Avalon Arbor manual

A r b o r Wood Stove Owner's Manual • Freestanding Stove • Mobile-Home Approved • Alcove Approved • Hearth-Stove Approved Save these instructions for future reference S A FE TY N OTIC E : If thi s appl i anc e is not properly ins tal l ed, a house fi re may re sult. For y our s afe ty, fol low the i nstall ation d i r ecti on s. C onta[...]

2 Introduction © Travis Industries 100-01190_000 4070326 Introduction We welcome you as a new owner of an Arbor wood-burning stove. In purchasing an Arbor you have joined the growing ranks of concerned individuals whose selection of an energy system reflects both a concern for the environment and aesthetics. The Arbor is one of the finest applianc[...]

Table of Contents 3 © Travis Industries 100-01190_000 4070326 General Information Introduction & Important Information ...................... 2 Safety Precautions ............................................ 4 Features & Specifications .................................... 6 Stove Installation Planning the Installation .....................[...]

4 Safety Precautions © Travis Industries 100-01190_000 4070326 The viewing door must be closed and latched during operation. Never block free airflow through the air vents on this appliance. Gas Gasoline or other flammable liquids must never be used to start the fire or "Freshen Up" the fire. Do not store or use gasoline or other flammab[...]

Safety Precautions 5 © Travis Industries 100-01190_000 4070326 Mobile Home When installed in a mobile home, this appliance must be bolted to the floor, have outside air, and not be installed in the bedroom (Per H.U.D. requirements). Check with local building officials. Do not place clothing or other flammable items on or near this appliance. Never[...]

6 Features & Specifications © Travis Industries 100-01190_000 4070326 Installation Options • Freestanding • Freestanding in an Alcove • Freestanding in a Mobile Home • Freestanding Hearth Stove Features • EPA Phase II Approved • 2.3 Cubic Foot Firebox Volume • Single Operating Control • Accepts Logs Up to 21” Long • Cast Ir[...]

Stove Installation (for qualified installers only) 7 © Travis Industries 100-01190_000 4070326 SAFETY NOTICE: P lease r ead t his en t ir e m an u al b efo r e yo u in stall an d u se you r n ew r o o m h eat er . F ailur e to f o llo w in st r u c tio n s m ay r es u lt in p r o p er t y d a m ag e , bo d il y injur y, or even death . C ontac t l[...]

8 Stove Installation (for qualified installers only) © Travis Industries 100-01190_000 4070326 Floor Protection Requirements • Floor protection must extend 6" to the sides and rear of the stove and 16" to the front of the stove 39.25” wide by 44.875" deep - see Figure 2 and Figure 3 ). • Floor protection must be non-combustibl[...]

Stove Installation (for qualified installers only) 9 © Travis Industries 100-01190_000 4070326 Top View - Straight Installation Measure rear and side clearances from the nearest edge of the stove top. Floor Protection 27-1/4” 22-7/8” 16” Min. Measure front clearances from the face of the stove (door opening). 6” Min. 6” Min. Clearance A [...]

10 Stove Installation (for qualified installers only) © Travis Industries 100-01190_000 4070326 Bypass Handle Installation See Figure 4 for details on installing the bypass handle. Line up the set screws on the bypass handle with the dimples on the bypass shaft. Tighten with the included 1/8” hex wrench. 1/8" Hex Figure 4 Rear Vent Configur[...]

Stove Installation (for qualified installers only) 11 © Travis Industries 100-01190_000 4070326 Chimney Connector Requirements • Chimney connector is required from the flue collar of the stove to the factory-built chimney (see Figure 7 ) or masonry chimney (see Figures 13, 14, and 15). • The chimney connector must be 6” diameter and a minimu[...]

12 Stove Installation (for qualified installers only) © Travis Industries 100-01190_000 4070326 Chimney Requirements • DO NOT CONNECT THIS UNIT TO A CHIMNEY FLUE SERVING ANOTHER APPLIANCE. • UL 103 HT Chimney must be used from the first ceiling or floor penetration to the chimney cap. • Use 6" diameter type UL 103 HT chimney from one ma[...]

