Jotul Gas Stove Bedienungsanleitung

1 Installation and Oper ation Instructions GF 400 BV Sebago Gas Stov e IF THE INFORMA TION IN THESE INSTRUCTIONS ARE NOT FOLL OWED EXA CTL Y , A FIRE OR EXPLO- SION MA Y RESUL T CA USING PROPERTY D AMAGE, PERSONAL INJUR Y OR LOSS OF LIFE. FOR Y OUR SAFETY : DO NOT ST ORE OR USE GASOLINE OR OTHER FLAMMABLE V APORS AND LIQUIDS IN THE VICIN- ITY OF TH[...]

2 W elcome to J ø tul... Congr atulations on the purchase of your new Jøtul GF 400 BV Sebago gas stov e . W e at Jøtul are glad you’v e made the decision to warm your hearth with a Jøtul product . Y our new stove ex emplifies our experience gained ov er 150 years as the world’ s largest manufactur er of solid fuel burning appliances. We’ [...]

3 T able of C ontents Service T ools .............................................. 4 Specifications ........................................... 4 General Inf ormation ............................... 5 Safety Inf ormation .................................. 6 Installation R equirements Location ................................................. 6 Hea[...]

4 GF 400 BV Sebago Specifications The Jøtul GF400 BV Sebago is a atmospherically- vented gas fir eplace heater designed only for vertical venting dir ectly t o the outside of the house, using listed, T ype B-vent pipe. Input Rates Natural Gas 40,000 BTU /hr . maximum input 22,000 BTU /hr . minimum input Propane 40,000 BTU /hr . maximum input 20,00[...]

5 Gener al Inf ormation  THIS H EA TER MUS T B E I NS T ALLED AN D MAI NT AI N ED BY A QU ALIFI ED SERVICE AGENCY .  The installation and repair of this appliance must be done by a qualified service person. Failur e to properly install and maintain this heater c ould result in an unsafe or ha z a r dous installation, which may result in a fir[...]

6 Location In selecting a location f or the stove, consider the following poin ts: 1) Heat distribution 2) V ent termination requir ements 3) Gas supply line routing 4) T raf fic areas , furniture, draperies , etc . The GF 400 BV may be located on or near c onven- tional construction materials, however , proper clear ance to combustibles must be ma[...]

7[...]

8 V ent Requirements The GF 400 BV Sebago is specifically designed to oper ate using 4” T ype B vent pipe components or a Listed Fle xible gas liner . • All venting c omponents must be installed in accor - dance with the terms of their listing and manufa cturer’ s instructions. • The minimum height of a vertically terminated system shall be[...]

9 • When 6” diameter decora tive pipe is installed to co ver the venting any Listed Flexible Gas liner must be connected directly to the stove ’ s draft hood. • Use of single wall c onnec tor pipe as a vent is prohibited f or use with the GF400 Sebago B- V ent stov e. • A firestop is r equired at ev ery floor . • Any v enting that is ex[...]

10[...]

11 Fuel C onv ersion Procedure 1. T urn off gas supply to stove. 2. R emove the stov e T op Plate. 3. Disengage the two Glass Fr ame Latches at the top of the firebo x. See illustration on page 5. C arefully lif t the glass panel up and out of the stove. 4. If installed, remov e the Embers and Log Set using care not to damage the fragile log parts.[...]

12 7. Lift out the Burner Plate: NOTE : There are no screw s securing the Burner to the floor of the fir ebox. P ull the Air Shutter forw ard and lif t the burner together with shutter up and out of the stove as a unit. See fig . 13. 8. Change the Burner Orifice . Using a ½” open ended wrench or deep-well socket, remov e the burner orifice from [...]

13 Gas Supply C onnec tion The gas supply line connection is made to the left side of the front -mounted v alve. The gas supply line should be 3/8" npt with a 1/2" diameter supply , or the appropriate size to pro vide sufficient gas pr essure to the v alve regardless of the input setting . The use of Flexible Gas Appliance C onnectors is [...]

14 Gas Pressure Corr ect gas pressure is essential for ef ficient and safe opera tion of the GF 400 BV gas stov e. It is impor tant that the correct pressure is established a t the time of the installation. Proper gas pr essure provides a consistent flow of gas to the appliance and is instru- mental in checking for gas leaks. Pressure T est: Attach[...]

15 Log Set Installation Brick Kit Note: Install the optional Antique Brick Kit 155370 before installing the logset. See page 22 and the instructions provided with that kit . The GF 400 BV logset must be installed before oper ating the burner . The logset includes six log pieces, and a bag of ember stones packaged inside the fir ebox. T o install th[...]

