth, flat, hard driving surfaces with no wind or curves. Y ou will often face hills, sidewalk cracks, uneven and loosely packed surfaces, curves, and wind. All of these driving conditions affect the distance or running time per battery ch[...]

26 Maxima W e work closely with our battery manufacturer to provide batteri es that best suit your Maxima s specific electrical demands. Fresh batteries arrive daily at Pride and are shipped fully charged to our customers. During shipping, the batteries may encounter temperature extremes that may influence their initial performance. Heat diminis[...]

Maxima 27 VII. OPERA TION BEFORE GETTING ON Y OUR MAXIMA n Fully charge the batteries See VI. Batteries and Charging. n Push the manual freewheel lever to the drive (down) position Never leave the manual freewheel lever pulled up unless you are manually pushing your Maxima. GETTING ONTO Y OUR MAXIMA 1. Make certain that the key is removed fro[...]

28 Maxima VII. OPERA TION WHETHER Y OU ARE DRIVING FORWARD OR IN REVERSE n Pull on the left handgrip to steer your Maxima to the left. n Pull on the right handgrip to steer your Maxima to the right. n Move the tiller to the center position to drive straight ahead. n Release the throttle control lever to decelerate and come to a complete stop. n The[...]

Maxima 29 TILLER ANGLE ADJUSTMENT is in motion. Y ou can adjust the tiller to any number of positions be- tween the forward stop and the scooter deck. 1. Pull up on the tiller adjustment lever . See figure 13. 2. Move the tiller to a comfortable position. 3. Release the tiller adjustment lever . The tiller remains in that position. SEA T HEIGHT ADJ[...]

30 Maxima VIII. COMFORT ADJUSTMENTS ARMREST HEIGHT ADJUSTMENT Y ou will need the following tools to adjust the height of the armrests:  5/32 Hex Key 1/8 Hex Key  7/16 W rench 1 . Loosen the setscrew on the side of the height adjustment tube with the 1/8 hex key . 2. Loosen and remove the acorn nut and screw hold- ing the height[...]

Maxima 31 FIGURE 17. POWER SEA T ACTUAT OR (OPTIONAL) SEA T ACTUA T OR WARNING! The power seat actuator is intended for operation only while the vehicle is stationar y and on a level surfac e. Its pur pose is to aid you in reaching objects. Strict adherence to the following safety rules is vital to your safety: Do not attempt to raise or lower the [...]

32 Maxima IX. DISASSEMBL Y AND ASSEMBL Y No tools are required to disassemble or assemble your Maxima. Always disassemble or assemble your Maxima on a level, dry surface with sufficient room for you to work and move around your scooter . Keep in mind that the disassembled sections of the Maxima take up more floor space than the assembled Maxima. DI[...]

Maxima 33 For information concerning these accessories, contact your authorized Pride provider . X. OPTIONAL ACCESSORIES WALKER HOLDER SINGLE CANE/CRUTCH HOLDER FOREARM CRUTCH HOLDER DOUBLE CANE/CRUTCH HOLDER OXYGEN TANK HOLDER REAR BASKET CUP HOLDER SAFETY FLAG FRONT BASKET REAR BUMPER[...]

34 Maxima Any electromechanical device occasionally requires some troubleshooting. However , most of the prob lems that may arise can usually be solved with a bit of thought and common sense. Many of these problems occur because the batteries are not fully charged, or because the batteries are worn down and can no longer hold a charge. What if all [...]

Maxima 35 XII. CARE AND MAINTENANCE Y our Maxima requires a minimal amount of care and maintenance. If you do not feel confident in your ability to perform the maintenance listed below , you may schedule inspection and maintenance at your authorized Pride provider . TIRE PRESSURE n W e recommend that the tire pressure be maintained at 30-35 psi . T[...]

36 Maxima XIII. WARRANTY THREE-YEAR LIMITED WARRANTY Three years on all structural frame components; including platform, fork, seat post, and frame. Three-year prorata drive train warranty; including transaxle, motor , and brake. n First year: 100% replacement of parts cost n Second year: 67% replacement of parts cost n Third year: 50% replacement [...]

Maxima 37 XIII. WARRANTY There is no other express warranty . Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one (1) year from the date of original purchase and to the extent permitted by law . Any and all implied warranties are excluded. This is the exclusive remedy . Liabilities for con[...]