Monessen Hearth CSDV20DLP manuale d’uso

         ?[...]

2 58D6056 CSD V Se ries Direct V e nt Gas Sto ve       ?[...]

58D6056 3 CSD V Se ries Direct V e nt Gas Sto ve 4. Never install the stove • in a recreational vehicle • where curtains, furniture, clothing, or other flam- mable objects are less than 42" from the front, top, or sides of the stove • in high traffic areas • in windy or drafty areas 5. This stove reaches high temperatures. Keep childre[...]

4 58D6056 CSD V Se ries Direct V e nt Gas Sto ve    15. This appliance, when installed, must be electrically grounded in accordance with local codes or in the absence of local codes, with the National Electrical Code, ANS/NFP A 70 , or the Canadian Electrical Code, [...]

58D6056 5 CSD V Se ries Direct V e nt Gas Sto ve     • This appliance has been certified for use with either natural or propane gas. See appropriate data plates. • This appliance is not for use with solid fuels. • The applia[...]

6 58D6056 CSD V Se ries Direct V e nt Gas Sto ve  A B C 586056 CSDV dims     A 20 M, " (530 mm) 26 Zx " (673 mm) 29 Zx " (749 mm) B 23 Zx " (597 mm) 28 Zx " (724 mm) 30 Zx " (775 mm) C 18 Cv[...]

58D6056 7 CSD V Se ries Direct V e nt Gas Sto ve       Plan for the installation of your stove. This includes deter- mining where the unit is to be installed, the vent configura- tion to be used, framing and finishing details, and wheth[...]

8 58D6056 CSD V Se ries Direct V e nt Gas Sto ve       Figures 4 and 5   ?[...]

58D6056 9 CSD V Se ries Direct V e nt Gas Sto ve  ON OFF A C B ST1 132 alcove clearances Figure 5 - Alcove Clearances ST1 132  ?[...]

10 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 1. Remove two (2) straps. Figure 6 2. Open plastic bag and slide to bottom of unit. Figure 7 3. Lift up on ash lip and pivot down to open control door . Figure 8 4. Lift up on front. Pivot bottom of front out. Remove front. Figure 8 5. Open and remove glass door . 6. Remove log box from inside of un[...]

58D6056 1 1 CSD V Se ries Direct V e nt Gas Sto ve               [...]

12 58D6056 CSD V Se ries Direct V e nt Gas Sto ve       There are two basic types of direct-vent installation: • Horizontal T ermination • V ertical T ermination It is important to select the proper length of vent pip[...]

58D6056 13 CSD V Se ries Direct V e nt Gas Sto ve    V V V V V V V X X X D E B B B C B M B A J K F L VENT TERMINA TION AIR SUPPL Y INLET AREA WHERE TERMINAL IS NOT PERMITTED H I Fixed Closed Operable Operable Fixed Closed V B CFM145a DV T ermin Location 5/01/01 Rev . 12/05/01 sta INSIDE[...]

14 58D6056 CSD V Se ries Direct V e nt Gas Sto ve Outside Corner Inside Corner T ermination Clearances T ermination clearances for buildings with combustible and noncombustible exteriors. G = Combustible 6" (152 mm) Noncombustible 2" (51 mm) F = Combustible 6" (152 mm) Noncombustible 2" (51 mm) G Balcony - with no side wall M = [...]

58D6056 15 CSD V Se ries Direct V e nt Gas Sto ve          1. Determine the route your horizontal venting will take.  The location of the horizontal [...]

16 58D6056 CSD V Se ries Direct V e nt Gas Sto ve    9 Zx " (241 mm) 9 Zx " (241 mm)    Framing Detail  [...]

58D6056 17 CSD V Se ries Direct V e nt Gas Sto ve HOT H V ST1 139 Horizontal termination    Figure 21 - Horizontal T ermination Configuration for Rigid V enting Using One (1) 90° Elbow ST1 139    [...]

18 58D6056 CSD V Se ries Direct V e nt Gas Sto ve    HOT H 1 V 1 H V ST1 141 Horiz term 3 elbows Figure 23 - Horizontal T ermination Configuration for Rigid V enting Using Three (3) 90° Elbows with T ermination at 90° to Stove  [...]

58D6056 19 CSD V Se ries Direct V e nt Gas Sto ve    Drop a plumb line from the inside of the roof to the locat- ing hole in the ceiling. Mark the center point where the vent will penetrate the roof. Drill a small locating hole at this point.  ?[...]

20 58D6056 CSD V Se ries Direct V e nt Gas Sto ve 3. Lower the support box through the hole in the roof until the bottom of the box extends at least 2" ( mm) below the ceiling. Figure 27. Align the support box vertically and horizontally using a level. T emporarily tack the sup- port box in place through the inside walls and into the roof shee[...]

58D6056 21 CSD V Se ries Direct V e nt Gas Sto ve    H V V 1 ST1 146 vert vent 2 elbows  Install restrictor into 4" collar of stove or f i r s t v e nt s e c t i o n as shown.    ?[...]

