Proline PLFW520 manual

Range Hoods For model numbers: PLFI520 / PLFW520 / PLFI543 / PLFW543 / PLFI544 / PLFW544 / PLFI750 / PLFW750 / PLFW812 / PLFL832 / PLFW832 user manual pro line[...]

Dear Valued Customer, Congratulations on your recent purchase of a new PROLINE range hood! To use your hood to its maximum potential, familiarize yourself with the controls and features of your new hood. This manual will step you through the installation of your hood, and how to maintain it. Read and use this care manual thoroughly, beginning with [...]

Table of Contents 1 Saftey Notice 1 2 Diagrams 2-7 Wall Hood . . . . . . . . . . . . . . . . 2 Control Panel . . . . . . . . . . . . . . . 3 Filters . . . . . . . . . . . . . . . . 4-5 Venting . . . . . . . . . . . . . . . . 6-7 3 Installation 8-15 Preparation . . . . . . . . . . . . . . 8 Wall Hood . . . . . . . . . . . . . . 9-11 Island Hood . . [...]

Installer: Leave this guide with the homeowner. Consumer: Keep this guide for future reference. The Important Safety Notice and warnings in this manual are not meant to cover all possible problems and situations that can occur. Use common sense and caution when installing, maintaining or operating this or any other appliance. Always contact the PRO[...]

warning ♦ If you receive a damaged product, immediately contact PROLINE Customer Support. Do not install or use a damaged hood. ♦ Do not install, repair or replace any part of the range hood unless specifically recommend- ed in the literature accompanying it. ♦ Use the range hood only for its intended purpose as outlined in this manual. DO NO[...]

2 | PROLINE ranGe HooDs Wall or Island Hood A - HOOD directs heat and smoke into the hood’s internal blower system. The blower forces heat and smoke from cooking into the chimney. B - CHIMNEY vents air from cooking to the outside of the home. C - CONTROL PANEL - controls the hood’s various features. D - FILTER(S) - prevent grease and grime from[...]

User manU al | 3 Control Panel Power: Turn on power to the hood by pressing the power button, on the left side of the control panel Speeds: There are 6 speeds on your hood. Press the plus or minus button(s) to increase or decrease the speed. The lowest speed is the quietest, and the highest speed is the most powerful. Section (A) of the display wil[...]

4 | PROLINE ranGe HooDs grease filters bafe lter To remove the aluminum filter, pull the spring loaded handle back toward the wall and down aluminum lter The baffle filter is equipped with a spring loaded handle. To remove from the hood, pull back toward the wall and down. The baffle filter can also be opened for easy cleaning. To open uns[...]

User manU al | 5 1. Remove the stainless steel or aluminum filters from the bottom of the hood. 2. Locate the existing raised support screws (A) on each side of the internal motor(s). 3. For each motor side, position charcoal filter over its support screw and rotate to lock into place. charcoal lter We recommend venting your hood directly outdoo[...]

6 | PROLINE ranGe HooDs venting options horizontal wall venting Option 1 Option 2 vertical roof venting[...]

User manU al | 7 height & venting requirements ♦ allow 28-36” between the top of your cooking surface and the bottom of hood ♦ vent vertically through the roof if possible ♦ vent through a side wall if you can- not vent directly above your range hood ♦ use 6” or 8” round (or 3-1/4 x 10” rectangular) metal ducting ♦ use as few [...]

8 | PROLINE ranGe HooDs preparation inspect range hood 1. Check contents of box: ♦ chimney ♦ ceiling bracket ♦ range hood ♦ flexible duct ♦ small bag of hardware 2. Test ♦ plug in and test controls, lights, fan ♦ inspect for any damage during shipping ♦ you must report any damage to Proline within 7 days for a refund tools you’ll [...]

User manU al | 9 Plan where the ductwork will be located. Install proper-sized duct work, and roof or wall cap, depending on where you will be venting your hood. Recommended and most com- mon installations are shown in the venting diagrams above. Adjust your measurements to accomodate heights of ceilings, cabinets, or rangetops. wall hood installat[...]

