Agri-Fab 2468 manuale d’uso

O WNERS MANU AL Model No. 502493 552493 Inc ludes Dec k Adapter #62468 CA UTION: Read Rules f or Saf e Oper ation and Instr uctions Carefully PRINTED IN U .S.A. FORM NO 41184 Re v . (04/23/09) CHIP-N-V A C Safety Assembl y Operating Maintenance Repair P arts[...]

2 T ABLE OF CONTENTS SAFETY R ULES ....................................................... 3,4 FULL SIZE HARD W ARE CHAR T ........................... 5,13 CAR T ON CONTENTS ................................................. 6 ASSEMBL Y .................................................................. 7 OPERA TION ..................................[...]

3 SAFETY Any po wer equipment can cause injury if operated improperly or if the user does not understand ho w to operate the equipment. Exercise caution at all times, when using po wer equipment. • Read and fo llow all instruct ions in this manual bef ore attemptin g to assemble or operate this equipment. F ailure[...]

4 W ARNING  • ReadOwner'sManualandallsafetylabelsonmac hinebeforestartingandusingmachine.  • DoNotremovetopco verorattempttoemptycontentsofcartwhileengineisrunning.  • DoNotstandbehindcar tinexhaustdisc hargearea?[...]

5 HARD W ARE P A CKA GE CONTENTS Seepage13fortheDec kAdapterhar dwarepac kage.(Contentsnotinc ludedhere.) K P H R M L I J G F E D C B A U V W Z AA X BB Y CC DD EE T SHO WN FULL SIZE Q S N O NO T SHO WN FULL SIZE REF . qTY DESCRIPTION CART VAC A 3 — He x Bolt, 3/8" x 3" B — 1 He x Bolt, 1/2" x 1[...]

6 CART ON CONTENTS (Mo w-N-V ac Car ton) CART ON CONTENTS (Cart Body Car ton) 3 1 2 4 8 12 11 7 9 5 10 13 6 10 5 8 1 7 2 3 4 6 9 REF . qTY DESCRIPTION 1 1 Wheel Suppor t 2 1 Rear T ongue 3 1 F ront T ongue 4 1 Hose Hanger Rod Assembly 5 2 Car t Body REF . qTY DESCRIPTION 6 1 Hose 7 1 T ailgate Reinf orcement Brac ket 8 1 Axle 9 1 Latch Stand Brac k[...]

7 ASSEMBL Y FIGURE 3 FIGURE 1 This unit is shipped WITHOUT GASOLINE or OIL. After assembly , see separate engine manual f or proper fuel and engine oil recommendations. CA UTION: Do not leave the cart unattended in upright position dur ing assembly . A falling car tcancausepersonalinjur y!Pa yclose attention to the stability of[...]

8 FIGURE 4 8. T o pre vent accidental tipping during the f ollowing assembly procedures , lower the cart to rest upside down, with the wheel support facing up , as shown in gure5. 9. Align the latch stand brac ket so that the tab is at the rear . F asten the brac ket to the rear set of holes at the front of the car t using two 1/4" x 5/8[...]

9 FIGURE 8 13. Flip the cart over so that it rests on its wheels . 14. Assemb le the front tongue on top of the rear tongue using three 3/8" x 3" he x bolts and 3/8" nyloc k nuts. Seegure8. HINT : F or easier assembly , suppor t the rear tongue with a bloc k of wood. 15. Assemb le the hitch brac ket to the front tongue us- i[...]

10 FIGURE 11 20.  Placeasidepanelontopofthecartbedange, inside the lip of the front panel. F asten the side panel to the front panel using three 1/4" x 5/8" he x bolts and 1/4" nyloc k nuts. F asten the side panel to the car t bedangeusingtwo1/4"x5/8"he xbolt[...]

11 25. Assemb le a shor t tar p strap to rear door using one 1/4"x1-1/4"he xbolt,two1/4"atwashersandone 1/4" nyloc k nut. Assemble an "S" hook through loose endofstrap . Seegure15. Repeatonothersideof door . 26. Assemb le door to rear of car t by r[...]

12 32.  Assemb lethehoseadapter(nozzle)tothefrontof the impeller housing and secure with the three knobs. Make sure that the s witch actuator brac ket contacts thes witchonthehousing. Seegure18. FIGURE 21 FIGURE 19 33. Place a hose clamp onto one end of hose . Push hose ontohoseadapter([...]

13 ContentsofHard wareP ackf orDeckAdapter: See Figure 22. Ke y qty . Description A 2 He x Bolt, 5/16" x 1-1/4" B 4 He x Bolt, 1/4" x 1" C 2 Carriage Bolt, 5/16" x 3/4" D 3 Nyloc k Nut, 5/16" E 5 Nylock Nut, 1/4" F 9 Flat Steel W asher , 1/4" Std. G 12 Flat W asher , 5/16" Std. H 5[...]

14 FIGURE 24 6. Holding the adapter brac ket and the dec k adapter together , position the dec k adapter on the mower deck. K eeping the edge of deck adapter as close as possible to the offset in the adapter br ack et, see if the slot in the adapter brac ket can be aligned with one ortwoofthedeectorholesiny ourmowerdec[...]

