Pride Mobility SC2700 Bedienungsanleitung

Owner ’ s Manual Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility.com A TTENTION: Please read the content of your owners manual before operating your scooter . The Ultimate In S tyle & Performance ®[...]

SAFETY GUIDELINES Copyright © 2003 Pride Mobility Products Corp. INFMANU1950 Please read and follow all instructions in this owner  s manual before attempting to operate your scooter for the first time. If there is anything in this manual you do not understand, or if you require additional assistance for setup, contact your authorized Pride pro[...]

3 V ictory XL-4 /RevC/June03 www .pridemobility .com I. INTRODUCTION ............................................................................................................... 4 II. SAFETY ...................................................................................................................... ....... 6 III. EMI/RFI ..............[...]

4 www .pridemobility .com Victory XL-4/RevC/June03 I. INTRODUCTION W elcome to Pride Mobility Products Corporation (Pride). Congratulations on the purchase of your new Pride Scooter . Y our s cooter design combines the most advanced state-of-the-art components with modern, attractive styling. W e are certain that the design features and trouble-fre[...]

5 V ictory XL-4 /RevC/June03 www .pridemobility .com I. INTRODUCTION Pride Owners Club As a Pride product owner , you are invited to register your product s warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed registration card or by visiting Pride s web site at www .pridemobility .com . As a[...]

6 www .pridemobility .com Victory XL-4/RevC/June03 II. SAFETY GENERAL WARNING! Do not operate y our new scooter for the fir st time without completel y reading and understanding this owner s man ual. Y our scooter is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to best[...]

7 V ictory XL-4 /RevC/June03 www .pridemobility .com II. SAFETY PRE-RIDE SAFETY CHECK Get to know the feel of your scooter and its capabilities. It is recommended that you perform a safety check before each use to make sure your scooter operates smoothly and safely . For details on how to perform these necessary inspections, see XI. Care and Mai[...]

8 www .pridemobility .com Victory XL-4/RevC/June03 350 lbs 10˚ II. SAFETY Figure 1. Maximum Recommended Incline Angle When climbing an incline, try to keep your scooter moving. If you must stop, start up again slowly , and then accelerate cautiously . When driving down an incline, do so by setting the speed adjustment to the slowest setting and dr[...]

9 V ictory XL-4 /RevC/June03 www .pridemobility .com II. SAFETY CORNERING INFORMA TION Excessively high cornering speeds can create the possibility of tipping. Factors which affect the possibility of tipping include, but are not limited to, cornering speed, steering angle (how sharply you are turning), uneven road surfaces, inclined road surfaces, [...]

10 www .pridemobility .com Victory XL-4/RevC/June03 II. SAFETY OUTDOOR DRIVING SURF ACES Y our scooter is designed to provide optimum stability under normal driving conditionsdry , level surfaces composed of concrete, blacktop, or asphalt. However , Pride recognizes that there will be times when you will encounter other surface types. For this r[...]

11 V ictory XL-4 /RevC/June03 www .pridemobility .com II. SAFETY FREEWHEEL MODE Y our scooter is equipped with a manual freewheel lever that, when pulled up, allows the scooter to be pushed. For more information about how to place your scooter into and out of freewheel mode, see V . Y our V ictory XL-4. WARNING! W hen your scooter is in freew[...]

12 www .pridemobility .com Victory XL-4/RevC/June03 II. SAFETY DOORS n Determine if the door opens toward or away from you. n Use your hand to turn the knob or push the handle or push-bar . n Drive your scooter gently and slowly forward to push the door open. Or drive your scooter gently and slowly rearwards to pull the door open. ELEV A TORS Moder[...]

13 V ictory XL-4 /RevC/June03 www .pridemobility .com II. SAFETY GETTING ONTO AND OFF OF YOUR SCOOTER Getting onto and off of your scooter requires a good sense of balance. Please observe the following safety tips when getting onto and of f of your scooter: n Ensure that your scooter is not in freewheel mode. See V . Y our V ictory XL-4. n Ma[...]

14 www .pridemobility .com Victory XL-4/RevC/June03 II. SAFETY PRESCRIPTION DRUGS/PHYSICAL LIMIT A TIONS The scooter user must exercise care and common sense when operating his/her scooter . This includes aware- ness of safety issues when taking prescribed or over- the-counter drugs or when the user has specific physical limitations. WARNING! Consu[...]

15 V ictory XL-4 /RevC/June03 www .pridemobility .com III. EMI/RFI EMI/RFI W ARNINGS Laboratory tests performed by the Food and Drug Administration (FDA) have shown that radio waves can cause unintended motion of electric mobility vehicles. Radio waves are a form of electromagnetic ener g y (EM). When electromagnetic energy adversely affects the op[...]