16 Close Open Optional W all Thermostat or Remote C ontrol Use only a 750 milliv olt DC two-wire circuit thermostat with this appliance. The thermostat should be placed in the same room as the heater , typically 5 feet off the floor . Av oid dra fty ar eas or any ar ea that may affect the accuracy of the thermostat . The thermostat should be connec[...]

17 S ystem Check 1. PU RGI NG T HE GAS LI N E: When lighting the appli- ance for the first time, it will take a few moments to clear the gas line of air . Once this purge is complete, the appliance will opera te as described in the lighting instructions. See the inside back cov er of this manual or the stove Rating Pla te attached the bottom of the[...]

18 Oper ation F amiliarize yourself with the controls of the GF 400 BV . Make sure that anyone else using the appliance is also familiar with the c ontrols and opera tion procedures. Alwa ys follow the Lighting Instructions on the inside back cov er of this manual and also located on the Rating Plate attached to the burner assembly . 1. Once the pi[...]

19 Glass Car e Clean the glass only when necessar y . Wipe the surface with a clean, dampened, soft cloth. Follow with a dry , sof t towel. T ake care not to scra tch the glass surface. WARNING: DO NO T USE ABRASIVE CLEANERS ON THE GLASS. NEVER CLEAN THE GLASS WHEN IT IS HOT . Gask et Inspec tion It is impor tant that the glass gasket be inspected [...]

20      THIS BLO WER MUST BE ELECTRICALL Y GROUNDED IN ACCORD ANCE WITH LOCAL CODES OR, IN THE ABSENCE OF L OCAL CODES, WITH THE CURRENT ANSI/ NFP A 70, NA TIONAL ELECTRICAL CODE OR CSA C22.1-CANADIAN ELECTRICAL CODE.      THIS UNIT IS SUPPLIED WITH A THREE-PRONG (GR OUNDING) PL UG FOR PRO TECTION AGAINST SHOCK HAZARD [...]

21 Blower Oper ation The optional v ariable-speed blower will enhance heat circulation around the fir ebox and out into the room. The blower is controlled by a hea t ac tiva ted switch (snapstat) that will ON L Y func tion when the control switch is in A UT O setting . After the fir e has been burning for a time, the snapstat will react to the heat[...]

22 1. Remov e the T op Plate. Simply lift if up off of the stove body . It is not fastened. 2. Remov e the Glass F rame. Disengage the two compression latches loca ted at the top of the firebox and lif t the glass frame up and off of the stov e. See Fig. 1. 3. Remov e the Logset. These parts are not fastened. Simply lif t them out of the firebo x .[...]

23 High Altitude Adjustment Installations burning natur al gas and located at altitudes from 2000 - 4500 f t . (610 M - 1370 M), requir e compen- sation f or the thinner air (less volume of air per cubic f oot). Higher altitudes aff ect the atmospheric pressure and heat value of gaseous fuels. The lower oxygen con tent in the air and the lower gas [...]

24 ONL Y USE REPLACEMENT P ARTS PRO VIDED BY AN AUTHORIZED JØTUL DEALER. Figure 44 . GF 400 B V Sebago Illustr ated P ar ts Breakdown 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 11 32 33 34 35 36 37 38 39 41 40 42 43 44 45 11 47 48 49 50 51 11 53 54 55 56 57 58 59 60 61 62 63 64 65 19 67 2 2 2 68 69 70 71 72 73[...]

25 GF 400 BV Sebago P ar ts List 1. Co ver Plate, Draft Hood ........................................... 129183 2. Screw , #8 x 1/2” Hex ................................................ 117917 3. Knob, Rheosta t .......................................................... 220709 4. Rheostat, 26” Leads .............................................[...]

26 MODEL NAME: ________________________ SERI AL N UMB ER: ______________________ D A TE OF PURC HASE: ___________________ PURC HASED FR OM: ____________________ NAME OF IN ST ALLER: ___________________ TYPE OF FU EL: ________________________ W A S S T OVE C ONVERTED? _______________ NO TES: GF 400 BV Sebago R ecor d the following informa tion to he[...]

27 3. Access the lower controls. 4. Depress gas c ontrol knob slightly and turn clock - wise to “OFF” . Do not force. FOR Y OUR SAFETY , READ BEFORE LIGHTING. LIGHTING INSTR UCTIONS T O TURN OFF GAS T O THE APPLIANCE: LIGHTING INSTR UCTIONS WARNING: IF Y OU DO NOT FOLL OW THESE INSTR UCTIONS EXACTL Y , A FIRE OR EXPLOSION MA Y RESUL T CAUSING P[...]

28 Jøtul ASA P .O . B ox 1411 N-1602 Fr edrik stad Norwa y Jøtul North America 55 Hutcherson Drive Gorham, Maine 04038-2634 November 2005 138301-B This appliance must be installed in conformance with local and na tional building regulations. Befor e beginning the installation, it is important that the these instruc tions be carefully read and und[...]