Nexgrill 720-0025 LP manual

ASSEMBLY & OPERATING INSTRUCTIONS FOR OUTDOORS STAINLESS STEEL GAS GRILL FOR MODEL 720-0025 LP OUTDOOR GRILL[...]

TABLE OF CONTENTS SECTION ONE: SECTION FIVE: Precaution ----- ---------- ---------- -- ----2-3 Care and Maintenan ce ------------- --------14 Placement of The Grill --------- --------3 Troub leshooting ---------- ---------- --------15 SECTION TWO: SECTION SIX: Assembly Instructions -------- --------4-9 Grill Pa rts List-------- --------------------[...]

PRECAUTIONS FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flames. 3. Open lid. 4. If odor continues, immediately call your gas supplier. WARNING Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual. FOR YOUR SAFETY Do not store or use gasoline or other[...]

PRECAUTIONS When using the grill, do not touch the grill rack , burn er grate or immediate surrounding area as t hese areas become extremely hot and co uld cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns fr om steam . Do not use a towel or bulky cloth in place or pothol ders . Do not let pothol ders to[...]

Assembly Instructions PLEASE READ THE INSTRU CTIONS C AREFULL Y AND FOLLOW STEP BY STEP. TOOLS REQUIRED: Step 1: Assemble casters to bottom panel with ¼”-20x3/4” screws . Casters with brakes should be assembled on the mark “L” side of bottom panel. “L” Step 2: Assemble bottom panel to side pane ls with 5/32”-32x1/2” screws. 4[...]

Step 3: Align the holes on the mark “rear pane l - b” to the bottom panel. The n, assemble it with 5/32”-32x1/2” screws. Align the holes on the mark “rear panel - a” to the mark “rear panel - b”. Then, assemble it with 5/32”-32x1/2” screws. 5 “rear panel – a” “rear panel - b” Step 4: Align the door holes to the side pa[...]

Step 5: Assemble the door handles with 5/32”-32x1/ 4” screws as picture shown below. Step 6: Remove the upper portion of grill from ca rton. Insert the upper portion of the grill onto the cart from the top. Insert from the top 6[...]

Step 7: Assemble side burner with ¼”-20x1/2” screws. Ali gn the holes on the right side of g rill housing and screw through the holes in the right side. Ti ghten into the grill housing as per th e diagram below. Then tighten the gas hose to side burner valve. Repeat this step for the left side shelf. Step 8: Assemble push bar with ¼”-20x1/2[...]

Step 9: SIDE BURNER GAS HOSE ASSEMBLY The side burner PVC gas hose has attached on the valve manifold inside the grill cart, insert the gas hose to the hole on right panel of the grill, an d secure it on the gas hose connector under the side burner as shown in figure below. Step 10: Assemble the rotisserie kit as per th e diagram below: First locat[...]

Step 11: TO MATCH LIGHT THE GRILL If the burner will not light after several attempts then the burner can be match lit. If you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accum ulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Insert a lit extended match or lighter throug[...]

Your gas grill is ready to use. 10[...]

11 GAS HOOK-UP NEVER CONNECT AN UNREGULATED GAS SUPPLY LINE TO THE APPLIANCE. USE THE REGULATOR ASSEMBLY SUPPLIED. This is a liquid propane co nf igured grill. Do not attempt to use a natural gas supply unless the grill has been reconfigured got natural gas use. Total gas cons umption (per hour) of the lar ge stainless steel gas grill with all burn[...]

TO TEST Make sure all control valves are in th e “OFF” position. Turn the gas supply on. Check all connections from the L.P. cylinder u p to and in cluding t he connection to the manifold pi pe assembly (the pipe that g oes to the burner). Soap bubbles will appear where a leak is present. If a leak is pre sen t, immedi ately turn off gas supply[...]

OPERATING INSTRUCTION General use of the grill an d rotisserie Each burner is rated at 12,000 Btu/hr. Th e grill b urners encompass the entire c ooking ar ea and are side ported to minimize blockage from falling grease and debris. Above the burne r s are stainle ss steel radiated. The igniter knobs are located on the l o wer center portio n of the [...]

GRILL LIGHTING INSTRUCTIONS WARNING: I MPORTANT! BEFORE LIGHTING… Inspect the ga s supply piping or hose p rior to turni ng the gas “ON”. If there is e vidence of cuts, wear, or abrasion, it must be replaced prior t o us e. Do not use the grill if the odor of gas is presen t. The pressure regulator and ho se assembly suppl ied with t he unit [...]

sand very lightly with dry 100 grit emery papers in the direction of t he grain. Specks of grease ca n gather on the surfaces of the stainless steel and bake on to the surface and give the a ppearance of rust. For rem oval use an abrasive pad in conjunction w ith a stainless steel cleaner. GRILL RACK The easiest way to clean the grill is immediatel[...]