16 www .pridemobility .com Victory XL-4/RevC/June03 III. EMI/RFI Are all electric mobility vehicles susceptible to EMI/RFI? Each make and model of electric mobility vehicle differs in its ability to resist EMI/RFI. Every mobility vehicle has a particular level of resistance to EMI/RFI. This resistance is measured in volts per meter (V/ m). A higher[...]

17 V ictory XL-4 /RevC/June03 www .pridemobility .com T urning Radius 5" 20.5" 20.5" 27" - 31" 43.5" - 45.5" 16.5" - 18.5" 69" 27" 24" 18" 18" 55" Figure 4. Victory XL-4 Dimensions Figure 4A. Victory XL-4 T ire Dimensions 13" 4" IV . SPECIFICA TIONS[...]

18 www .pridemobility .com Victory XL-4/RevC/June03 Mode l Number SC 2700 Avai labl e C o lor s Ca nd y Appl e Re d , V ip e r Bl ue , O n yx Bl a ck Ove ra l l Le ng t h 55 in . Ove ra l l Wi dt h 27 in. Total Weight Wi th out Batteries 217 lbs. Hea v i est Pi ec e When Di sass em b led R e ar se ction: 87. 5 lbs . Turning Radi us 69 in. Ma x i mu[...]

19 V ictory XL-4 /RevC/June03 www .pridemobility .com WARNING! Do not e xpose the contr ol console assembly to moisture. In the ev ent it does become exposed to moisture, do not attempt to oper ate your scooter until it has dried thor oughly . V . YOUR VICTOR Y XL-4 Y our scooter is an indoor/outdoor , motorized electric scooter designed to enhance[...]

20 www .pridemobility .com Victory XL-4/RevC/June03 V . YOUR VICTOR Y XL-4 Throttle Control Lever This lever allows you to control the forward and reverse speeds up to the maximum you preset with the speed adjustment dial. For instructions on how to operate the throttle control lever , see VII. Operation. Running Lights Switch This switch ena[...]

21 V ictory XL-4 /RevC/June03 www .pridemobility .com Handbrake Lever (Optional) Y our scooter may be equipped with a handbrake lever , located on the tiller handle. This lever pro- vides you with additional stopping power . Se e figure 7. n Release the throttle control lever and gently squeeze the handbrake lever to come to a stop. NOTE: If you do[...]

22 www .pridemobility .com Victory XL-4/RevC/June03 REAR SHROUD The rear shroud is a removable plastic piece that protects the rear section and its subcomponents. In order to remove the rear shroud, you must first remove the seat from your scooter and then lift the rear shroud gently until it disengages from the reusable fasteners holding it in pla[...]

23 V ictory XL-4 /RevC/June03 www .pridemobility .com V . YOUR VICTOR Y XL-4 Electronic Controller Module This module is located behind the batteries and at the forward left corner of the rear section. The electronic controller module receives electrical signals from the console controls and sends power to the motor , the brakes, and the lighting s[...]

24 www .pridemobility .com Victory XL-4/RevC/June03 V . YOUR VICTOR Y XL-4 Main Circuit Breaker (Reset Button) When the voltage in the batteries becomes low or your scooter is heavily strained because of excessive loads, the main circuit breaker may trip to protect the motor and electronics from damage. When the breaker trips, the entire electrical[...]

25 V ictory XL-4 /RevC/June03 www .pridemobility .com VI. BA TTERIES AND CHARGING Y our scooter requires two long-lasting, 12-volt, deep-cycle batteries that are sealed and maintenance free. They are recharged by an onboard char ging system. n Char ge your scooter s batteries prior to using it for the first time. n Keep the batteries fully charg[...]

26 www .pridemobility .com Victory XL-4/RevC/June03 VI. BA TTERIES AND CHARGING BA TTERY REPLACEMENT T o change a battery in your scooter: 1. Power down your scooter and remove the key . 2 . Remove the seat. 3 . Gently lift the rear shroud of f of your scooter high enough to be able to disconnect the rear lighting harnesses. See figure 12. 4 . Disc[...]

27 V ictory XL-4 /RevC/June03 www .pridemobility .com How often must I charge the batteries? T wo major factors must be considered when deciding how often to charge the batteries: n All day scooter use on a daily basis. n Infrequent scooter use. W ith these considerations in mind, you can determine just how often and for how long you should charge [...]

28 www .pridemobility .com Victory XL-4/RevC/June03 VI . BA TTERIES AND CHARGING Use these specifications to reorder deep-cycle batteries from your authorized Pride Provider: Why do my new batteries seem weak? Deep-cycle batteries employ a different chemical technology than that used in car batteries, nickel-cad- mium batteries (nicads), or in othe[...]

29 V ictory XL-4 /RevC/June03 www .pridemobility .com VI . BA TTERIES AND CHARGING What about public transportation? If you intend to use public transportation with your scooter , you must contact the transportation Provider in advance to determine their specific requirements. How should I store my scooter and its batteries? See XI Care and Main[...]