Stove Installation (for qualified installers only) 13 © Travis Industries 100-01190_000 4070326 Chimney Termination Requirements • Must have an approved cap (to prevent water from entering) • Must not be located where it will become plugged by snow or other material • Must terminate at least 3' above the roof and at least 2' above [...]

14 Stove Installation (for qualified installers only) © Travis Industries 100-01190_000 4070326 Alcove Installation Requirements Whenever the stove is placed in a location where the ceiling height is less than 8' tall, it is considered an alcove installation. Because of the reduced height, the special installation requirements listed below mu[...]

Stove Installation (for qualified installers only) 15 © Travis Industries 100-01190_000 4070326 Mobile Home Requirements • Outside air must be installed - see "Outside Air Requirements" on page 13 • Chimney connector and chimney must be one of the following types: AMERI-TEC model DCC connector with AMERI-TEC UL 103 HT chimney DURAVEN[...]

16 Stove Installation (for qualified installers only) © Travis Industries 100-01190_000 4070326 Standard Ceiling with a Factory Built Chimney Chimney Cap (See the section "Chimney Termination Requirements" for more details) Chimney Sections Minimum Air Space to Combustibles (See Chimney Manufacturer's Instructions - usually 2")[...]

Stove Installation (for qualified installers only) 17 © Travis Industries 100-01190_000 4070326 Hearth Stove Positive Connection NOTE : Most factory-built chimney manufacturers make stainless steel chimney liners, either flexible or rigid. This provides a wide variety of installation options. Make sure to follow the manufacturer's instruction[...]

18 Stove Installation (for qualified installers only) © Travis Industries 100-01190_000 4070326 Interior or Exterior Masonry Chimney NOTE: This type of installation requires a UBC approved masonry connector or other method approved by the NFPA 211 standard. See Chimney Connector Requirements on page 11 for further details. Make sure the clean-out [...]

Operating Your Appliance 19 © Travis Industries 100-01190_000 4070326 Safety Notice If this appliance is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation inspection requirements in your area. Read and follow all of the [...]

20 Operating Your Appliance © Travis Industries 100-01190_000 4070326 Opening the Doors Typically the doors are only opened to start the fire. Use the Loading Lid to re-load the stove. Swing the doors open. WARNING : Do not swing the doors past 90 ° . This may cause the doors to strike the body of the stove and cause damage. NOTE : When closing t[...]

Operating Your Appliance 21 © Travis Industries 100-01190_000 4070326 Bypass Operation The bypass controls the flow of smoke inside the heater. When open, smoke goes directly up the flue, creating more draft. When closed, the smoke goes through the combustor, utilizing the secondary combustion system and making the heater more efficient. • When [...]

22 Operating Your Appliance © Travis Industries 100-01190_000 4070326 Starting a Fire Since the dawn of time man has debated the best way to start a fire. Some use the boy-scout "tee-pee", some prefer the "tic-tac-toe" stack. Either way, review the hints and warnings below to ensure proper fire starting. • Make sure the air c[...]

Operating Your Appliance 23 © Travis Industries 100-01190_000 4070326 Adjusting the Burn Rate Use the air control slider to control the burn rate of the stove. See the illustration below for details. Low Burn (air control closed) High Burn (air control open) Use the air control to change the burn rate. Approximate Air Control Settings Overnight Bu[...]

24 Operating Your Appliance © Travis Industries 100-01190_000 4070326 Ash Removal ASHES Ashes should be placed in a metal container with a tight fitting lid. The closed container of ashes should be placed on a noncombustible floor or on the ground, away from all combustible materials, pending final disposal. If the ashes are disposed of by burial [...]

Operating Your Appliance 25 © Travis Industries 100-01190_000 4070326 Blower Operation The blower is available to assist the convection chamber in distributing heat to your home. The directions below detail the options you have with the blower and the best method for operation. OFF Turn the dial all the way counter- clockwise until it clicks off. [...]

