Craftsman 139.53625SR manual

/ ® Owners anual 00000 Garage Door Opener Model Model Model Model Model 139.53315SR ", 1/3HP 139.53415SR- 1/2HP 139.53615SR = 1/2HP 139.53625SR - 1/2HP 139.53699SR _ 1/2HP FASTEN THIS MANUAL NEAR THE GARAGE DOOR AFTER INSTALLATION, PERIODIC CHECKS OF THE OPENER ARE REQUIRED TO INSURE SATISFACTORY OPERATION. FOR RESIDENTIAL USE ONLY, , ,= ,= ,[...]

Start By Reading These important Safety Rules , H ,,,,,,,,,,,,I, JL , = ' ' L L== ,===1,,, =,, H NH,,= ,, THIS SAFETY ALERT SYMBOL MEANS CAUTION _-- PERSONAL SAFETY OR PROPERTY DAMAGE INSTRUCTION, READ THESE INSTRUCTIONS CAREFULLY, THIS GARAGE DOOR OPENER IS DESIGNED AND TESTED TO OFFER REASONABLY SAFE SERVICE PROVIDED IT IS INSTALLED AND[...]

O Serat,on of Your Opener BEFORE YOU PROCEED, PLEASE READ THE e DO NOT PERMIT CHILDREN TO PLAY IN DOOR SAFETY RULES ON PAGE 2 AND OPERATING AREA. INSTRUCTIONS ON THIS PAGE CAREFULLY. e OPERATE ONLY WHEN OPENER IS PROPERLY TO AVOID DIFFICU/L,TY DURING INSTALLATION, DO ADJUSTED AND THE DOOR IS VISIBLE AND NOT RUN OPENER UNTIL INSTRUCTED TO DO SOs UNO[...]

1, Motor: Permanently lubricated with automatic reset. 2., Opener Light: Turns on and off automatically with 4¥2 minute illumination for your safety and convenience & Safety System: Independent up and down force adjustment, The door reverses automatically when obstructed in DOWN direction The door STOPS when obstructed in UP position 4. Easy L[...]

mi ................................ , ......... _ 1,1,1 ii nl ii, ii nnll u,i ,i i, lul,, u ¸ i ul ii ii i,! i i,i, CARTON CHECK LIST SEARS has packaged your GARAGE DOOR OPENER in two cartons which contain all the parts and hardware illustrated below and on Page 22. Rag Lighl Transmitters (21, Touch Code Mini Cover Grease Lens exce._ 53415, 53315 [...]

Assembly TO AVOID INSTALLATION DIFFICULTIES, DO NOT RUN THE GARAGE DOOR OPENER UNTIL INSTRUCTED TO DO SO. STEP 1 Assemble Tee Rail & Attach Cable Pulley Bracket J= = = ,=,,H = H H= ,,,, u,,,,,,,,,, , =J,,,,, , ,, ,,,,, ='== =,= =,,,,,,,, ,i ,,, ,,,= ! CAUTION: Do not tighten the lock nuts until bolt necks ate seated in square holes, _14&qu[...]

Assembly i iiii n ,1,1, i, i, i ii ,uu, ,,11 u11,,i null , STEP 2 Install Trofley Ul illUU,,lll 11111 J,Ul i iiii ii I,,llLJ I u I AS A TEMPORARY STOP, INSERT A SCREWDRIVER T,oHE %.,f_.,_ y _,_ INTO HOLE IN FRONT END OF TEE RAiL AS SHOWN. _----_ 1, At_ch threaded shaft to trolley with tockw_her and nuts _ ,," __ - as shown .fr" .-" 2[...]

Assembly i i iii ii, iii, ,JIJ,,llJ,lL,II I,,,,,,',, STEP 4 , iiii i111 ,!l ii, ,i,,,11,,11 i, i, ii ,i i Install Chain and Cable Lii iii ii iiiiiiiiii I IIIII ii III II ii ,11,111111 Lii _11 ii1 DO NOT REMOVE CHAIN AND CABLE FROM CARTON. Detach cable from side of carton and fasten to trolley with a master link from coin envelope, MASTER LINK [...]

Assembly Hit I i, ,,i I III I ,I, STEP 5 , ,, , H,,"H I I="= I IIIlllll II I , H,,I Tighten the Chain and Cable HI ,I,,H,, , .................................. Loosen Lock Tighten Tro({_ Chin i Base of Tee R_I .,-.--- 1/2 Inch CAUTION: Keep the chain from twisting as nuts are turned. PROCEDURE: Thread the outer nut toward troltey as shown[...]

installation i,! ,i ii, iiii i, ,i,,i i, STEP 1 iiii1,11 i i i i , ii iiii...:: ....... iii iiii L ii iiiiiii ,11 iiiii Position and Instafl Header Bracket installation procedures vary according to garage door types. Follow only those instruc- tions which apply to your door as tllustratedo i i iii i IL iii i .... := THE HEADER BRACKET MUST BE RIGID[...]

|n3tallation .... ii H i ml ,i ii ill ii , _ ,,, ,, ............. , i! i i nl I,,,IL ,i,n i,,,i,i, STEP 2 Attach Tee Rail to Header Bracket Pac_king M.atedal PROCEDURE: Position opener chassis on garage floor below the header bracket, Use packin 3 matedaI base to protect cover° NOTE: To enable the Tee rail to clear sectional door springs, it may b[...]