CHECKLIST PROBLEMS WHAT TO DO Grill won’t light when the ignition button is push ed. Remove the grill rack and th e rad iant tray. With a mirror, watch the igniter tip. You should see a spark jump from the tip of the igniter when the button is pressed. Yo u should als o hear a repeat ing cli ck. If there is no spark a nd no click, re place the ba[...]

Part List ILLUSTRATED PARTS BREAKDOWN Model 720-0025 LP Outdoors Gas Grill 17[...]

MODEL 720-0025 PARTS LIST REF# DESCRIPTION QTY PART# REF# DESCRIPTION QTY PART# 1 DOUBLE LAYER LID 1PIECE BBQ49001 21 ROTSSERIE KIT 1PIECE BBQ49023 2 THERMOMETRE 1PIECE BBQ49002 22 PUSH BAR, SIDE SHELF 1PIECE BBQ49024 3 LOGO 1PIECE BBQ49003 23 SIDE SHELF 2PIECES BBQ49025 4 HANDLE, FRONT LID 1PIECE BBQ 49004 24 RIGHT DOOR W/ CONDIMENT TRAY 1SET BBQ4[...]

GRILL COOKING CHART FOOD WEIGHT OR THICKNESS FLAME SIZE APPROXIMATE TIME SPECIAL INSTRUCTIONS AND TIPS VEGETABLES Fresh Slice. Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Beets Medium 12 to 20 m inutes Carrots Turnips Grill, turning once. Brush occasionally with melted butter or margarine. Onion 1/2 inch sli [...]

FOOD WEIGHT OR THICKNESS FLAME SIZE APPROXIMATE TIME SPECIAL INSTRUCTIONS AND TIPS Tenderloin, Porterhouse, T-Bone, Sirloi n Rare 1 inc h High 8 to 14 m inute s Remove exces s fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once. 1-1/2 inc h High 11 to 1 8 minutes Medium 1 inch Medium to 12 to 22 m inutes 1-1/2 inc h High 16 [...]

Breasts well-d one Medium 30 to 45 m inutes FOOD WEIGHT OR THICKNESS FLAME SIZE APPROXIMATE TIME SPECIAL INSTRUCTIONS AND TIPS FISH AND SEAFOOD Steaks Grill, turning once. Brush withmelted butter, margarine or oil to keep moist. Halibut 3/4 t o 1 inch Medi um to 8 to 15 mi nutes Salmon High Swordfish Whole Catfish 4 t o 8 ounces Medium to 12 t o 20[...]

GRILL RECIPE SUGGESTIONS BBQ SALMON 2 large salmon steaks 2 tbs. Oil Salt & pepper 2 oz. thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice Spring of parsl e y Lemon wedges Preheat the BBQ. Brush the stea ks with oil and season with salt and pepper. Place on BBQ grill and cook for 10 minutes, turni ng stea ks over halfway cooking ti me. Meanwhi[...]

VEGETABLE KABOBS 3 medium -sized z ucchini 12 cherry tom atoes 12 fresh m ushrooms Grated Parmesan c heese Parboil whole zucchini 5 minutes on your side burner or until ju st tender. Drain and cut into ½ inch slices. Thread zucchini, tom atoes and mushrooms alternately on each of six skewers. Brush with marinade m ade of Italian d ressing, Worcest[...]

Turn your rotis burn er on high. Rotis for 50 minutes or until done. PORK ROAST Apple cider vinega r basting sauce: 1 c. apple cider vinegar 6 oz. water ½ stick butter Salt, peppe r, parsley an d garlic seasoning 2 oz. lemon juice 10 lbs. po rk roast Time: 1-1/ 2 ho urs to 2 hours Bring pork to room temperatur e before placi ng it on t he spit ro [...]

LIMITED WARRANTY MODEL 720-0025 STAINLESS STEEL OUTDOOR GAS GRILL NEXGRIL L INDUSTRI ES, INC. warran ts to the original con sumer purcha ser of each Outdoor Gas Grill that when subject to nor mal residential use, it is free from defects in w orkmanshi p and m aterials for t he periods s pecified below. This warranty excludes grills used in ren tal [...]