22 58D6056 CSD V Se ries Direct V e nt Gas Sto ve     Use proper gas type for the fireplace you are installing. If you have conflicting gas type, do not install fireplace. See dealer where you purchased the fireplace for proper fireplace according to [...]

58D6056 23 CSD V Se ries Direct V e nt Gas Sto ve      The gas line connection may be made using 1/2" rigid tubing or an approved flex connector . Since some municipalities have additional local codes it is always best to consult your local authorities and the curren[...]

24 58D6056 CSD V Se ries Direct V e nt Gas Sto ve     1. Check gas type. The gas supply must be the same as stated on the appliance’s rating decal. If the gas supply is dif ferent from the fireplace, ?[...]

58D6056 25 CSD V Se ries Direct V e nt Gas Sto ve   A remote wall switch and up to fifteen (15) feet of 18 Ga. wire may be used with this appliance. Attach the wall switch in a junction box at the desired location on the wall. Figure 35 . Do not extend beyond the wall swi[...]

26 58D6056 CSD V Se ries Direct V e nt Gas Sto ve     — This unit is supplied with ceramic fiber logs. Do not handle these logs with your bare hands.      ?[...]

58D6056 27 CSD V Se ries Direct V e nt Gas Sto ve  Figure 38 1. Carefully remove logs from wrapping. 2. Open front door of firebox. 3. Place rear log (#1) on rear log pin. 4. Place left base log (#2) on the two pins against left side of firebox. 5. Place right base [...]

28 58D6056 CSD V Se ries Direct V e nt Gas Sto ve   Figure 40 1. Carefully remove logs from wrapping. 2. Open front door of firebox. 3. Place rear log (#1) on rear log pins. 4. Place left base log (#2) on the two pins against l[...]

58D6056 29 CSD V Se ries Direct V e nt Gas Sto ve    This appliance is equipped with a pilot which must be lit by hand while following these instructions exactly .  BEFORE OPERA TING smell all around the appliance area for gas. Be sure to smell next to the floor bec[...]

30 58D6056 CSD V Se ries Direct V e nt Gas Sto ve        ?[...]

58D6056 31 CSD V Se ries Direct V e nt Gas Sto ve   O F F P I L O T O N PILOT FP1937 control knob on  The “ON/OFF” switch for the main burner can be found on the back right side of the stove. This switch allows you to turn [...]

32 58D6056 CSD V Se ries Direct V e nt Gas Sto ve       The venturi of the burner is equipped with an air shutter . The opening of the venturi has be[...]

58D6056 33 CSD V Se ries Direct V e nt Gas Sto ve  Make sure the gas valve knob is in the “OFF” position. W ait at least five (5) minutes before start-ing maintenance.  A qualified agency should examine the venting system annually .[...]

34 58D6056 CSD V Se ries Direct V e nt Gas Sto ve               ?[...]

58D6056 35 CSD V Se ries Direct V e nt Gas Sto ve           ?[...]

36 58D6056 CSD V Se ries Direct V e nt Gas Sto ve   18 19 20 17 3 4 13 12 15 16 5 2 8 9 1 6 10 14 1 1 7 586056 CSDV20 parts [...]

58D6056 37 CSD V Se ries Direct V e nt Gas Sto ve         1. Burner Assembly 1 58D0250 58D0250 2. Log Support Bracket 1 58D0210 58D0210 3. Pilot Assembly 1 37D0018 37D0019 4. SIT 820[...]

38 58D6056 CSD V Se ries Direct V e nt Gas Sto ve   18 19 20 21 22 17 3 4 13 12 16 5 1 1 2 15 1 14 6 10 8 7 9 586056 CSDV30 parts [...]

58D6056 39 CSD V Se ries Direct V e nt Gas Sto ve         1. Burner Assembly 1 58D0150 58D0150 2. Log Support Bracket 1 58D0024 58D0024 3. Pilot Assembly 1 37D0018 37D0019 4. SIT 820[...]

40 58D6056 CSD V Se ries Direct V e nt Gas Sto ve   22 23 16 24 25 26 28 4 5 14 13 7 6 2 3 2 17 20 18 19 8 1 1 15 9 10 12 21 586056 CSDV40 parts [...]

58D6056 41 CSD V Se ries Direct V e nt Gas Sto ve         1. Burner Assembly 1 58D0368 58D0368 2. Rear Burner Assembly 1 58D0362 58D0362 3. Log Support Bracket 1 58D0310 58D0310 4. P[...]

42 58D6056 CSD V Se ries Direct V e nt Gas Sto ve  This product must be installed by a licensed plumber or gas fitter when installed within the Commonwealth of Massachusetts. Any residence with a direct vent product must have a CO detector installed in the res[...]

58D6056 43 CSD V Se ries Direct V e nt Gas Sto ve MHSC warrants its products to be free of defects in material and workmanship and backs each product with a Limited Lifetime W arranty . This warranty is to the original purchaser of a MHSC product and is not transferable.   Covered under this warran[...]

 149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com[...]