In.otallation .,,,,,,, , i ii ,11,1,! ,11 i,, N, i1,, , ,,,, i ,,,,, STEP 4 Hang Opener Chassis THE OPENER CHASSIS MUST BE SECURELY FASTENED TO A STRUCTURAL SUPPORT OF GARAGE. Three representative installations are shown. Yours may be different. Hanging brackets should be angled (Fig.l) or crossed (Fig.2) to provide rigid support, On finished ceili[...]

installation i, u,,,, i,,,. i, ,u i STEP 6 Install Waft Push Button i i i, i, ii ii ,,11 nl, liH,m LOCATE WALL PUSH BUTTON (OR ANY ADDITIONAL PUSH BUTTONS) WHERE THE GARAGE DOOR IS VISIBLE, AWAY FROM DOOR AND DOOR HARDWARE AND OUT OF THE REACH OF CHILDREN, " SERIOUS PERSONAL INJURY FROM A MOVING GARAGE DOOR MAY RESULT FROM MISUSE OF THE OPENER[...]

]nstaliation ILL II II I II ,_l!l,, I II,I, I,, I,,,, I I Ill STEP 7 Install Light and Lens ............... ii ll,, ill i ,, i , i,i ,i ,,i INSTALLING LIGHT: Install a 75 watt maximun light bulb in socket as shown° The light will turn on and remafn lit for 4-1/2 minutes when power is connected,, After 4d12 minutes it will turn off_ If light bulb b[...]

Installation H i,ill nl i i i ill ii m,ll,iHii iH, i nl i!................ ,,, , rl, ill,, it i i,u,lll STEP 9 Instau Door Bracket and Plate Follow instructions which apply to your door type as illustrated below. TO PREVENT DAMAGE TO LIGHTWEIGHT AND METAL GARAGE DOORS (OR ONES WtTH GLASS PANELS), ALWAYS REINFORCE THE INSIDE OF DOOR--BOTH VERT1C..AL[...]

nstallation ....................... ,,,., , u,,..., ,,, , , i .,.,,, i, . STEP 10 Connect Door Arm to Trolley Follow only those instructions which apply to your door type° H,, ,,, ,.,, i,,, ii , i,, , ,m H,,,, ,,, ,t , , i , SECTIONAL DOOR INSTALLATION Make sure garage door is closed tighL Pull the emergency release handle to disconnect the trolle[...]

Adjustment = u ,1, ,u.,imu. 1, ,,,,,1 i i, ulul , _LL,,II, IIII II ' ,,,", STEP 1 Adjust LIMIT ADJUSTMENT settings regulate the points at which the door will stop when mowng up or down. NOTE: Door STOPS in the UP direction if anything interferes with door travel. Door REVERSES in the DOWN direction if anything interferes with the door tra[...]

Adjustment .......... irll STEP 3 Test Safety Reverse System ii ............................... ii IIIIIL i ii THE SAFETY REVERSE SYSTEM TEST IS IMPORTANT. GARAGE DOOR MUST REVERSE ON CONTACT WITH A ONE INCH OBSTACLE PLACED ON THE FLOOR. FAILURE TO PROPERLY ADJUST OPENER MAY RESULT IN SERIOUS PERSONAL INJURY FROM A CLOSING GARAGE DOOR. REPEAT TEST [...]

Radio Controls EC.C. rules prohibit adjustments to or modification of receiver and transmitter circuitry except for changing the code setting and replacing the transmitter battery THERE ARE NQ OTHER USER SERVICEABLE PARTS Manufactured under ! or more of the fol_owlng U.S. patents: RE2g_525; 4,03"7,201; 4,750,1t8; 4,806,930 Your 53000SR SERIES [...]

!taving a Problem? Review Pages 2 and 3 Before Proceeding SITUATION i,,N i,ii ii i i OPENER DOESN'T OPERATE FROM EITHER THE WALL PUSH BUTTON OR TRANSMITTER PROBABLE CAUSE & SOLUTION 1 Have you disengaged all door tocks? Review Step 8, page 14r 2 Does the opener have electric power? Plug a tamp into the outiet. If it doesn't light, che[...]

Having a Problem? (continued) SITUATION PROBABLE CAUSE & SOLUTION ,,, i i i ,i i , I,H,m Ill ,.,.,I,,, ,..,,m . , I, .., I DOOR REVERSES FOR NO APPARENT REASON 1 Is something obstructing the door? Pull red emergency reteas handle Operate door manuafly If it is unbalanced or binding, call a garage door serviceman _o correct the problem. 2. Clear[...]

Repair Parts RAIL ASSEMBLY PARTS LIST 5 6 KEY PART NO. NO,, DESCRIPTION 1 2 3 4 5 6 7 1A995 41B3244 4tB3243 2B313 183B93 4IB2616 4tA3473 41A3534 Master link kit Outer trolley Inner trolley Tee rail-center section Tee rail-end section (each) Cable pulley bracket assy Chain and cabte NOT SHOWN Rail assy hardware kit (includes hardware illustrated on [...]