30 www .pridemobility .com Victory XL-4/RevC/June03 VII. OPERA TION BEFORE GETTING ONTO YOUR SCOOTER n Have you fully charged the batteries? See VI. Batteries and Char ging. n Is the manual freewheel lever in the drive (down) position? Never leave the manual freewheel lever pulled up unless you are manually pushing your scooter. GETTING ONT O[...]

31 V ictory XL-4 /RevC/June03 www .pridemobility .com VII. OPERA TION GETTING OFF OF YOUR SCOOTER 1. Bring your scooter to a complete stop. 2. Remove the key fr om the key switch. 3 . Push forward on the seat lock lever and rotate the seat until you are facing toward the side of your scooter. 4 . Make certain that the seat is locked securely in pos[...]

32 www .pridemobility .com Victory XL-4/RevC/June03 VIII. COMFORT ADJUSTMENTS TILLER ANGLE ADJUSTMENT Y our tiller is equipped with a tiller adjustment lever , which allows you to lock the tiller in place. See figure 14. T o adjust the tiller angle: 1 . T urn the tiller adjustment lever counterclockwise until it is loose. If the tiller adjustment l[...]

33 V ictory XL-4 /RevC/June03 www .pridemobility .com VIII. COMFORT ADJUSTMENTS Figure 15. Seat Height Adjustment LOWER SEA T POST UPPER SEA T POST HEX HEAD BOL T AND NUT Figure 16. Seat Adjustments SEA TBACK ADJUSTMENT T o adjust the recline angle of the seat: 1 . Pull up on the seat recline lever to unlock the seatback. See figure 16. 2. Lean for[...]

34 www .pridemobility .com Victory XL-4/RevC/June03 VIII. COMFORT ADJUSTMENTS ARMREST ADJUSTMENT There is an armrest adjustment dial on the underside of each armrest. T o adjust the armrest angle upward or downward while seated in your scooter: n T urn the armrest adjustment dial to the left to lower the armrest angle or to the right to raise the a[...]

35 V ictory XL-4 /RevC/June03 www .pridemobility .com VIII. COMFORT ADJUSTMENTS POWER SEA T (OPTIONAL) Y our scooter may be equipped with a power seat. The power seat actuator is designed to raise or lower the seat automatically with minimal ef fort on the part of the operator . See figure 18. T o operate your power seat: If the toggle switch is mo[...]

36 www .pridemobility .com Victory XL-4/RevC/June03 The V ictory XL-4 requires no tools for disassembly . Always disassemble or assemble your scooter on a level, dry surface with sufficient room for you to work and move around your scooter . Keep in mind that the disassembled sections of the scooter will take up more floor space than the assembled [...]

37 V ictory XL-4 /RevC/June03 www .pridemobility .com ASSEMBL Y 1 . Position the scooter halves as shown in figure 23. 2 . Lift up on the frame handle and push back on the seat post. 3 . Align the curved bracket of the front section with the mounting peg of the rear section and lower the front section onto the peg of the rear section. 4 . Pivot the[...]

38 www .pridemobility .com Victory XL-4/RevC/June03 X. TROUBLESHOOTING Any electromechanical device requires occasional troubleshooting. However , most problems that arise can usually be solved with a bit of thought and common sense. Many of these problems occur because the batteries are not fully char ged or because the batteries are worn down and[...]

39 V ictory XL-4 /RevC/June03 www .pridemobility .com XI . CARE AND MAINTENANCE Y our scooter requires a minimal amount of care and maintenance. If you do not feel confident in your ability to perform the maintenance listed below , you may schedule inspection and maintenance at your authorized Pride Provider . The following areas require periodic i[...]

40 www .pridemobility .com Victory XL-4/RevC/June03 X I. CARE AND MAINTENANCE WARNING! T he replacement fuse must e xactl y matc h the r ating of the new fuse. F ailure to use pr operl y rated fuses ma y cause dama ge to the electrical system and may result in personal injur y . WARNING! A lways protect batteries fr om fre ezing temper atures and n[...]

41 V ictory XL-4 /RevC/June03 www .pridemobility .com XII. OPTIONAL ACCESSORIES OPTIONAL ACCESSORIES For information concerning these optional accessories, contact your authorized Pride Provider . Rear Basket Single Cane/Crutch Holder Dual Cane/Crutch Holder Oxygen T ank Holder W alker Holder Forearm Crutch Holder Safety Flag Cup Holder Double Crut[...]

42 www .pridemobility .com Victory XL-4/RevC/June03 XIII. WARRANTY THREE-YEAR LIMITED WARRANTY Three years on all structural frame components; including platform, fork, seat post, and frame. Three-year prorata drive train warranty; including transaxle, motor , and brake. n First year: 100% replacement of parts cost n Second year: 67% replacement of[...]

182 Susquehanna A venue Exeter , P A 18643 1-800-800-8586 www .pridemobility .com[...]