10 | PROLINE ranGe HooDs step 3 wall hood installation Hang hood and connect step 2 Install ceiling bracket ♦ Place the chimney bracket against the ceiling ♦ Find the center point of the bracket and mark it ♦ Line the bracket center point with the center point on the wall ♦ Mark the locations of bracket holes on wall ♦ Drill holes into th[...]

User manU al | 11 wall hood installation step 3 Install grease filter step 2 Install chimney ♦ Take off protective laminate coating ♦ Place the chimney on top of range hood base ♦ Make sure the chimney is facing the correct direction (the vertical vent should be on the top) ♦ Secure the lower portion of the chimney to the base of the hood ?[...]

12 | PROLINE ranGe HooDs island hood installation step 1 Locate the center above the stove where the hood is to be installed. Ensure that the bracket will be se- cured to solid wood backing. Install the duct work in the center of the bracket. Secure the upper end of the bracket to the ceiling. step 2 Attach the draft damper to the top of hood base.[...]

User manU al | 13 step 4 Attach the duct to the top of the back draft damper. Place the chim- ney sections over the lower bracket section and on top of the main unit. Attach lower bracket to upper brack- et at desired height using screws provided. step 5 Make your electrical connections. The hood comes with a grounded three prong plug that can eith[...]

14 | PROLINE ranGe HooDs hood insert installation step 1 Mark the leveling point of the hood. Position two mounting screws on the wall leaving 1/8” space between the wall and your hood. If you are installing under a cabinet, the hood should be flush with the front of the cabinet. Make sure you mount the hood on wall studs or lumbars for secure pl[...]

User manU al | 15 hood insert installation step 4 step 5 step 6 Align hood-mounting bracket to the screws on the wall and hook hood into place. Additional mount- ing fasteners may be used to further secure your hood. Use 6” or 8” round steel pipe to connect the exhaust on the hood to the ductwork above. Use silver tape or duct tape to make all [...]

16 | PROLINE ranGe HooDs Care & Cleaning warning ♦ Never put your hand into the area housing the fan while the fan is operating ♦ Turn off power to the hood before cleaning ♦ Make sure your cooktop and hood are cool before cleaning ♦ Use only the types of cleaning solutions mentioned in this manual ♦ Completely dry the filter(s) immed[...]

User manU al | 17 17 | PROLINE ranGe HooDs replacing the light bulb ♦ Make sure the range hood is unplugged or turn OFF breaker ♦ Place a flat-head screwdriver between light cover and housing to remove cover ♦ Gently pull defective bulb straight out and discard ♦ Wear a cotton glove or use a cloth to handle the replacement bulb (DO NOT hand[...]

18 | troubleshooting NOTHING WORKS (Control Panel not lit, Blower not working) Solution 1: Turn on power at circuit breaker panel or fuse box. Check for tripped breaker or blown fuse. Solution 2: Make sure hood main power switch is on. LIGHTS NOT TURNING ON Solution 1: see “nothing works” Solution 2: Swap out lights to determine if bulbs are de[...]

User manU al | 19 Warranty All PROLINE range hoods come with a Two Year Warranty on Parts, and a One Year Warranty on Labor. Who is Covered: Only the original purchaser for residential products purchased in the continental United States (limited warranty in Canada, Hawaii, and Alaska). Two Year Warranty - Parts & Labor For two years from the da[...]

20 | PROLINE ranGe HooDs Returns 1. You must report damage directly to PROLINE within 7 days to receive a full refund. 2. Send a photo showing the damage. We need this before we can approve your damage claim. 3. Once your claim is approved, we will arrange for a damage pickup. 4. A new replacement hood will be sent to you after the damaged hood has[...]

return claims not accepted if: ♦ Hood has been installed ♦ Hood has been custom cut or otherwise altered ♦ Damage is reported after 7 days ♦ Original packaging or parts are missing exchanges 1. You must request an exchange directly to PROLINE within 14 days. 2. Notify us of your reason for the exchange. Provide a photo if your hood is damag[...]

PRO LINE Range Hoods 1750 S 500 W Salt Lake City, UT 84115 • 1-877-901-5530 • www.prolinerangehoods.com[...]