15 FIGURE 28 11. After car t is emptied, secure car t to tongue with latch and reattach the rear door and the vinyl boot. HO W T O USE Y OUR CHIP-N-V A C BEFORE ST ARTING 1. Y our Chip-N-V ac engine is shipped without oil or gasoline. Ser vice the Chip-N-V ac engine with oil and gas as instructed in the separate engine manual. 2. Inspect the Chip-N[...]

16 USING THE CHIPPER CHUTE 1. Material such as stalks or heavy branches up to 3" in diameter ma y be fed into the chipper chute as sho wn ingure29.  2. Be sure to wear e ye protection and glo ves when f eeding material into the chipper chute. 3. Use the tamper plug, not your hands , to f orce mater ial down through the chipper chut[...]

17 MAINTENANCE Ser vice Dates Chec k f or loose fasteners X Chec k soft vinyl boot X Chec k tire pressure X Chec k engine oil le vel X Lubricate X Clean X X Maintain engine per instructions below and in engine man ual. Before each use After each use Every season Before stor age CUST OMER RESPONSIBILITIES • Readandf ollowthemaintena[...]

18 ST ORA GE 3. If storing in an un ventilated or metal storage shed, coat metal par ts with light oil or silicone to prev ent rust. 4. Store unit in a clean, dry area. 1. Clean the engine and the entire unit thoroughly . 2. Ref er to engine manual f or correct engine storage instructions. SER VICE AND ADJUSTMENTS FIGURE 30 SHARPENING OR REPLA CING[...]

19 TR OUBLESHOO TING PROBLEM POSSIBLE CA USE(S) CORRECTIVE A CTION Engine fails to star t 1. Spar k plug wire disconnected. 1. Connect wire to spar k plug.   2. Saf etys witchnotcontacted.  2. Correctlyinstallhoseadapternozzle. 3. Fuel tank empty , or stale fuel. 3. Fill tank with clean, fresh fuel. 4. Fuel[...]

20 NO TES[...]

21 P ARTS REP AIR P ARTS FOR MODEL 502493/552493 CAR T BOD Y 11 11 4 1 2 11 1 3 5 A 5 8 6 8 7 10 9 12 12 12 13 13 28 28 15 23 A 16 17 18 19 20 21 22 24 25 26 27 28 24 14 REF . P ART NO . qTY DESCRIPTION 1 23985 2 Car t Body 2 62458 1 T ailgate Reinforcement Brac ket 3 23507 1 Wheel Suppor t 4 24497 1 Latch Stand Brac ket 5 24897 1 Wheel Axle , 1&qu[...]

22 REP AIR P ARTS FOR MODEL 502493/552493 CHIP-N-V A C 42 43 32 41 TO TRA CT OR 26 24 25 27 23 4 39 40 11 12 35 13 21 20 28 33 13 33 35 34 37 13 13 36 35 31 35 13 1 2 2 4 8 8 8 17 19 19 18 29 30 40 51 A 22 20 35 B B 4 13 5 8 13 8 13 13 8 40 40 40 40 40 35 35 35 35 44 44 44 12 12 12 47 45 46 47 48 50 49 AD APTER #62468 13 54 11 55,56,57,11 3 4 6 9 1[...]

23 REP AIR P ARTS FOR MODEL 502493/552493 CHIP-N-V A C REF . P ART NO . qTY DESCRIPTION 1 24080 1 Engine Base 2 24078 2 Housing Brace 3 24958 1 Hose Hanger Brac ket 4 43182 14 He x Bolt, 5/16-18 x 3/4" 5 43063 2 He x Bolt, 5/16-18 x 1" 6 43085 4 He x Bolt, 5/16-18 x 1-1/2" 7 731-1617 1 T amper Plug 8 47810 15 Nyloc k Nut, 5/16" [...]

24 REP AIR P ARTS FOR MODEL 502493/552493 CHIP-N-V A C IMPELLER HOUSING ASSEMBL Y 2 6 18 10 5 2 3 5 10 8 24 4 3 17 8 4 7 16 23 11 9 18 20 22 4 9 21 16 23 15 1 16 13 14 1 15 6 12 19 28 27 26 25 24 REF . P ART NO . qTY DESCRIPTION 1 629-0241A 1 Wire Har ness 2 63993 1 Inner Housing Assemb ly 3 24633 1 Outer Housing Assemb ly 4 43182 12 He x Bolt, 5/1[...]

25 A PO WER POLE A CORNER OF A BUILDING OR A FENCE POST FOLD ALONG DO TTED LINE, REPRESENTING A 10 DEGREE SLOPE SIGHT AND HOLD THIS LEVEL WITH A VER TICAL TREE SLOPE GUIDE (Keepthissheetinasaf eplaceforfutureref erence .) Use this guide to determine if a slope is safe for the operation?[...]

26 NO TES[...]

27 NO TES[...]

REP AIR P ARTS 809 South Hamilton Sulliv an, IL. 61951 217-728-8388 www .ag ri-fab .com © 2002 Agri-F ab , Inc. This document (or manual) is protected under the U .S . Cop yright Laws and the cop yright laws of f oreign countries, pursuant to the Univ ersal Copyright Conv ention and the Berne conv ention. No par t of this document ma y be reproduc[...]