26 Operating Your Appliance © Travis Industries 100-01190_000 4070326 Hints for Burning • Get the appliance hot before adjusting to low burn • Use smaller pieces of wood during start-up and high burns to increase temperature • Use larger pieces of wood for overnight or sustained burns • Stack the wood tightly together to establish a longer[...]

Operating Your Appliance 27 © Travis Industries 100-01190_000 4070326 Troubleshooting Problem Possible Cause Smoke Enters Room During Start-Up • Open the bypass (pg. 21). • Open the air control (pg. 23). • Cold Air Blockage - burn a piece of newspaper to establish a draft. • If the flame is not getting enough air, a small crack in the door[...]

28 Maintaining Your Appliance © Travis Industries 100-01190_000 4070326 Failure to properly maintain and inspect your appliance may reduce the performance and life of the appliance, void your warranty, and create a fire hazard. Daily Maintenance (while stove is in use) Remove Ash (if necessary) • Ash removal is not required once it builds up. 1/[...]

Maintaining Your Appliance 29 © Travis Industries 100-01190_000 4070326 Monthly Maintenance (while appliance is in use) Make sure the appliance has fully cooled prior to conducting service. Door and Glass Inspection The door must form an air-tight seal to the firebox for the stove to work correctly. Inspect the door gasket to make sure it forms an[...]

30 Maintaining Your Appliance © Travis Industries 100-01190_000 4070326 Yearly Maintenance Make sure the appliance has fully cooled prior to conducting service. Touch Up Paint Included with the owner's pack of this appliance is a can of Stove-Brite® paint. To touch up nicks or dulled paint, apply the paint while the appliance is cool. Sand r[...]

Maintaining Your Appliance 31 © Travis Industries 100-01190_000 4070326 Door Parts 5 9 8 10 4 3 7 2 6 1 ID # Description Qty Part # ID # Description Qty Part # 1 Door, Left 1 2 Door, Right 1 3 Door Gasket 1 4 Gasket Cement 1 5 Glass Gasket 1 6 Glass 2 7 Glass Clip w Screws, Gasket 4 8 Door Hinge w Pins 4 9 Left Door Handle w Hardware 1 10 Right Do[...]

32 Maintaining Your Appliance © Travis Industries 100-01190_000 4070326 Firebox Parts 4 2 1 1 7 9 6 3 5 8 7 ID # Description Qty Part # ID # Description Qty Part # 1 Side Brick 2 250-00139 2 Combustion Brick 1 250-00141 3 Interram Gasket 1 250-00294 4 Back Brick 1 250-00140 5 Firebox Back 1 6 Combustor 1 250-00247 7 Brick Clips with Bolts 1 250-00[...]

Limited 5 Year Warranty 33 © Travis Industries 100-01190_000 4070326 To register your TRAVIS INDUSTRIES, INC. 5 Year Warranty, complete the enclosed warranty card and mail it within ten (10) days of the appliance purchase date to: TRAVIS INDUSTRIES, INC., 4800 Harbour Pointe Blvd. SW, Mukilteo, WA 98275. TRAVIS INDUSTRIES, INC. warrants this appli[...]

34 Limited 5 Year Warranty © Travis Industries 100-01190_000 4070326 CONDITIONS & EXCLUSIONS 1. This new appliance must be installed by a qualified installer. It must be installed, operated, and maintained at all times in accordance with the instructions in the Owner’s Manual. Any alteration, willful abuse, accident, neglect, or misuse of th[...]

Listing Information 35 © Travis Industries 100-01190_000 4070326 Listing Label[...]

36 Optional Equipment © Travis Industries 100-01190_000 4070326 Rear Blower Installation (Part # 99000138) The rear blower improves heat transfer by pushing heated air through the convection channel. Operating instructions are described in the section "Blower Operation". Route the wires on the outside of the stove, behind the convection [...]

37 Optional Equipment © Travis Industries 100-01190_000 4070326[...]

38 Index © Travis Industries 100-01190_000 4070326 Air Control (Adjusting the Burn Rate) ....................... 2 3 Alcove Installation Requirements ............................ 1 4 Ash Removal ......................................................2 4 Ash Removal ......................................................2 8 Ashpan ...................[...]